Beruflich Dokumente
Kultur Dokumente
mot_op1.exe
mot_op2.exe
The "mot_op1.exe" is selected if Com1 port of your PC / laptop is used to link to the RS232 port of the
ignition control unit.
The "mot_op2.exe" is selected if Com2 port of your PC / laptop is used to link to the RS232 port of the
ignition control unit.
Copy the selected file onto your hard disc.
Operation
Execute the selected file and a warning message will be displayed. Read carefully and ensure that
you have read and understood the user manual of the ignition control unit.
When ready, press any key.
Now the main screen will appear when the control unit is connected to 24 VDC.
RPM
ANALOG INPUT SIGNAL
SPARK TIMING
IGNITION STATUS
speed
in degrees crankshaft
in degrees BTDC
ready or not ready
All below listed functions can be pulled up when pressing "shift and letter":
C
E
ESC
M
S
_____________________________________________________________________________________________________
Motortech GmbH
Tel. +49 5141 9399-0
page 1 of 1
Notes
key codes:
F1
F2
F3
F4
F5
CHANGE PARAMETER
NEXT
PREVIOUS
HELP
SAVE
change parameters
next parameter
previous parameter
help
save parameters
M: misfiring detection
A list of output wires is displayed. Only the number of wires which are in use for the application are
marked with "1" underneath the letters.
When misfiring occurs in the primary circuit, a "0" will appear under the particular cylinder letter code,
which indicates the failure.
At the same time the total amount of misfirings per second is displayed.
To leave this program function press "ESC".
End program
To leave the program press F10.
_____________________________________________________________________________________________________
Motortech GmbH
Tel. +49 5141 9399-0
page 2 of 2