Beruflich Dokumente
Kultur Dokumente
A D J U S TA B L E
FREQUENCY DRIVE
AF-300 C11
The AF-300 C11 drive is designed for use in small machines such as fans and
conveyors, as well as other machines in which motor speeds can vary. The AF-300 C11
series is available in thirteen models, from 1/8 to 5 hp, allowing you to select the model
that best suits your application. The AF-300 C11 only requires power and motor
connections to the built-in
terminal block for use.
Easy-to-follow programming
and output frequency can be
set and adjusted using the
keypad panel. Quick response
time delivers reliable operation against load fluctuation.
Self-diagnostics provide
shut-off protection and fault
failure messages. Each unit
also has a standard frequency setting POT mounted on
the face of the drive for quick
adjustments and standard
built-in PID loop.
Selectable functions
include operating
method/frequency
setting, base and
top frequency, maximum output
frequency, torque boost, DC
braking, accel/decel, multifrequency settings, and motor
sound adjustments.
Enclosure
Installation Location
IP20
Do not install in locations where product could be exposed to dust, corrosive gas, inflammable
gas, oil mist, vapor, water drops, or direct sunlight. There must be no salt in the atmosphere.
Condensation must not be caused by sudden changes in temperature. For use at altitudes of
3300 ft. (1000m) or less without derating.
-10C to +50C (+14F to +122F)
5 to 95% RH (non-condensing)
3mm:
2 to less than 9 Hz
9 to less than 20 Hz
9.8m/s2:
20 to less than 55 Hz
2 m/s2:
55 to less than 200 Hz
1 m/s2:
-25C to +65C (-4F to +149F)
Ambient Temperature
Ambient Humidity
Vibration
Storage Temperature
Input Frequency
Output Frequency
Power System
Setting
Maximum frequency:
50 to 120 Hz (in 1 Hz steps)
Base frequency:
25 to 120 Hz (in 1 Hz steps)
Starting frequency:
1 to 6 Hz (in 1 Hz steps)
Digital setting: 0.01% of maximum frequency (from -10C to +50C)
Analog setting: 1.0% of maximum frequency (at 25C 10C)
Digital setting: 0.1 Hz (99.9 Hz or less), 1 Hz (100 Hz or more)
Analog setting: 1/256 of maximum frequency (ex. 0.23 Hz for 60 Hz, 0.47 Hz for 120 Hz)
Accuracy (Stability)
Setting Resolution
Control
Control Method
Operation Method
Frequency Setting
Indication
Acceleration/Deceleration Time
Voltage/Frequency (V/F)
Characteristics
PID Control
Restart After Momentary
Power Failure
Frequency Limiter
Bias Frequency
Frequency Jump Control
Torque Boost
Starting Torque
Protection
Overload
Instantaneous Overcurrent
Overvoltage
Overheating
Motor Protection
Alarm Output
Options
Standard
Communications
BAUART
GEPRFT
TV
Rheinland
Product Safety
GEA-S1021
000502
FERGADV
TYPE
APPROVED