Beruflich Dokumente
Kultur Dokumente
)
2016 Taylor & Francis Group, London, ISBN: 978-1-138-02877-7
ABSTRACT: The interest towards improving the quality of power, which are supplied to the electronic
equipments has been increasing to ensure the optimum utilization of power generated. A low power
factor is responsible for reducing the active power thats available from the grid. Thus, it causes a high
harmonic distortion of the line current eventually, which results in electromagnetic interference problems
and cross-interferences, through the line impedance, between different systems connected to the same supply. The standard rectifier employing a diode bridge followed by a filter capacitor for DC utilities gives
unacceptable performances in terms of power quality according to the rising benchmark set by recent
developments in the relevant field. The most popular topology for power factor correction is certainly the
boost topology. In this work, a power factor corrected boost converter has been designed and simulated
in MATLAB and the proposed control strategy has been implemented.
1
INTRODUCTION
265
LAHIRI_Book.indb 265
3/7/2016 11:05:56 AM
D =1
Vi
Vo
(5)
Figure 1.
II LON =
DT
Vi dt =
DT
Vi
L
(1)
dII L
dt
The control strategy proposed in this work is hysteresis control. In hysteresis current control the
current is made to vary within a specific band,
as shown in Figure 2. Currentmode control can
be achieved by sensing the current of the switching power devices or energy storage element and
integrating it into main voltage control loop
(Fagerstrom et al. 2012). Whenever the actual current reaches the upper limit of the band the switch
of the boost converter must be off and whenever
the current falls to the lower limit of the band,
the switch must be ON. In this control scheme the
switching frequency is not constant.
The block diagram of the implemented control
strategy is shown in Figure 3.
iL (t )RL
(6)
(2)
II LOFF =
(3)
LON
II LLOFF
OFF
F =0
(4)
Figure 2. Input current waveform of PFC boost converter with hysteresis control.
266
LAHIRI_Book.indb 266
3/7/2016 11:05:56 AM
VL (t ) =V
Vg
I L RL
(7)
Similarly,
ic (t ) =
V
R
(8)
s
z
s
s
1+
+
Q 0 0
(9)
1
s
s
1+
+
Q 0 0
(10)
where,
Gg 0 =
1
1 D
0 =
1 D
LC
Gd =
V
(1 D )2 R
z =
,Q
1 D
L
(1 D )R LC
267
CH054_66.indd 267
3/21/2016 5:01:24 PM
CONCLUSION
268
LAHIRI_Book.indb 268
3/7/2016 11:06:27 AM