Beruflich Dokumente
Kultur Dokumente
ESTIMATE
NAME OF WORK: Provision of Generator facilities to the subourdinate court building
at Cuddalore , Kancheepuram, Thiruvannamalai, Thuiruvallur, Vellore and Villupuram
Districts .
Qty
Description
3
Nos. Supply , Testing Commissioning and Handing over of 1no
160 KVA Diesel Generator set (Make Kirlokar/Ashok
Leylend / Cummins) of 0.8 P.F three Phase 15V /
420volts,50 C/S 1500 RPM CPCB Approved capacity
compressing of Developing 200 BHP Water cooled clock
wise rotating with 128 KW / 160KVA operating capacity
Brush Less Alternator close coupled underneath fuel tank
,standard safeties, LLOP With stop solenoid ,battery with
lead ,Electric start and Anti Vibration mountings and
accessories and AMF control panel as detailed below
including transporting and Unloading charges
Rate
Per
Amount
1246300.00 Ea
4985200.00
(A) ENGINE :
Water cooled diesel engine suitable for Generator application
with a shaft output of 200 BHP 1500 RPM under NTP
condition . The Engine Shall Comprise the following
standard fitting flexible coupling, fly wheel,air cleaner, fan
blower radiator, water pump, fuel filter and lubricatingoil
filter etc
D.ALTERNATOR:
Sl.
No
Qty
Description
Rate
Per
Amount
3
160 KVA /128KW Capacity Brushless Alternator AC 3phase
50c/s 415/420V 0.8PF 1500 RPM under NTP conditions
conforming to IS 13364 (part - II) 1992 to be means of
coupling
Sl.
No
Qty
Description
Rate
Per
Amount
3
E.AMF CONTROL PANEL
The AMF control panel cubical should be fabricated with
vermin proof and duct proof best quality sheet steel and floor
mounted with removable rear panels and hinged front door
with enamel paint and incorporating the following suitable
provisions for connecting incoming and out going leads
having been made on the control panel
Sl.
No
Qty
Description
3
release , instant short circuit.
25) Rectangular copper bus bars (1 No. for each phase ,
neutral and earthing terminal) of adiquate capacity
duly colour coded with heat shrinkable PVC sleaves.
Rate
Per
Amount
Sl.
No
Qty
Description
Rate
Per
Amount
3
26) 1 No. mains voltage monitor
27) Hooter / Audio alarm for indication set fails to start
and for DG O/L
28) 1 set timer
29) Audio visual indicator arrangements for
a)low lubricating oil pressure
b) High water temparature.
c) Over speed
30) 1 No. earth fault relay
31) Isolator to isolate the neutral
Note:
1. The Control panel should be complete with necessary
fuses , cables , lables, other accessorries with
neutral isolation arrangements
2. The engine should trip for the following conditions
a) Low lubricant pressure
b) High water temparature.
c) Over speed
(F) Fuel tank : Fuel tank of 250 litrs a Capacity and with
Inlet and Outlet connections level indicator with scale etc
..,
(G) .BASE FRAME:
The Base frame should be Fabricated MS channel frame of
rigidly welded constrution for mounting of Generator set .
The Engine and Alternator should be coupled by suitably
designed diaphragm type flexible coupling with guard and
mounted on the base frame with proper alignment .
Sl.
No
Qty
Description
Rate
4
3
Nos. Supply , Testing Commissioning and Handing over of 1no
835000.00
125 KVA Diesel Generator set(Make Kirlokar/Ashok
Leylend/Cummins) of 0.8 P.F three Phase 15V / 420 volts,50
C/S 1500 RPM CPCB Approved capacity compressing of
Developing 156 BHP Water cooled clock wise rotating with
100 KW / 125 KVA operating capacity Brush Less
Alternator close coupled underneath fuel tank ,standard
safeties, LLOP With stop solenoid ,battery with lead ,Electric
start and Anti Vibration mountings and accessories and
AMF control panel as detailed below including transporting
and Unloading charges
Per
Amount
Ea
3340000.00
(A) ENGINE :
Water cooled diesel engine suitable for Generator application
with a shaft output of 156 BHP 1500 RPM under NTP
condition . The Engine Shall Comprise the following
standard fitting flexible coupling, fly wheel,air cleaner, fan
blower radiator, water pump, fuel filter and lubricatingoil
filter etc
(B) 12/24 Volt Electronic Starting Equipment Complete
with Starter motor dynamo standard batteries with cable
flexible exhaust piping of 50cms Length
Engine Instrument Panel / Mounted
Starting push button /starting key lubricating oil temperature
gauge lubricating oil pressure gauge water temperature
gauge safety control for low lubricating oil pressure , safety
control for high water temperature safety control for over
speed ,Hour meter(mechanical)and RPM indicator battery
charging ammeter. The engine should be cabable of
providing 10% over load for one hour for every 11hours
continous run at full load
D.ALTERNATOR:
125 KVA /100 KW Capacity Brushless Alternator AC 3phase
50c/s 415/420V 0.8PF 1500 RPM under NTP conditions
conforming to IS 13364 (part - II) 1992 to be means of
coupling
Sl.
No
Qty
Rate
Per
Amount
Sl.
No
Qty
Description
Rate
Per
Amount
Sl.
No
Qty
Description
Rate
Per
Amount
Sl.
No
Qty
Description
Rate
Per
Amount
10
Sl.
No
Qty
Description
3
Nos. Supply , Testing Commissioning and Handing over of 1no
62.5 KVA Diesel Generator set of(Make
Kirlokar/Ashok Leylend/Cummins) 0.8 P.F three Phase
415V / 420volts,50 C/S 1500 RPM CPCB Approved
capacity compressing of Developing 83 BHP Water
cooled clock wise rotating with 50 KW / 62.5 KVA
operating capacity Brush Less Alternator close coupled
underneath fuel tank ,standard safeties, LLOP With stop
solenoid ,battery with lead ,Electric start and Anti Vibration
mountings and accessories and AMF control panel as
detailed below including transporting and Unloading
charges
Rate
Per
Amount
607500.00 Ea
4860000.00
11
Sl.
No
Qty
Description
Rate
Per
Amount
(A) ENGINE :
Water cooled diesel engine suitable for Generator application
with a shaft output of 83 BHP 1500 RPM under NTP
condition . The Engine Shall Comprise the following
standard fitting flexible coupling, fly wheel,air cleaner, fan
blower radiator, water pump, fuel filter and lubricatingoil
filter etc
(B) 12/24 Volt Electronic Starting Equipment Complete
with Starter motor dynamo standard batteries with cable
flexible exhaust piping of 50cms Length
( C ) Engine Instrument Panel / Mounted
Starting push button /starting key lubricating oil temperature
gauge lubricating oil pressure gauge water temperature
gauge safety control for low lubricating oil pressure , safety
control for high water temperature safety control for over
speed ,Hour meter (mechanical) and RPM indicator battery
charging ammeter. The engine should be cabable of
providing 10% over load for one hour for every 11hours
continous run at full load
D.ALTERNATOR:
62.5 KVA / 50 KW Capacity Brushless Alternator AC 3phase
50c/s 415/420V 0.8PF 1500 RPM under NTP conditions
conforming to IS 13364 (part - II) 1992 to be means of
coupling
E.AMF CONTROL PANEL
The AMF control panel cubical should be fabricated with
vermin proof and duct proof best quality sheet steel and floor
mounted with removable rear panels and hinged front door
with enamel paint and incorporating the following suitable
provisions for connecting incoming and out going leads
having been made on the control panel
1) AC Ammeter and selector switch
2) Voltmeter and selector switch
3) 3 Nos current Transformer with suiatable ratio
4) Frequency meter
5) KWH meter
6)1 No. Power factor meter
7) Battery charging set comprising of the following for
charging the battery from mains
a) Transformer/Rectifier
b) DC Ammeter
12
Sl.
No
Qty
Description
Rate
Per
Amount
c) DC Volt meter
d) ON / OFF switch
e) Charging rate selector switch
f) push botton start
13
Sl.
No
Qty
Description
Rate
Per
Amount
Sl.
No
Qty
Description
Rate
Per
Amount
Note:
1. The Control panel should be complete with necessary
fuses , cables , lables, other accessorries with
neutral isolation arrangements
15
Sl.
No
Qty
Description
Rate
Per
Amount
20
(A) ENGINE :
Water cooled diesel engine suitable for Generator application
with a shaft output of 56 BHP 1500 RPM under NTP
condition . The Engine Shall Comprise the following
standard fitting flexible coupling, fly wheel,air cleaner, fan
blower radiator, water pump, fuel filter and lubricatingoil
filter etc
16
Sl.
No
Qty
Description
3
(B) 12/24 Volt Electronic Starting Equipment Complete
with Starter motor dynamo standard batteries with cable
flexible exhaust piping of 50cms Length
Rate
Per
Amount
17
Sl.
No
Qty
Description
3
( C ) Engine Instrument Panel / Mounted
Rate
Per
Amount
Sl.
No
Qty
Description
Rate
Per
Amount
19
Sl.
No
Qty
Description
Rate
Per
Amount
12) 1 set low voltage HRC fuse for the short circuit
protection of the alternator
13) 1 set DC control relay incorporating engine start/
stop and failure to start/lock out
14) 1 set selector switch auto / manual
15) 1 NO. push botton start
16) 1 NO. push botton stop
17 ) 1 NO. push botton reset
18) 1 No. signal lamp for indicating load ON main
19) 1 No. signal lamp for indicating load ON set
20) 1 No. signal lamp for indicating fails to starts.
21) 1 No. signal lamp for indicating set running
22) 1 No. signal lamp for indicating bettery charger ON
23) 1 set pilot lamp of 3 Nos
24) MCCB of 63 A capacity with magnetic over load
release , instant short circuit.
25) Rectangular copper bus bars (1 No. for each phase ,
neutral and earthing terminal) of adiquate capacity
duly colour coded with heat shrinkable PVC sleaves.
26) 1 No. mains voltage monitor
27) Hooter / Audio alarm for indication set fails to start
and for DG O/L
28) 1 set timer
29) Audio visual indicator arrangements for
a)low lubricating oil pressure
b) High water temparature.
c) Over speed
30) 1 No. earth fault relay
31) Isolator to isolate the neutral
Note:
1. The Control panel should be complete with necessary
fuses , cables , lables, other accessorries with
neutral isolation arrangements
2. The engine should trip for the following conditions
a) Low lubricant pressure
b) High water temparature.
c) Over speed
(F) Fuel tank : Fuel tank of 150 litrs a Capacity and with
Inlet and Outlet connections level indicator with scale etc
..,
20
Sl.
No
Qty
Description
Rate
Per
Amount
431200.00 Ea
431200.00
(A) ENGINE :
Water cooled diesel engine suitable for Generator application
with a shaft output of 20.5 BHP 1500 RPM under NTP
condition . The Engine Shall Comprise the following
standard fitting flexible coupling, fly wheel,air cleaner, fan
blower radiator, water pump, fuel filter and lubricatingoil
filter etc
(B) 12/24 Volt Electronic Starting Equipment Complete
with Starter motor dynamo standard batteries with cable
flexible exhaust piping of 50cms Length
( C ) Engine Instrument Panel / Mounted
21
Sl.
No
Qty
Description
Rate
Per
Amount
3
Starting push button /starting key lubricating oil temperature
gauge lubricating oil pressure gauge water temperature
gauge safety control for low lubricating oil pressure , safety
control for high water temperature safety control for over
speed ,Hour meter (mechanical) and RPM indicator battery
charging ammeter. The engine should be cabable of
providing 10% over load for one hour for every 11hours
continous run at full load
22
Sl.
No
Qty
Description
Rate
Per
Amount
D.ALTERNATOR:
15 KVA / 12 KW Capacity Brushless Alternator AC 3phase
50c/s 415/420V 0.8PF 1500 RPM under NTP conditions
conforming to IS 13364 (part - II) 1992 to be means of
coupling
E.AMF CONTROL PANEL
The AMF control panel cubical should be fabricated with
vermin proof and duct proof best quality sheet steel and floor
mounted with removable rear panels and hinged front door
with enamel paint and incorporating the following suitable
provisions for connecting incoming and out going leads
having been made on the control panel
Sl.
No
Qty
Description
Rate
Per
Amount
24
Sl.
No
Qty
Description
Rate
Per
Amount
25
Sl.
No
Qty
Description
Rate
Per
Amount
721200.00
(A) ENGINE :
Water cooled diesel engine suitable for Generator application
with a shaft output of 10 BHP 1500 RPM under NTP
condition . The Engine Shall Comprise the following
standard fitting flexible coupling, fly wheel,air cleaner, fan
blower radiator, water pump, fuel filter and lubricatingoil
filter etc
(B) 12/24 Volt Electronic Starting Equipment Complete
with Starter motor dynamo standard batteries with cable
flexible exhaust piping of 50cms Length
( C ) Engine Instrument Panel / Mounted
Starting push button /starting key lubricating oil temperature
gauge lubricating oil pressure gauge water temperature
gauge safety control for low lubricating oil pressure , safety
control for high water temperature safety control for over
speed ,Hour meter (mechanical) and RPM indicator battery
charging ammeter. The engine should be cabable of
providing 10% over load for one hour for every 11hours
continous run at full load
26
Sl.
No
Qty
Description
Rate
Per
Amount
D.ALTERNATOR:
5 KVA / 4 KW Capacity Brushless Alternator AC single
phase 50c/s 220 V/ 0.8PF 1500 RPM under NTP conditions
conforming to IS 13364 (part - II) 1992 to be means of
coupling
27500.00
Job
110000.00
21500.00
Job
86000.00
27
Sl.
No
Qty
Description
3
Job ERECTION OF GENSET : Providing suitable concrete
foundation with cement concrete 1:2:4 with sand cushion all
around the foundation erection of 62.5 KVA Generator set
over the existing foundation and erection of generator set
with proper alignment over the existing foundation to suit
62.5 KVA Genset foundation size L3200 mm x w 1500 mm
x H 450 mm
Rate
Per
Amount
16000.00
Job
128000.00
10
20
13000.00
Job
260000.00
11
10000.00
Job
10000.00
12
7000.00
Job
21000.00
13
200
2600.00
Mtr
520000.00
14
160
1763.30
Ea
282128.00
28
Sl.
No
Qty
Description
3
15 2300 Mtrs Supply and run of 25mm x 3mm tinned copper flat with
necessary clamps / supports on wall / floor / ground for earth
connection
(SD-76)
1
Rate
Per
Amount
411.20
Mtr
945760.00
29
Sl.
No
Qty
Description
Rate
Per
Amount
2000.00
set
30000.00
Job 1080000.00
18 1440 Mtrs Supply and laying of 31/2 X 185 sq.mm PVC armoured
LTUG cable in a trench to be excavated at a depth of 0.75
metre putting 0.15 mt. Layer of sand and covering the cable
completely with bricks and sand and refilling the earth to
make good.(SD - 211)
1188.40
Mtr 1711296.00
19
480
1106.70
Mtr
531216.00
20
48
Nos Supply and fixing of brass cable gland for 3 1/2 x 185 sqmm
PVC armoured LTUG cable with earth connection (SD - 193
)
409.40
Each
19651.20
21
48
309.80
Each
14870.40
627.40
Mtr
903456.00
23
527.20
Mtr
253056.00
16
40
17
36
480
3
set Supply of tools sucjh as1 no 15" cutting piler , 1no 6"
screws driver , 2 nos 9" screw driver , 1 set 6 nos double
ended spanner ,1No 1/2 hammer , 1No spanner for
removing engine oil plug 1no line tester required for the
mainttenence and operation of generator set -1 set
80000.00
30
Sl.
No
Qty
24
48
Description
3
Nos Supply and fixing of brass cable gland for 3 1/2 x 70 sqmm
PVC armoured LTUG cable with earth connection (SD - 193
)
Rate
Per
Amount
293.25
Each
14076.00
31
Sl.
No
Qty
Description
Rate
Per
Amount
183.20
Each
521.60
Mtr 1799520.00
432.20
Mtr
518640.00
28
48
Nos Supply and fixing of brass cable gland for 3 1/2 x 50 sqmm
PVC armoured LTUG cable with earth connection (SD - 188
)
226.20
Each
10857.60
29
48
175.00
Each
8400.00
30
180
403.60
Mtr
72648.00
31
60
353.20
Mtr
21192.00
32
Nos Supply and fixing of brass cable gland for 3 1/2 x 25 sqmm
PVC armoured LTUG cable with earth connection (SD - 186
)
212.40
Each
1274.40
33
163.40
Each
980.40
25
48
3
Nos Supply and providing cable end termination of 3 1/2 x 70
sqmm PVC LTUG Aluminium armoured cable with
necessary aluminium cable sockets by crimping etc. with
electrical connection complete (SD - 238)
8793.60
32
Sl.
No
Qty
34
540
Description
3
Mtrs Supply and laying of 2 X 16 sq.mm PVC armoured LTUG
cable in a trench to be excavated at a depth of 0.75 metre
putting 0.15 mt. Layer of sand and covering the cable
completely with bricks and sand and refilling the earth to
make good.(SD - 199)
Rate
Per
Amount
301.30
Mtr
162702.00
33
Sl.
No
Qty
Description
3
Mtrs Supply and clamping of 2 x 16 sq. mm PVC LTUG
armoured LTUG cable on post or on wall with MS Clamps.
(SD - 217)
Rate
Per
Amount
204.70
Mtr
36846.00
152.40
Each
2743.20
35
180
36
18
Nos Supply and fixing of brass cable gland for 2 x 16 sqmm PVC
armoured LTUG cable with earth connection (SD - 183 )
37
900
Mtrs Supply and laying of 12 core x 2.5 sq.mm PVC copper cable
in a trench to be excavated at a depth of 0.75 metre covering
the cable completely through suitable G.I. pipe and refilling
the earth to make good (DATA - A)
600.30 Mtr
540270.00
38
360
512.10 Mtr
184356.00
39
2219.60 Mtr
6658.80
40
Job Providing fuel to run the DG set for 25%, 50%, 75% and
full load testing and Commissioning.
540000.00
540000.00
20 Nos 40 KVA
- Rs 5,000/- Each =
20,000.00
41
417
Nos Supply and fixing of 12 way single pole and neutral MCB
sheet steel enclosure Distribution board with Double Door
and 1No. 32 Amps DP MCB as incoming and 10 Nos 6
Amps to 32Amps SPMCB as outgoing in flush with wall
and making good of the concealed portion with earth
connection only. The MCB DB and MCB's should be with
ISI mark (Like standard make) (Data-D )
42
137
5514.80 Each
755527.60
34
Sl.
No
Qty
Rate
Per
Amount
35
Sl.
No
Qty
Description
Rate
Per
Amount
3
Supply and fixing of Vertical type 4 way triple pole netural
MCB distribution board double door type with 63A 4 pole
MCB isolator as incoming , 2 Nos 32 A TP MCB 6 Nos 6 to
32 A SPMCB asoutgoing inflush with wall and making
good of the concealed portion with earth connection. The
MCB DB and MCB outgoing in flush with wall and making
good of the concealed portion with earth connection only.
The MCB DB and MCB's should be with ISI mark (Like
standard make)
(DATA-F)
43
20
No
44
16272.30 Each
325446.00
16272.30 Each
130178.40
306.90 mtrs
630679.50
789.40 mtrs
331548.00
1170.70 mtrs
224774.40
420
48
192
36
Sl.
No
Qty
Description
Rate
Per
Amount
37
Sl.
No
Qty
49
56
Description
3
mtrs Renewal by supply and run of 4 of 25 (168/0.45)sqmm PVC
Rate
Per
Amount
1271.20 mtrs
71187.20
50
LS
LS
278000.00
41622212.20
51
LS
Adverticement charges
400000.00
52
LS
416200.00
53
LS
1031587.80
Total 43470000.00
(Rupees Four crore thirty four lakhs and seventy thousand Only)
38
1
2
Kancheepuram District
1 Chengalpattu
Thiruvallur District
1 Thiruvallur
2 Poonamalle
160
KVA
125
KVA
1
1
3 Ponneri
4 Tiruthani
5 Thiruvottiyur
6 Ambattur
7 Pallipattu
8 Uthukottai
Vellore District
1 Ranipet
2 Gudiyatham
1
1
2
1
5 Solinghur
6 Wallajapet
7 Ambur
1
1
8 Arcot
9 Katpadi
10 Vellore
40 KVA
3 Vaniyampadi
4 Arakkonam
62.5
KVA
Thiruvannamalai District
1 Thiruvannamalai
Cuddalore District
1 Cuddalore
2 Chidambaram
1
1
1
1
2
1
3 Virudhachalam
4 Panrutti
5 Neyveli
6 Portonovo
7 Kattumannarkoil
1
1
1
15
KVA
5 KVA
1
2
3
4
5
Villupuram District
Gingee
Ulundurpet
Tirukoilur
Vanur
Sankarapuram
Grand Total
3
1
1
1
1
20
40 KVA
SR
160 KVA
125 KVA
62.5 KVA
40 KVA
1170000
1600000
278000
1982000
4748000
1187000
1187000
1187000
1187000
1187000
990000
1800000
1440000
990000
720000
720000
720000
990000
720000
990000
1600000
1600000
2550000
1248000
1248000
1248000
1023000
1023000
1023000
15 KVA
5 KVA
1100000
1248000
1023000
720000
1023000
278000
6782000 5520000
8952000
20118000
720000
1100000
43470000
DAT A
SHEET
Qty
Description
Rate
Per
Amount
DATA -A
1
390.00
Mtr
390.00
28.20
Mtr
28.20
157.60
Mtr
157.60
2.98
Mtr
2.98
21.50
Mtr
21.50
600.28
Rate/Metre = Rs.
600.30
or
600.30
DATA - B
Rate as per SD 221
258.20
Less
1
182.00
Mtr
182
76.20
Add
1
mt
390.00
mt
390.00
45.90
mt
45.90
512.10
512.10
DATA - C
Rate as per SD 164
2819.60
Less
1
1500.00
Mtr
1500
1319.60
Add
1
900.00
mt
900.00
over switch
Rate/Metre = Rs.
2219.60
2219.60
45
DATA - D
1.00
No 12 way single pole and neutral MCB distribution board
(SR) double Door.
1.00
No 32A DP MCB
10.00 Nos 6A to 32A SPMCB
LS
Wall cutting, grouting and flushing etc.,
LS
Earth connection
1180.00
Ea
1180.00
490.00
148.00
LS
LS
Ea
Ea
490.00
1480.00
26.35
15.20
3191.55
31.92
476.00
3699.47
Ea
2060.00
664.00
Ea
664.00
148.00
Ea
1776.00
Add 1% sundries
Labour Charges (SD-167)
Rate / ea Rs.
3699.47
3699.50
DATA -E
1.00
No 4 way Horizontal TPMCB DB
double Door type (SR).
1.00
No 40 A FP MCB isolator
12.00
2060.00
LS
LS
53.45
LS
Earth connection
LS
15.20
4568.65
45.69
900.50
5514.84
Add 1% sundries
Labour Charges (SD-179)
Rate / ea Rs.
5514.84
5514.80
DATA -F
1.00
No 4 way Vertical type TPMCB DB
double Door type (SR).
5110.00
Ea
5110.00
1.00
693.00
Ea
693.00
2.00
738.00
Ea
1476.00
6.00
148.00
Ea
888.00
LS
LS
53.45
LS
Earth connection
LS
15.20
8235.65
82.36
900.50
Add 1% sundries
Labour Charges (SD-179)
46
5
9218.51
Rate / ea Rs.
9218.51
9218.50
47
DATA -G
1.00
No 8 way Vertical type TPMCB DB
double Door type (SR).
6290.00
Ea
6290.00
845.00
Ea
845.00
1.00
3.00
Nos 63 A TPMCB
1490.00
Ea
4470.00
3.00
Nos 32 A TPMCB
738.00
Ea
2214.00
9.00
148.00
Ea
1332.00
LS
LS
53.45
LS
Earth connection
LS
15.20
15219.65
152.20
900.50
16272.35
Add 1% sundries
Labour Charges (SD-179)
Rate / ea Rs.
16272.35
16272.30
DATA - H
Rate as per SD 62
Less
24737.08
360
51.20
Mtr
18432
6305.08
360
Add
No. 10 sq mm copper wire
76.80
mt
27648.00
33953.08
33953.08
3143.00
71049.16
789.44
789.40
DATA - I
360
90
360
90
Rate as per SD 62
Less
Mtrs 6 sq mm copper wire
Mtrs 32 mm PVC Pipe
Add
No. 19 sq mm copper wire
(AS per SD 131)
Mtrs 50 mm PVC Pipe
24737.08
51.20
45.90
18432.00
4131.00
22563.00
252.00
90720.00
98.00
8820.00
99540.00
22563.00
2174.08
mt
99540.00
101714.08
48
5
508.57
3143.00
105365.65
1170.73
1170.70
49
DATA - J
Rate as per SD 62
Less
360
90
360
90
24737.08
Add
No. 25 sq mm copper wire
Mtrs 50 mm PVC Pipe
51.20
45.90
277.00
98.00
18432.00
4131.00
22563.00
99720.00
8820.00
108540.00
22563.00
2174.08
mt
108540.00
110714.08
553.57
3143.00
114410.65
1271.23
1271.20
50
Kancheepuram District
160
125 KVA
62.5 KVA
40 KVA
15 KVA
5 KVA
185
185
70
50
25
2x16
1 Chengalpattu
2
180
60
12 way
LDB
SL
No.
Tally sheet
18
Thiruvallur District
1 Thiruvallur
180
60
36
2 Poonamalle
180
60
36
3 Ponneri
680
240
24
4 Tiruthani
170
60
5 Thiruvottiyur
170
60
6 Ambattur
170
60
7 Pallipattu
170
60
8 Uthukottai
170
60
Vellore District
1 Ranipet
2 Gudiyatham
3 Vaniyampadi
180
180
60
60
18
340
120
12
4 Arakkonam
180
60
170
60
15
5 Solinghur
170
60
6 Wallajapet
170
60
7 Ambur
180
60
8 Arcot
170
9 Katpadi
10 Vellore
4
180
60
60
6
9
180
60
36
180
60
36
Thiruvannamalai District
1 Thiruvannamalai
Cuddalore District
1 Cuddalore
360
120
36
2 Chidambaram
180
60
3 Virudhachalam
180
60
4 Panrutti
180
60
5 Neyveli
180
60
6 Portonovo
180
60
6 Kattumannarkoil
180
60
Villupuram District
1 Gingee
2 Ulundurpet
180
60
3 Tirukoilur
540
170
60
4 Vanur
190
Total 720
185 sq mm L LTUG =
185 sq mm C LTUG =
240
720+720 =1440
240+240=480
720
240
1440
480
60
60
3450 1200
9
6
180
5 Sankarapuram
180
180
60
540
180
417
4 of 6 sq
mm run
6
306
90
12
712
180
14
12
712
180
14
8
4
408
120
84
2
1
102
30
21
2
1
102
30
21
2
1
102
30
21
2
1
102
30
21
2
1
102
30
21
153
45
324
90
204
60
2
1
42
24
4 of 25 sq
mm run
4 of 25sq
mm run
4 of 16 sq
mm run
4 of 10 sq
mm run
8way
Vertical
4way
Vertical
2 of 6 sq
mm run
4way
Horizontal
heet
2
2
255
75
21
102
30
21
102
30
21
153
45
102
30
153
45
12
712
180
14
12
712
180
14
12
712
180
3
2
1
1
24
24
21
24
162
45
24
162
45
24
162
45
24
102
30
21
102
30
21
102
30
21
102
3
162
45
24
102
30
21
58
15
21
102
30
137
20
7650 2055
420
192
56