Beruflich Dokumente
Kultur Dokumente
for installation:
screwdriver
2 wire nuts
(size 54)
Installation
Instructions
IMPORTANT:
Read and save these instructions.
IMPORTANT:
Installer:
Homeowner:
inspectors
worm
gear clamp
use.
or auger
plastic tube
Instructions.
dishwasher drain
connector
d
0
Lb
0
0;
on-off
electrical
(Et
ampere
Installation dimensions
Remove old
disposer.
Electrical Shock Hazard
- II
Caution: Potential
gasket
Mounting
assembly
screw(s)
F!!v
;y
Check that
all parts were
included.
sink flange
Property Damage.
metal flange
2 rubber
Remove disposer
mounting ring
and 3 screws
snap ring
Electrical
requirements
E. A
U.L.-listed conduit
must be provided
connector
at the junction
box.
A. 120
B. THE
4
A. Use wrench
P-trap.
PANEL A
Go to Step 3-D.
To install our
sinks firs Y
disposer :
to loosen nut at top of
screw
C. Loosen
Attach the
upper
mounting
mm
assembhr,
IA
gasket
8. Holding the rubber gasket and metal backup ring in place, attach the mounting ring to
the sleeve with the three mounting ring
screws Do Not tighten screws at this time.
D. Remove nut.
E. Push the
Clean sinkS
drain line.
A.
Separate the
mounting
assembly.
A
Make
electrical
connections
1D.t-i
B. Loosen
sleeve
D. Take assembly
7
A.
Apply rubber
asket or putty
so sink flange.
wire (no
smaller than the other cable wire) to the
yreen yrounding screw
B. If sink
PANEL B
to a yrounded
IA.
D.
Optional
dishwasher
drain
connection
11
14
Optional:
Connect to
dishwasher drain.
12
Connect
disposer
to mounting
assembb
1
A.
A.
B.
Attach the
disposer
waste line
pipe to drain trap.
13
C. Insert
D. Slip
15
C. If not
comply with
lock
disposer
in place.
MODELS
GClOOO
GC2000
GC3000
Check for
leaks and
proper
operation.
16
D.
B.
E,Rotate disposer until waste line pipe aligns
with drain trap.
PANEL C
IS
clean and
D.
A.
r-
appliance
b. Drain cleaner,
PERSONAL INJURY HAZARD
When using electric appliances basic
precautions should always be followed,
including the following:
Read all the instructions
appliance.
Turn the power switch to the OFF position before attempting to clear a jam or
remove an object from the disposer,
When attempting to loosen a jam In a
waster disposer, use a self service jambreaker wrench as described in Use and
Care Guide.
When attempting to remove objects
from a waster disposer, use lony-handled tongs or pliers.
Failure to follow these instructions
result in serious injury.
could
---
Save these
instructions.
must be yrounded.
could
301
PrInted
In U S A.