Beruflich Dokumente
Kultur Dokumente
Project scope
Product specification:
In addition to key design calculations, the use of finite element simulation is compulsory for
the structure analysis.
Consideration of society impact, and environmental health and safety in the design must be
demonstrated.
The inclusion of remote control in the product design are strongly encouraged though it is
not compulsory.
Only the motors and the blades that the students can choose to purchase. All other parts
must be fabricated in-house in the lab or workshop.
For the utilization of in-house 3D printer, students are advised to first understand its capability as part their design
consideration.
Prototype must be produced in this project, and it must fulfill the following test criteria:
To take off vertically at the height of 2m at minimum, once the motors are activated
To lift an additional load of 20g at minimum (Note: 20sen coins x 5 will be used as the load)
To survive a free drop test from 10m height, without any evidence of defect to the structure and
functionality of the product
Key Milestones
Semester 1 (14 weeks)
(week 2 week 6)
Establishing
Design Solution:
Design solution is
established through
theoretical calculation
and advanced simulation
(e.g. structural stress
analysis and lift/drag
force analysis)
Materials selection
List of parts
Submission of Stage
1 progress report &
oral presentation
Design Solution
Validation:
Prototype fabrication
Fully functional
prototype
demonstrations and
testing
Final Cost Analysis
Stage 2 Final
Report submission
and Poster
presentation
Group Number
Group members
Supervisor/co-supervisor
Group 1
PANG Qi Huat
Mr Gerald/Dr Amir
Dr Amir/Dr Yazdi
Dr Yazdi/Mr Gerald
Dr How/Dr Chuah
Dr Yazdi/Dr How
EHSAN SAMOH
Tan Ming Jie
Liw Wei Chun
Back up