Beruflich Dokumente
Kultur Dokumente
To save BOF file (need to execute when any modification made to BOF file)
# bof save
To reboot router:
#admin reboot
Configure a Card/IOM:
#configure card <slot id of card> card-type <type of card>
Configure a MDA:
#configure card <slot id of card> mda <slot id of mda> mda-type <type of
mda>
Shutdown a Card/IOM:
#configure card <slot id of card> shutdown
Shutdown MDA:
#configure card <slot id of card> mda <slot id of mda> shutdown
De-provision a Card/IOM:
#configure no card <slot id of card>
De-provision MDA:
#configure card <slot id of card> no mda <slot id of mda>
Display OS version:
#show version
Router ports must be configured as either access, hybrid or network. The default is network.
-
Access ports: Configured for customer facing traffic on which services are configured. If a
Service Access Port (SAP) is to be configured on the port or channel, it must be configured as an
access port or channel.
Network ports: Configured for network facing traffic. These ports participate in the service
provider transport or infrastructure network. Dot1q is supported on network ports.
Hybrid ports: Configured for access and network facing traffic. While the default mode of an
Ethernet port remains network, the mode of a port cannot be changed between the
access/network/hybrid values unless the port is shut down and the configured SAPs and/or
interfaces are deleted. Hybrid ports allow a single port to operate in both access and network
modes. MTU of port in hybrid mode is the same as in network mode except for the 10/100 MDA.
The default encap for hybrid port mode is dot1q; it also supports QinQ encapsulation on the port
level. Null hybrid port mode is not supported.
Once the port is changed to hybrid, the default MTU of the port is changed to
match the value of 9212 bytes currently used in network mode (higher than
an access port); this is to ensure that both SAP and network VLANs can be
accommodated. The only exception is when the port is a 10/100 fast
Ethernet. In those cases, the MTU in hybrid mode is set to 1522 bytes, which
corresponds to the default access MTU with QinQ, which is larger than the
network dot1q MTU or access dot1q MTU for this type of Ethernet port.