Sorganics P/N: 90009, 93209, 90109, 90509, 95509 Distributor 8109 Alister Place 1/10/2009 Address Date Prepared Port St Lucie FL 34986 Robert A. Huey Prepared by 877-337-8549 Phone Number (For Information) 800-424-9300 (CHEMTREC) 703-527-3887 (CHEMTREC, collect calls accepted) Emergency Phone Number International Emergency Phone Number
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
COMPONENTS - Chemical Name & Common Names OSHA ACIH Other Limits (Hazardous Components 1% or greater; Carcinogene 0.1% or greater) Wt. % PEL TLV Recommended Glycosperse 0-20 (CAS#9005-65-6) 5-15% --- --- NONE Sodium Laureth Sulfate (CAS#9004-82-4) 1-5% --- --- NONE Linear Alcohol Ethoxylate (CAS# 68439-46-3) 1-5% --- --- NONE Sodium Gluconate (CAS# 527-07-1) 1-5% --- --- NONE Dodecylbenzene sulfonic acid (CAS# 27176-87-0) 1-5% --- --- NONE Non-Hazardous Ingredients >70% TOTAL 100 SECTION 2 - PHYSICAL / CHEMICAL CHARACTERISTICS Boiling Specific Gravity Point 100 C (H2O - 1) 1.0 Vapor Pressure Melting (mm Hg and Temperature) 750-765 mm @ 220 F Point 28 - 34 F Vapor Density Evaporation Rate No information (Air = 1) N/A (________________ = 1) found. Solubility Water in Water Miscible in water. Reactive N/A
pH 8.0 to 9.0 Appearance and Odor Off white, translucent, no odor
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
Flash Point & None Auto-Ignition Flammability Limits in LEL UEL Method Used Pensky-Martens CC Temperature N/A Air % by Volume N/A N/A N/A Extinguisher Media Water spray, water fog, foam, or dry chemical Special Fire Prevent human exposure to fire, fumes, smoke, and products of combustion. Firefighters should wear Fighting Procedures full face, self contained breathing apparatus and impervious protective clothing. Unusual Fire and Explosion Hazards Toxic fumes may be released.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY Conditions X Stable To Avoid None known. Unstable Incompatibility (Materials to Avoid) Inorganic acids, organic acids, bleaching agents (oxidizers) HAZARDOUS POLYMERIZATION Conditions None required. May Occur To Avoid X Will Not Occur
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUT Inhalation X Ingestion CARCINOGEN NTP OSHA OF ENTRY X Skin Absorption Not Hazardous LISTED IN IARC Monograph X Not Listed HEALTH HAZAR Acute Skin and eye irritant. Chronic Poisonous if swallowed. Signs and Symptoms of Exposure Redness of skin or eyes. Medical Conditions Generally Aggravated by Exposure None known. EMERGENCY FIRST AID PROCEDURES - Seek medical assistance for further treatment if necessary. Eye Contact Wash thoroughly with running water for 15 minutes. Get medical advice if irritation develops. Skin Contact Wash exposed area thoroughly with water for 15 minutes. Get medical advice if irritation develops. Inhalation Remove to fresh air. If breathing is difficult give oxygen. Call a physician immediately if difficulty breathing persists. Ingestion Do not induce vomiting. Do not give anything by mouth to unconscious person. Give water to rinse mouth and give several glasses of water to dilute. Call physician immediately.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (Specify Type) Proper ventilation required, respirator not normally required. Protective Gloves Neoprene Gloves. Eye Protection Wear Chemical Goggles.
VENTILATION X Local Exhaust Mechanical (general) Special
TO BE USED Other (Specify) Other Protective Clothing and Equipment Wear protective clothing when handling. Hygienic Work Practices Use good housekeeping measures.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE / LEAK PROCEDURES
Steps to be Taken if Material Small spills can be rinsed to drain with water. Is Spilled Or Released Large spills should be contained for reclaim or properly disposed. Waste Disposal Follow applicable local, state, and federal regulations Methods Precautions to be Taken This product may become slippery on floors. in Handling and Storage Avoid spilling and walking on spilled area. Other Precautions and/or Special Hazards None known. NFPA/HMIS Rating* Health__1__ Flammability_0__ Reactivity_0__ Special_0__
SECTION 8 - REGULATORY CONTROLS
The components of this product are included on or exempted from listing on the TSCA inventory of chemical substances. Protection of stratospheric ozone (pursuant to section 611 of the clean air act amendments of 1990): Per 40 CFR part 82, this product does not contain any class I or class II ozone depleting substances.
The information provided here is compiled from sources believed to be reliable and is accurate to the best of our knowledge at this time. It is provided in good faith but without warranty, expressed or implied, the results of the use of this information or to the product to which it relates. Recipient assumes responsibility for the use, storage or disposal of this product, including any resultant injury or property damage. Revision:09/22/09