Sie sind auf Seite 1von 8

Install QPST and Backup qcn

Page 5 of 8 - How to unlock the Orange San Francisco II for free

Introduction Install the USB drivers Download required files Check FTM mode Install
QPST & Backup qcn Restore qcn Reinstall stock ROM Comments

On this page, we will install QPST and set it up in order for your Orange San Francisco II to
communicate with your computer.
1.

On your PC, download qpst.zip to you desktop. Once completed, extract it.

2.

Open the folder Install QPST (from the zip you just extracted) and
run setup.exe (or setup) to install. Follow the on screen instructions.

Run setup.exe. Follow the wizard instructions to install QPST.


3.

Make sure your phone is disconnected from your computer.

4.

On your phone, open Settings from the app menu.

5.

Tap Applications.

6.

Tap Development.

7.

Make sure USB debugging is ticked.

8.

Switch off your phone, remove the battery, wait 5 seconds, and then reinsert.

9.

Hold the Volume down and Power on button at the same time, for 10 seconds.

10.

You should now see FTM on your screen.

Troubleshooting

If your phone boots as normal, it is likely that you did not press the required buttons correctly,
or you did not disconnect your phone from your computer. Try booting into FTM mode again.

1. Turn off your phone and remove the battery.


2. Reinsert the battery.
3. Make sure your phone is disconnected from your computer.
4. Hold the Volume down and Power on button at the same time, for 10 seconds.
5. Follow from step 8.

11.

Connect your phone to your computer.

12.

Click Start -> All Programs -> QPST -> QPST Configuration

Run QPST Configuration.

13.

Click the Ports tab, and then click the button Add New Port ...

Click the Ports tab then the Add New Port... button.

14.

Click on COM - USB/QC Diagnostic and click OK. In our case, there was the number 9
after COM, as seen in the picture below. You may have a different number, which is fine.

Click COM - USB/QC Diagnostic and then OK.

15.

Click Start Clients and then Software Download.

Click Start Clients and then Software Download.

16.

Click the Backup tab and then the second Browse button.

Click the Backup tab and then click the second Browse button.

17.

You should now be presented with a Window asking you where to save a file. Save the
file to your Desktop, and name it osf2

18.

Press the Start button (it's next to the Abort button)

19.

Wait until you see "Memory Backup Completed" in the Status box.

Wait until you see Memory Backup Completed.

20.

Go to your Desktop and check the file size of osf2. Make sure it is NOT 0 KB in file size.
You can do this by simply hovering over the file with your mouse, as seen below. For us, the file
size was 153 KB, however it may be different for you, which is fine - just make sure it is greater
than 0 KB.

Check the file size of osf2 by hovering your mouse over the file. Make sure it is greater than 0
KB.

21.

Close all QPST Windows.

22.

Click Start -> All Programs -> QPST -> QPST Configuration

23.

Click the Ports tab.

24.

Click the only COM device from the list.

25.

Click the Disable button and then click Yes.

Click the only COM device listed and then click the Disable button.

26.

Close all QPST Windows, and continue to the next page.

Das könnte Ihnen auch gefallen