Beruflich Dokumente
Kultur Dokumente
Pantalla anterior
Producto: EXCAVATOR
Modelo: 315C EXCAVATOR CFB
Configuracin: 315C & 315C L Excavators CFB00001 -UP (MACHINE)
POWERED BY 3046 Engine
Pruebas y Ajustes
315C Excavator Hydraulic System
Nmero de medio -RENR5519-08
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting and repair
of the product. Be prepared to collect the fluid with suitable containers
before opening any compartment or disassembling any component
containing fluids.
Refer to Special Publication, NENG2500, "Caterpillar Tools and Shop
Products Guide" for tools and supplies suitable to collect and contain
fluids on Caterpillar products.
Dispose of all fluids according to local regulations and mandates.
Personal injury can result from hydraulic oil pressure and hot oil.
Hydraulic oil pressure can remain in the hydraulic system after the
engine has been stopped. Serious injury can be caused if this pressure is
not released before any service is done on the hydraulic system.
Make sure all of the work tools have been lowered to the ground, and
the oil is cool before removing any components or lines. Remove the oil
filler cap only when the engine is stopped, and the filler cap is cool
Illustration 1
Pump compartment
g00763698
(1) Connector
(2) O-Ring seal
(3) Hose
1. While the engine is stopped, disconnect hose (3) from connector (1) .
2. Remove connector (1) and O -Ring seal (2) from the pump housing.
3. Fill the main pumps with oil.
4. Inspect O-Ring seal (2). If the seal is damaged, replace the seal.
5. Install O-Ring seal (2) and connector (1) at the pump housing.
6. Connect hose (3) to connector (1). Tighten hose (3) to the specified torque.
NOTICE
To avoid system damage, make sure that the hydraulic pump is
properly filled with hydraulic oil before start -up.
Illustration 2
Pump Compartment
g00771472
(4) Hose
(5) Plug
9. Slowly loosen hose (4) until oil begins to flow around the hose connection.
10. Tighten hose (4) to the specified torque.
11. Stop the engine and slowly lower the boom until the bucket is on the ground. This pressurizes the
hydraulic tank.
12. Slowly loosen plug (5) on top of hose (4) until oil begins to flow from the opening.
13. Tighten plug (5) to the specified torque.