Beruflich Dokumente
Kultur Dokumente
specification
Doc N:
QM-TEC-06014-00-001
Project:
Dayang 801-822;
1001-1022 ; 2001-2024
Rev. :
Date:
30.08.2007
TABLE OF CONTENTS
1
Technical specifications.......................................................................................................................................................... 2
1.1
General ............................................................................................................................................................................ 2
1.2
1.3
Bulktanks ......................................................................................................................................................................... 2
1.3.1
Details ..................................................................................................................................................................... 2
1.4
Compressor...................................................................................................................................................................... 2
1.5
Dryer ............................................................................................................................................................................... 2
1.6
Aeration ........................................................................................................................................................................... 3
Technical
specification
Doc N:
QM-TEC-06014-00-001
Project:
Dayang 801-822;
1001-1022 ; 2001-2024
Rev. :
Date:
30.08.2007
Technical specifications
1.1
General
3
The installation consists of eight (4) high volume type bulk tanks, 2 with a volume of 35 m and 2 with a
3
3
volume of 45 m with a total filling volume of 160m .
The pneumatic tanks are pressure vessels. Designed primarily for carrying dry materials such as barite
(drilling mud), cement, bentonite and other materials used in drilling operations.
1.2
Class society
The tanks are certified by ABS, for the following pressure rating:
Working pressure:
Test pressure:
1.3
5.6 Bar
7,3 Bar
Bulktanks
The special design of these tanks ensures the rapid discharging of the complete tank without remaining inside the
tank.
1.3.1
Details
Number of tanks
Type of tanks
Diameter ()
Height
Capacity (pc)
Total capacity
Working pressure
Design according
Certificate by
Preservation inside & outside
1.4
:
:
:
:
:
:
:
:
:
:
4
High volume type design
4.350 mm
3.800 mm
3 &
3
2x 35 m 2x 45 m
3
160.0 m
5.6 Bar
ABS
ABS
Steel blasting SA2,5
One (1) layer of primer 40 m
Compressor
The compressor installation consists of two (2) Aerzen compressor sets. Type VMX-337-R / 110.
The compressor installation consists of two Aerzen compressor sets. Type VMX
337R / 110 Marine
Capacity at the compressor discharge end as per ISO-1217 1196 Annex C. is
21m3/ min. at 7.0 Bar, based on an inlet pressure of 1.0 Bar and an inlet
temperature of 20 8C and at an 0% relative humidity.
1.5
Dryer
The dryer installation consists of two (2) Aerzen refrigerated dryers. Type RA 300 BEKO,
Technical
specification
Doc N:
QM-TEC-06014-00-001
Project:
Dayang 801-822;
1001-1022 ; 2001-2024
Rev. :
1.6
Date:
30.08.2007
Aeration
In order to unload materials from the tanks, it is necessary to aerate or fluidise the material.
For this purpose, aeration pads are used. When high volume air from the compressor is introduced into the dry
material through the aeration pads, the material becomes entrained with air and will assume some of the
characteristics of water. It will seek its own level and flow to a central low point in the pressure tank.
In this fluidised condition and under pressure, the material will flow through the discharge line from the vessel to any
point within reasonable distance, depending on numerous factors, such as: density of materials, pressures, line sizes,
bends in the line, etc.