Beruflich Dokumente
Kultur Dokumente
Description
Quantity
Remarks
1
2
3
4
5
1
1
2
1
1
Required Tools
Metric offset hexagon key wrench 6
Metric offset hexagon key wrench 3
Basic Assembly
3. Mount the two O-Rings (supplied with the OMT kit) on the
OMT body. Pay attention to the mounting direction, as
shown in the section view.
Remote Configurations
When remote configuration is required, the OMT is attached directly to the antenna and the RFU-Cs are
installed remotely, using a flexible waveguide.
This section describes the required items and procedures for remote installation.
Remote configurations include:
2+0 (2 x 1+0 remote connection to OMT)
2+2 (2 x 1+1 remote connection to OMT)
2+0/2+2 Installations
Frequencies 13-38 GHz do not require adaptors
Frequencies 6-11 GHz require adaptors, as describe below
With RFU-C OMT Adaptors:
1. For UDR70, UBR84, and UBR100, mount the ORing (supplied with the OMT kit).
2. For UBR84 and UBR100, mount the OMT
adaptor (with its installed sealing gasket) on the
OMT, and tighten using four M4 screws and
washers (supplied with the OMT adaptor kit).
3. The flexible waveguide should be mounted without its
gasket (only for the OMT side).
Important!
For the warranty to be honored, install the unit in accordance with the instructions above.