Beruflich Dokumente
Kultur Dokumente
www.philips.com/welcome
SBA3010/37
User manual
1 Important
Safety
Important Safety Instructions
a
b
c
d
e
f
g
h
i
j
k
l
Warning
Never remove the casing of this apparatus.
Never lubricate any part of this apparatus.
Never place this apparatus on other electrical equipment.
Notice
Any changes or modifications made to this device that are not expressly
approved by Philips Consumer Lifestyle may void the users authority to
operate the equipment.
This device complies with Part 15 of the FCC Rules. Operation is
subject to the following two conditions:
1 this device may not cause harmful interference, and
2 this device must accept any interference received, including
interference that may cause undesired operation.
This equipment has been tested and found to comply with the
limits for a Class B digital device, pursuant to part 15 of the FCC
Rules and ICES-003 of Industry Canada . These limits are designed
to provide reasonable protection against harmful interference in a
residential installation. This equipment generates, uses, and can radiate
radio frequency energy and, if not installed and used in accordance
with the instruction manual, may cause harmful interference to radio
communications.
However, there is no guarantee that interference will not occur in a
particular installation. If this equipment does cause harmful interference
to radio or television reception, which can be determined by turning
the equipment off and on, the user is encouraged to try to correct the
interference by one or more of the following measures:
Relocate the receiving antenna.
Increase the separation between equipment and receiver.
Downloaded from www.Manualslib.com manuals search engine
Note
Get started
Power supply
The speaker can operate on built-in rechargeable battery.
To recharge the built-in battery:
Connect your speaker with PC through supplied USB cable.
The power indicator turns on.
The power indicator turns off when its fully charged.
Play
1 Pull the audio input plug out of the speaker.
2 Slide the switch to turn the speaker on.
The LED lights up.
3 Connect the speaker to your device with the audio input plug.
4 Adjust the volume and navigate your audio content on your device.
5 After use,disconnect your device from the speaker and slide the
switch to turn the speaker off.
Product information
Note
Specifications
Amplifier
Rated Output Power
2W RMS
>70dB
Distortions
<1%
Aux-in Link
General information
DC power input
USB 5V 500mA
3.7V 500mAH
>8 hours
Dimensions-Main Unit
(diameter x height)
D65.8mm * H76.6mm
0.208 kg
4 Troubleshooting
Warning
Never remove the casing of this apparatus.
To keep the warranty valid, never try to repair the system yourself.
If you encounter problems when using this apparatus, check the
following points before requesting service. If the problem remains
unsolved, go to the Philips web site (www.philips.com/welcome). When
you contact Philips, ensure that the apparatus is nearby and the model
number and serial number are available.
No power
No sound