Beruflich Dokumente
Kultur Dokumente
Download the runtime file that correspond to the desired software version
from the Nortel Support Portal at http://www.nortel.com/support.
The file used in this procedure is p16a1230.img.
Connect to the switch through the console port using an appropriate terminal
or terminal emulation software. Refer to Console Port Settings on page 10
for connection parameters.
Reset the switch using the reset command. This command has the
following syntax:
reset [-y]
Disconnect the console session, change the connection baud rate to 115200,
and reconnect.
Using the options available in the terminal emulation software, use a Zmodem
transfer to move the software image (p16a1230.img) acquired in step 1 to the
switch.
After the file transfer is complete, the switch will load the new runtime image.
Disconnect the terminal session, change the baud rate to 9600, and reconnect.
The switch will boot with the Software Release 1.x software.
321327-B