Beruflich Dokumente
Kultur Dokumente
5982
1/4
Web Site
http://www.simplicity.com
1-888-588-2700
info@simplicity.com
General Directions
The Pattern
4
C
A
CENTER FRONT OR
BACK of garment.
11
NOTCHES
10
DOTS
CUTTING LINE
TO SHORTEN:
At lengthen or
shorten lines,
make an even
pleat taking up
amount needed.
Tape in place.
LENGTHEN OR
SHORTEN LINES
13
F
D
14
D
E
A/B/C
12
15
11-COLLAR -D,F
14-INSET -D,E,F
15-SLEEVE -D,E,F
Sewing
SEW garment following Sewing Directions.
PIN or machine-baste seams matching notches.
STITCH 5/8" (1.5 cm) seams unless otherwise stated.
PRESS seams open unless otherwise indicated clipping when necessary so
seams will lie flat.
TRIM seams to reduce bulk, as shown below.
Trim enclosed
seams into layers
D/F
Cutting
Layouts
pattern printed
side down
pattern printed
side up
Trim corners
Clip inner
curves
Notch outer
curves
SEL.
4
INTERFACING
INTERFACING
USE PIECES 3 4
USE PIECES 12 13
FUSIBLE
ALL SIZES
ALL SIZES
D,F COLLAR
SELVAGE
USE PIECE 11
A,B,C TOPS
FOLD
2
SEL.
4
WITH NAP
SIZES 1/2 1 2
WITH NAP
ALL SIZES
Mark small
If layout
shows a piece
extending past
fold, cut out all
pieces except
piece that
extends.
selvages indicating
direction of nap or
design. Fold fabric
crosswise with
RIGHT sides
together, and cut
along fold (a).
Open out
fabric to single
thickness. Cut
extending
piece on
RIGHT side of
fabric in
position
shown.
a.
SELVAGE
b.
SELVAGES
SELVAGE
SELVAGES
FOLD
12
SELS.
13
FOLD
1A
1B
1C
1D
FOLD
SEL.
WITH NAP
ALL SIZES
10
12
14
15
13
11
FOLD
FOLD
FOLD
SEL.
10
13
3
1
12
14
SEL.
SEL.
15
15
USE PIECES 7 8
WITH NAP
ALL SIZES
SEL.
2C
SELS.
SIZES 1/2 1 2 3
2A
2B
WITH NAP
ALL SIZES
FOLD
USE PIECES 5 6
SELS.
FOLD
1E
FOLD
FOLD
USE PIECES 9 10 12 13 14 15
SEL.
FOLD
D,E,F TOPS
FOLD
FOLD
SEL.
To Quick Mark:
PIN pattern to fabric as shown in Cutting
Layouts.
SEL.
SEL.
USE PIECES 1 2 3 4
11
SIZES 3 4
AFTER CUTTING:
Transfer markings to WRONG side
of fabric before removing pattern.
Use pin and chalk method or
dressmakers tracing paper and
wheel.
Espaol
See
SPECIAL
CUTTING
NOTES
BEFORE CUTTING:
PRESS pattern pieces with a warm dry
iron. PRE-SHRINK fabric by pre-washing
washables or steam-pressing nonwashables.
SELVAGE
ADJUST IF NEEDED
Make adjustments before placing
pattern on fabric.
TO LENGTHEN:
Cut pattern
between
lengthen or
shorten lines.
Spread pattern
evenly, the
amount needed
and tape to
paper.
CROSSWISE FOLD
SYMBOLS
GRAIN LINE Place on
straight grain of fabric
parallel to selvage
Cutting/Marking
15 pieces given
WITH NAP
ALL SIZES
8
FOLD = DOBLEZ
FOLD
Copyright 2002Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
FOLD
FOLD
English/Spanish
5982
Sewing Directions
2/4
FABRIC
KEY
RIGHT SIDE
WRONG SIDE
INTERFACING
LINING
7. Press up hem.
Press under 1/4" (6mm) on raw edge.
Stitch close to inner pressed edge.
FOR VIEW A- Sew heart applique to upper LEFT front, as
shown on front of envelope.
STAY-STITCHING
TOP A, B, C
FRONT
BACK
STAY-STITCHING
TOP D, E, F
BACK
2
2. FOR VIEW A- On OUTSIDE, place lower edge of one color
middy braid along placement line, having raw edges even.
Stitch along center of trim. Stitch second and third color of
braid 1/8 (3mm) below first row spacing them 1/8" (3mm)
apart and having raw edges even, as shown.
1. Stay-stitch front and back neck edges 1/4" (6mm) from cut
edge in direction of arrows.
FRONT
2
2. To reinforce front at neck edge, stitch along stitching line at
center front. Stitch front to back at shoulder seams.
COLLAR D, F
4
3. With RIGHT sides together and raw edges even, stitch facing
to collar in 3/8 (1cm) seam, leaving notched edge open. Trim
seam and corners.
5
5. With RIGHT sides together, stitch facing to neck and armhole
edges, matching centers.
Trim seam; clip curves.
Copyright 2002Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
5
5. FOR EITHER VIEW- Clip neck edge of garment to stitching
at center front.
On OUTSIDE, pin collar (facing side) to neck edge, matching
centers and placing small dot at shoulder seam. Baste in 3/8
(1cm) seam.
English/Spanish
5982
3/4
14
15. With RIGHT sides together, pin sleeve to armhole edge with
center small dot at shoulder seam, matching remaining small
dots.
Stitch. Stitch again 1/8" (3mm) from first stitching.
Trim seam below notches close to stitching.
Press seam toward sleeve.
15
16
9
17
17. Press up sleeve and lower hem.
Press under 1/4" (6mm) on raw edge.
Stitch close to inner pressed edge.
10
18
11
12. Fold inset along fold line with WRONG sides together. Press.
Stitch 1/4 (6mm) from raw edge.
If you prefer to EDGE FINISH raw edge...stitch
1/4" (6mm) from edge, turn under along stitching and stitch
OR zig-zag over the edge OR overlock/serge over the edge.
12
13
LONG SHORTS A, B, E OR
SHORT SHORTS C, D, F
NOTE: Applique is optional for Views A, C.
2
CENTER
BACK
INNER
LEG
SEAM
VIEW -D,F
VIEW -E
Copyright 2002Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
CENTER
FRONT
English/Spanish
5982
Espaol
4/4
BLUSAS A, B, C
3
4
NOTA: - la aplicacin es opcional para los Modelos A, C.
3. FOR VIEWS A, C, D, E, F- Stitch front to back at side seams.
1.
SIDE
SEAM
SIDE
SEAM
2.
4. FOR VIEW B- Stitch front to back at side seams leaving an
opening between small dots. Back-stitch at dots to reinforce
seam.
Haga una puntada de sostn en el borde del escote del frente y de la espalda, a
1/2 (1.3cm) de los bordes cortados, en la direccin de las flechas.
La puntada de sostn es permanente y sirve para prevenir que se estiren los
bordes curvos. La puntada de sostn no aparecer en las ilustraciones
siguientes.
PARA EL MODELO A - Por el EXTERIOR, coloque le borde inferior de un galn
fino de un color a lo largo de la lnea de colocacin casando los bordes no
terminados. Cosa a lo largo del centro del galn. Cosa los galones del segundo
y tercero color a 1/8 (3mm) debajo del primero, con intervalos de 1/8" (3mm)
casando los bordes no terminados, como se muestra.
SIGA AS PARA A, B, C
3.
4.
5
6.
7.
7
6. Press 1-1/4" (3.2cm) on upper edge to INSIDE, forming
casing. Press under 1/4" (6mm) on raw edge. Stitch close to
lower edge of casing, leaving an opening to insert elastic.
BLUSAS D, E, F
NOTA:
Haga una puntada de sostn en los bordes del escote del frente y de la espalda,
a 1/4" (6mm) de los bordes cortados, en la direccin de las flechas.
La puntada de sostn es permanente y sirve para prevenir que se estiren los
bordes curvos. La puntada de sostn no aparecer en las ilustraciones
siguientes.
Para reforzar el frente en el borde de escote, cosa a lo largo de la lnea de
pespunte en el centro del frente. Cosa juntos el frente y la espalda por las
costuras de los hombros.
CUELLO D, F
8. Stitch ends of elastic together securely. Stitch opening
closed. Distribute fullness evenly. Remove basting.
TIP-To secure elastic so it wont twist in wearing, stitch
through all thicknesses of casing in the groove of each seam.
3.
4.
5.
10
6.
10. FOR VIEW B- Cut ribbon in half. Insert ribbon into opening at
lower edge, having ends extend evenly. Trim ends if
necessary.
11
7.
8.
Copyright 2002Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
1.
2.
8
SIGA AS PARA D, E, F
9.
1.
Cosa juntos el frente y la parte trasera por las costuras de las piernas.
2.
DERECHO CON DERECHO, prenda con alfileres la costura del centro casando
las costuras interiores de las piernas y las muescas. Cosa. Para reforzar la
costura, vuelva a coser en el primer pespunte. Recorte la costura a 1/4" (6mm)
en la parte curva. Planche abierta la costura restante .
PARA LOS MODELOS A, C, D, E, F- Cosa juntos el frente y la parte trasera por
las costuras de los lados.
PARA LE MODELO B- Cosa juntos el frente y la parte trasera por las costuras
de los lados dejando una abertura entre los puntos pequeos. Retroceda el
pespunte en los puntos para reforzar la costura.
3.
4.
Para evitar que el elstico quede atrapado en los margnes de costura al insrtalo en la jareta,
pguelos con materia adhesiva o hilvnelos a mquina en la prenda, en la seccin de la jareta. No
olvdese quitar el hilvn una vez la jareta este terminada.
6. Planche 1-1/4" (3.2cm) hacia el INTEROR en el borde superior, para formar la jareta. Planche un
doblez de 1/4" (6mm) en el borde no terminado. Cosa cerca del borde inferior de jareta dejando
una abertura para insertar el elstico.
7. Corte un pedazo de elstico a la medida de la prenda ms 1" (2.5cm). Inserte el elstico en el
interior de la jareta. Cruce los extremos y mantngalos juntos con un imperdible. Prubese la
prenda y ajstela.
8. Cosa juntos los extremos del elstico firmemente. Cierre la abertura cosindola. Distribuya
uniformemente la amplitud. Quite el hilvn.
CONSEJO - Para fijar el elstico de tal manera que no se enrolle con el uso, cosa a travs de
todos los espesores de la jareta en el surco de las costuras.
9. Planche el dobladillo. Planche un doblez de 1/4" (6mm) en el borde no terminado. Cosa cerca del
borde interior planchado.
10. PARA EL MODELO B- Corte la cinta por la mitad. Inserte la cinta por la abertura en el borde
inferior, dejando los extremos sobrepasar de largo igual. Recorte los extremos si es necesario.
11. PARA EL MODELO E- Por el EXTERIOR, prenda con alfileres el centro del galn fino en el
pespunte del dobladillo volviendo un extremo hacia dentro y cruzndolo en la costura interior de la
pierna. Cosa a lo largo del centro del adorno.
Prenda con alfileres y cosa el segundo galn a 1/2 (1.3cm) arriba del primero.
PARA EL MODELO F - Coloque el galn en el pespunte del dobladillo
solamente, procediendo como para el Modelo E.
PARA EL MODELO A - Cosa la aplicacin de corazn en el frente IZQUIERDO
inferior de la pierna, como se muestra en el frente del sobre.
PARA EL MODELO C - Cosa la aplicacin de bandera en el frente DERECHO
inferior, como se muestra en el frente del sobre.