Beruflich Dokumente
Kultur Dokumente
BTD 2008/11
Product Name
Joint Type
Granor
Modular
Freyssinet Australia
Granor
Zillmere Engineering
Freyssinet Australia
Granor
Freyssinet Australia
Fingerplate
(See Note 1
below)
Saw tooth
(See Notes 1
& 2 below)
Miska BJ6
(Joint must be RMS approved version)
Trelleborg Engineered
Systems Australia
SSA100
Evolution Civil
Maintenance
Britflex BEJ
(Rehabilitation of expansion joints only)
Granor
Strip seal
Compression
seal
Notes:
1. Provide stainless steel drainage troughs for new bridges.
2. These joints may have large gaps. The suitability for cyclists must be checked where applicable.
Contact:
Current as at:
8 October 2015
1 of 11
Company
Product Name
Joint Type
Granor
Trelleborg
Engineered
Systems Australia
Parchem
Emer-Seal:
Roadseal SL (for joint Type A to
RMS B312)
Roadseal (for joints Types B and C to
RMS B312)
PU40 (for joints Types B and C to
RMS B312)
Small
movement
joints
Small
movement
joint sealants
(see following
Note)
Note As the sealants approved above for Types B and C to RMS B312 do
not satisfy the hardness and movement capability requirements of RMS B312
for the full range of joint gaps, their suitability for the intended joint gap and
movement must be verified before proposing them in any small movement
joints. Submissions for use of other than the approved joint sealants in specific
small movement joint applications must be reviewed by the Senior Bridge
Engineer (Special Projects), RMS Bridge Engineering.
Product Name
Freyssinet Australia
Tetron CD FX/GL/GG
Granor
Trelleborg Engineered
Systems Australia
Freyssinet Australia
PPC
Granor
Series A to K, Series N to Y
mageba (Australia)
Pty Ltd
Ludowici LEB
Trelleborg Engineered
Systems Australia
Trelleborg
mageba (Australia)
Pty Ltd
Ludowici RPS
Trelleborg Engineered
Systems Australia
Trelleborg
Bearing Type
Pot
Contact:
Current as at:
Spherical
Laminated elastomeric
Unreinforced elastomeric
pads and strips
8 October 2015
2 of 11
Product Name
Bearing Type
mageba (Australia)
Pty Ltd
Laminated elastomeric
3.
Product Name
Waterproofing System
Parchem
Construction
Products
Shelterbit H.D.
Bridge Membrane
SAMI P/L
Samiseal 6
Stirling Lloyd
Eliminator
Product Name
Waterproofing System
Evolution Civil
Maintenance
Pitchmastic PmB
Evolution Civil
Maintenance
Britdex MDP
Product Name
Cormac TH604
Note Cormac TH604: In high wear situations, surface skid resistance to be checked at
regular intervals and coating to be reapplied as required.
Contact:
Current as at:
8 October 2015
3 of 11
ii.
(2) DSI Factory Grouted Double Corrosion Protection Threadbar System comprising
(a) Anchorage: Solid plate with domed anchor nut without grout slot.
(b) Couplers: Cylindrical of the D assembly type.
(c) Bar (see Note 2):
i.
ii.
b)
Non stressing anchorage: Cast-in onion dead end with steel plates;
c)
d)
Contact:
Current as at:
8 October 2015
4 of 11
Stressing anchorage: Standard plate (see following Note), flat washer and nut;
Note Plates: Freyssibars standard steel plates come in four different designs
as follows:
I.
SRG Limited
(1) Slab post-tensioning system with up to 6 x 12.7 mm strands and with up to
5 x 15.2 mm strands.
(2) Macalloy Prestressing Bar System up to 50 mm diameter.
(3) BBR Cona Multi Strand Post Tensioning System with M1 live and dead end
anchorages and swaged dead end anchorages with up to 61 x 12.7 mm super grade
strands and up to 42 x 15.2 mm extra high tensile grade strands and Type M3 5506
fabricated live and swaged dead end anchorages with 55 x 15.2 mm extra high
tensile grade strands and type K couplers for up to 31 x 12.7 mm super grade
strands and up to 42 x 15.2 mm extra high tensile grade strands.
4)
b)
c)
d)
e)
f)
Spiral steel sheet duct- Refobar Australia or equivalent, and PP plastic ducts;
g)
h)
Corrugated HDPE trumpet type A from 0206 to 6106 (for anchor heads);
i)
Contact:
Current as at:
8 October 2015
5 of 11
j)
b)
c)
Coupling: Multistrand coupler heads with 90 spigot (see Note 1); and
d)
Tendon sizes (see Note 2) of 7, 12, 19, 22, 27, 31, 37, 42, 48 & 55 strands of
the following type and grade:
I.
b)
c)
d)
e)
Corrugated steel sheet duct to, EN 523 and corrugated plastic duct VSL
PT-PLUS;
f)
g)
h)
i)
1770 MPa or 1860 MPa 7-wire strand of nominal diameter 15.2 or 15.7 mm,
respectively, to EN 10138 or approved equivalent; and
j)
Contact:
Current as at:
8 October 2015
6 of 11
Note: Component designation ending with 6 or 6N are suitable for use with the
15.2 mm diameter strands, and designation ending with 6s are suitable for the
15.7 mm diameter strands.
(3) VSL Slab System comprising:
a)
b)
Non stressing anchorage: Cast-in swaged ends on steel plate or onion dead
ends;
c)
Coupling: Coupler blocks with packers using 2-piece wedges for Stage 1
strands and swaged Stage 2 strands; and
d)
b)
c)
d)
e)
f)
3-piece wedge with steel spring ring - Grade 16NiCr to EN 10084 or Grade
C15 to EN 10277-2;
g)
1770 MPa or 1860 MPa 7-wire strand with diameters 15.2 mm and 15.7mm to
EN 10138 or approved equivalent; and
Contact:
Current as at:
8 October 2015
7 of 11
Note: For information on provisionally approved systems which do not appear on this list,
ii.
(2)
ii.
Contact:
Current as at:
8 October 2015
8 of 11
Contact:
Current as at:
8 October 2015
9 of 11
Size
Comments
12 to
40 mm
12 to
36 mm
12 and
20 to
40 mm
Lenton Position
Couplers EL12P14LN
to EL20P14LN
12 to
20 mm
Lenton Position
Couplers EL25P13LN
to EL36P13LN
24 to
36 mm
24 to
36 mm
(ii)
VicRoads (GeoPave)
8 October 2015
10 of 11
(b) TNO Foundation Pile Diagnostic System and TNOWAVE Analysis (TNO Laboratories,
Netherlands)
(i) Frankipile Australia P/L (Sydney)
(ii) Foundation Specialists Pty Ltd
Equipment
(a) Equipment
(i) Pile Driving Analyzer manufactured by Pile Dynamics Inc
(ii) Foundation Pile Diagnostic System (Version 3) manufactured by TNO
Laboratories
PO Box 3035
Contact:
Current as at:
8 October 2015
11 of 11