Beruflich Dokumente
Kultur Dokumente
http://www.hoelscher-hi.de/hendrik/english/demux.htm
HOME
DMX Demultiplexer
DMX 512
This LeastCost Demux converts up to eight consecutive DMX channels to the corresponding
analogue 0-10V signals.
resources
FAQ
OpenRDM
dimmer
switch pack
demux
LED
matrix
rc-servo
stepper
Analyzer
strobo mod
With this circuit you can integrate existing analogue dimmer packs into a new DMX installation.
A DMX Demultiplexer is made of:
1 DMX Transceiver
1-8 low pass filters with levelshifter
DMX-Transceiver (Rev. 3.01)
With this modul DMX data can be received or transmitted.
Because of the complete usage of the RS485 converter, a bidirectional transfer
of data is possible (i.e: RDM as described in ANSI E1.20). Till now this feature
is only supported by a few expensive devices.
high voltage
tesla coil
twin
Though the circuit is only made of an AVR and few other parts I recommend a
diy etched board.
misc
pics
links
imprint
_
parts
1 de 4
27/06/2012 12:04
DMX Demultiplexer
http://www.hoelscher-hi.de/hendrik/english/demux.htm
IC1
IC2
IC3
B1
LED1
LED2
R1
R2,3,4
C1,2
C7
C5,6
SW1
Q1
connectors
ATmega8515-16PU
75176B
7805
rectifier (round)
LED 5mm red
LED 5mm green
10k (PT10-S)
390 Ohm
27pF
100nF
100F
DIP-Switch (10)
8MHz (HC49)
pin header (single)
As you can see, the schematic is quite simple: The heart of the controller is the firmware of the mcu
(IC1). The start address is set with SW1. The LEDs indicate the status of the controller. The parts
around IC3 are responsable for an exact Vcc of 5.0Vdc. IC2 is the RS485-Transceiver. It allows our
controller to communicate via DMX512 with other equipment.
For a dimmer- or switchpack you have to connect the pins of "output" with the "-"pins of the
dimmer-/switchmodules because a mcu can drive bigger loads as a current sink. The "+"inputs of
all modules must be connected to vcc.
The "spare" port is used for additional pins or to jumper different modes.
AC1&2 have to be connected with a power supply of 9-12V ac or dc. 3-5W should be sufficient.
The following schematic shows you how to connect the transceiver with the DMX bus:
2 de 4
27/06/2012 12:04
DMX Demultiplexer
http://www.hoelscher-hi.de/hendrik/english/demux.htm
On the resources site you can find a manual for programming AVRs. The 8MHz crystal has to be
selected as clock source by changing the fuse bits.
After changing the fuse bits the transceiver should be flashed with the Demultiplexer Firmware. This
program generates high frequency PWM signals from the next eight channels after the start
address.
Filter and Shifter
3 de 4
27/06/2012 12:04
DMX Demultiplexer
http://www.hoelscher-hi.de/hendrik/english/demux.htm
4 de 4
Error
Solution
There is no signal connected to the
Connect the transceiver to the DMX bus.
transceiver.
The signal is not accepted as DMX.
Swap D+ and D- at the DMX connector.
The transceiver cannot receive all Transmit more channels or choose a lower
required channels.
start address.
27/06/2012 12:04