Sie sind auf Seite 1von 30

QUEZON CITY POLYTECHNIC UNIVERSITY

673 Quirino Highway, San Bartolome, Novaliches, Quezon City


College of Engineering
Electronics Engineering Department

PROACTIVE CAMERA ENABLED VEHICLE


SECURITY SYSTEM USING GSM GPS
NAVIGATION TECHNOLOGY

AGUILON, JAMES LLOYD J.


ALVAREZ, HADRIAN D.
CLEOFE, MARK EDWIN, JR. R.
VILLARUZ, ANNETHONETTE G.

SUBMITTED TO THE FACULTY OF THE


COLLEGE OF ENGINEERING,
QUEZON CITY POLYTECHNIC UNIVERSITY
IN PARTIAL FULFILLMENT OF THE REQUIREMENTS
FOR THE DEGREE OF

BACHELOR OF SCIENCE IN ELECTRONICS ENGINEERING

JANUARY 2015

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

CHAPTER I
THE PROBLEM AND ITS SETTING

1.1 Background of the Study


Republic Act No. 6539 An Act Preventing and Penalizing Carnapping or
Anti Carnapping Act of 1972 defines carnapping (vehicle theft) as taking, with intent
to gain, of a motor vehicle belonging to another without the latters consent, or by means
of violence against or intimidation of persons, or by using force upon things.
In the last few years, vehicle theft has been one of the most committed crimes
across the globe. In the United States of America alone, there were an estimated 721, 053
thefts of motor vehicles nationwide in 2012 (Federal Bureau of Investigation, Uniform
Crime Report: Crime in the United States, 2012). Motor vehicles include all land vehicles
with an engine that run on the road, including cars, motorcycles, buses, lorries,
construction and agricultural vehicles. The estimated rate of motor vehicle thefts was
229.7 per 100, 000 inhabitants. Furthermore, the United States have a record of 1, 261,
226 thefts way back 2003, which made it the country with the most number of vehicle
thefts since 2003 up to 2012 in the world, with a rate of 430.6 (per 100, 000 inhabitants).
More than $4.3 billion (Php 193.5 billion) was lost to motor vehicle thefts in 2012 alone.
The average dollar loss per stolen vehicle was $6, 019 (Php 270, 855). (FBI, UCR: Crime
in the United States, 2012).
However, it wasnt until 2006 from which the United States experienced the most
drastic record of private car thievery worldwide since 2003 up to 2012, with 852, 600

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

cases and a rate of 283.3. Italy came in second with 182, 524 cases which gave a rate of
309.0. Sweden, on the other hand, reported 31, 588 vehicle thefts on 2005, making them
the country with the highest rate, 349.8 per 100, 000 population from 2003 to 2012. This
is closely followed by Bahrain with 3, 030 cases, also in 2005, with a rate of 344.5
(United Nations Office on Drugs and Crime, 2013).
Philippines also got its fair share of motor vehicle thefts. Just recently, Philippine
National Police Directorate for Investigation and Detective Management (PNP
DIDM) records indicate that the cases of car theft in the country jumped to 10, 039 from
5, 599 last year. (The Philippine Star, 2015). With 84 percent of all incidents, National
Capital Region (NCR) documented the biggest number of stolen vehicles in the country
in 2011, via PNP Highway Patrol Group. The Region 4A (CALABARZON) and
Region 3 (Central Luzon) were a distant second and third, accounting ten percent and
five percent of the total, respectively. In Metro Manila, 26 percent of all cases (71 stolen
cars and 45 stolen motorcycles) occurred in Quezon City. Manila came in second with 21
percent (48 cars and 44 motorcycles stolen) while Makati was a far third with only seven
percent (Philippine Daily Inquirer, 2011).
Out of around 286 stolen motor vehicles during January to April, 2011, 207 were
stolen while parked (SWP), while 60 were either seized at gunpoint (SAG) with
intimidation or forcibly taken. SWP accounts for 72.37 percent of the total vehicle theft
incidents in the time period (National Statistics Office: The Philippines in Figures 2011,
2011).

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

In the most recent records of PNP Crime Maps this year, Quezon City topped the
list of having the most number of car thefts in Metro Manila from January 1 to September
9, 2015, with 170 cases in total. Valenzuela and Manila followed with 22 and 21 cases of
vehicle theft, respectively. Mandaluyong came fourth with 15 cases, while Pasig and San
Juan tied at the fifth spot with 14 cases (Manila Bulletin, 2015).
With all these alarming rates of vehicle thefts across the globe, everyone should
take precaution. These records only ascertained that despite the built-in security features
of todays car models and firm police programs of law-implementation, one still cannot
fully ensure the safety of their vehicles, and their lives in extension.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

1.2 Introduction
There is no doubt that Philippines has progressed these last few decades at such
an enormous rate that a lot of companies have strongly established themselves here. Vast
amount of workforce is what these companies bring with them. Although transportation
to such a large mass has been tended by the government via public transportation
systems, there are still a lot of aspects that made public commute uncomfortable and
nerve-wracking. Purchasing your own vehicle is no longer a luxury but a necessity,
especially to those who work in the metro.
Vehicle theft is one of the many concerns when owning a private car. To solve this
issue, GSM GPS system can be incorporated to the security system of your vehicle. The
development of satellite communication technology made it easy to determine the vehicle
whereabouts. Nowadays, GPS used in cars, ambulances, fleets and police vehicles are
common sights on the roads of developed countries (Ramani et al, 2013).
The GPS/GSM Based System is one of the most vital systems, which integrates
both GSM and GPS technologies. It is necessary due to the many of applications of both
GSM and GPS systems and the wide usage of them by millions of people throughout the
world (Chen et al, 2010). This system which is designed for private cars, provides realtime location and vehicle manipulation at fairly and considerable features.
The Proactive Camera Enabled Vehicular Security System using GSM GPS
Navigation Technology uses short message services (SMS) protocol available in the
cellular phone to achieve the control and communication between the user and the

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

proposed system. Upon leaving the car, the owner should send a text message to the
system, Activate, to enable the security system. Then upon entering, the word
Deactivate will disable the entire security system. The system uses infrared sensors
which will be able to detect movement in the car. When it does detect movement, the
system will then enable the Internet Protocol Camera to take a picture and then send a
text message to the owner. The message content is Somebody illegally entered your car.
Check the feed at (IP Address). The owner will then be able to send an SMS with the
keyword, Secure. The system program will then verify the code, if correct, inactivates
the vehicle system via Relay Switch and send the current location: latitude and longitude
coordinates (GPS data) where the vehicle is via SMS again to the owner. The disable
feature of this system prevents the snatcher from taking the vehicle any further.
The proposed system determines the current location of the vehicle via GPS. This
system uses SkyNav SKG25B, which is a complete GPS engine module that features
super sensitivity, ultra-low power and small form factor. The GPS signal is applied to the
antenna input of module, and a complete serial data message with position, velocity and
time information is presented at the serial interface with NMEA protocol or custom
protocol. It is based on the high performance features of the MediaTek MT3329 singlechip architecture, its 165dBm tracking sensitivity extends positioning coverage into
place like urban canyons and dense foliage environment where the GPS was not possible
before. The small form factor and low power consumption make the module easy to
integrate into portable device like PNDs, mobile phones, cameras and vehicle navigation
systems.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

Also, the system uses SIM900 GSM-GPRS Module for its GSM connection. It
offers Quad-Band Range and has 3.3V TTL serial port. An IP Camera is used for realtime feed of the car. Arduino (Gizduino V) makes up for the integration and data analysis
gathered by the system modules.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

1.3 Conceptual Framework


This study presents a new design for a vehicle anti-theft system as a solution to
secure cars from unauthorized access. It is an enhancement and development of the
already existing security system to attain the economic environment for security,
maintenance and productivity basis. It is incorporated with GPS technology to track and
locate position of the car. The input automatically sends warning message to the owner
when an intruder was detected. Automatically the system informs the owner and block
the possible theft of the vehicle. The protection form of the program allows the car owner
to track, locate and view the current alterations within the car. The software design was
constructed and developed to introduce the car owner with a new system that allows
tracking and determining the location of the car. It also allows the car owner to use an
android phone for detecting an intruder in the vehicle. Furthermore, using IP Cam, the car
owner will know who the non-authorized user is.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

1.4 Theoretical Framework


Global Positioning System
Global Positioning System (GPS) is a space-based navigation system that
provides location and time information in all weather conditions, anywhere on or near the
Earth where there is an unobstructed line of sight to four or more GPS satellites. GPS
satellites circle the earth twice a day in a very precise orbit and transmit signal
information to earth. GPS receivers take this information and use tri-lateration to
calculate the user's exact location. Essentially, the GPS receiver compares the time a
signal was transmitted by a satellite with the time it was received.
Android Mobile
Android is a mobile operating system (OS) currently developed by Google, based
on the Linux kernel and designed primarily for touch-screen mobile devices such as
smart-phones and tablets. Android technology system is open for modification. Google
came up with an innovative operation system termed as ANDROID, which is open
system architecture with customizable third party development and debugging
environment which helps the users to manipulate the features and it offers developers
free platform to make their own applications. This gives users the opportunity to change
and enhance products based on personal preferences.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

Anti-Theft System
An anti-theft system is any device or method used to prevent or deter the
unauthorized appropriation of items considered valuable. There are two kinds of antitheft system, Passive and Active Anti-theft Systems. Passive and active anti-theft devices
are the two options available when considering an anti-theft system. Passive devices
automatically arm themselves when the vehicle is turned off, the ignition key removed, or
a door is shut. No additional action is required. Active devices require some independent
physical action before they are set, such as pushing a button, or placing a "lock" over a
vehicle component part. This physical action must be repeated every time the anti-theft
device is set or it will not function.
Short Message Service
Short Message Service (SMS) is a text messaging service component of phone,
Web, or mobile communication systems. It uses standardized communications protocols
to allow fixed line or mobile phone devices to exchange short text messages. The term
"SMS" is used for both the user activity and all types of short text messaging in many
parts of the world. SMS allows for text messages of 160 characters (letters, numbers and
symbols) in length. Or for other alphabets, such as Chinese or Arabic, the maximum
message size is limited to just 70 characters.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

Internet
Internet is the global system of interconnected computer networks that use the
Internet protocol suite (TCP/IP) to link billions of devices worldwide. It is a network of
networks that consists of millions of private, public, academic, business, and government
networks of local to global scope, linked by a broad array of electronic, wireless, and
optical networking technologies. The Internet carries an extensive range of information
resources and services, such as the inter-linked hypertext documents and applications of
the World Wide Web (WWW), electronic mail, telephony, and peer-to-peer networks for
file sharing.
Internet Protocol
Internet Protocol (IP) is the principal communications protocol in the Internet
protocol suite for relaying datagrams across network boundaries. Its routing function
enables internetworking, and essentially establishes the Internet. Internet Protocol is
responsible for addressing hosts and for routing datagrams (packets) from a source host
to a destination host across one or more IP networks. For this purpose, the Internet
Protocol defines the format of packets and provides an addressing system that has two
functions: identifying hosts; and providing a logical location service.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

1.5 Statement of the Problem/ Objectives


1. To create and provide a design for enhancement of an anti-theft and protection
system for vehicles that will heighten the security status and also raise the
difficulty of theft to an almost infeasible level
2. To offer an easy and struggle-free means to locate your missing or thieved car
3. To upsurge owners involvement in the security system of their vehicles
4. To potentially lessen the number of auto thefts and to support local law
enforcement and government in reducing overall crime
5. To conserve the resources, like time and police force, which is normally needed to
address vehicle thefts

1.6 Scope and Delimitation


This study focuses to present the feasibility, cost-efficiency, and reimbursements
of a smart vehicle security system in improving the already existing safekeeping features
of todays vehicles.
The system prototype was tested with a 3 x 1 foot remote controlled car as a
simulation. The concept, however, remains the same. The relay will still cut up the power
supply of the remote-controlled car as it would in an actual vehicle. The data gathered are
susceptible to control variables that may influence the results of the experimentation.

1.7 Significance of the Study

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

The reason why this study is vital can be explained in three aspects. First, the
findings of this research will redound to the benefit of the society considering that vehicle
plays such a vital role in todays civilization. Vehicles evidently paved the way for
modernization and technological advancements in so many levels, and its safekeeping is
above monetary concerns. This is no longer about how one can buy another vehicle, its
about how we keep ourselves protected from criminals, who maybe desperate enough to
end ones life.
Second, it will provide an enhancement to an already existing security features of
todays vehicles and thereby increasing the level of infeasibility of vehicle theft. It will
address newer vehicle theft techniques that obviously outwitted the security which
vehicle manufacturers offer nowadays.
Third, the use this new technology will potentially assist law enforcement
programs in addressing the alarming rates of crimes across the globe. Since most of the
getaway vehicles used in various crimes are stolen, decreasing the rate of stolen car will
correspond to a decrease also in other crimes. Moreover, it is already evident that not
using a stolen car will easily give away their identifications.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

1.8 Definition of Terms

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

CHAPTER II
DISCUSSION OF PRIOR RESEARCH AND DEVELOPMENT
2.1 Foreign Research and Development
In many previous research works, the authors have given some analytical view of
the circuit used in the various projects, while in some other global positioning system
(GPS) is commonly used as global navigation satellite system is used to locate the
vehicles and also to stop the vehicle if stolen. The location information is sent in the form
of message containing latitude, longitude and speed information to the owner of the
vehicle or location can also be traced using internet through Google maps.
A number of developments have taken place in anti-theft systems for vehicles and
some of the relevant ones are as follows.
The utilization of ARM 7 microcontroller, GSM and GPS module together with
an accelerometer and temperature sensor is carried out by Joshi and Mahajan [Arm 7
based theft control, accident detection and vehicle positioning system, July 2014]. The
GPS and GSM module is being utilized for following the area of vehicle. The extra part is
being included is the accelerometer which essentially contains the MEMS sensor offering
a low-pass filter and is fundamentally utilized for Shake Detection, Orientation Detection
and Tap Detection. The utilization of temperature sensor is additionally being carried out
with a specific end goal to acquire the vehicle engine temperature which changes over the
estimation of temperature into electrical signal.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

A hybrid GPS-GSM localization of vehicles Tracking System has been developed


by Al-Khedher [Hybrid GPS-GSM localization of automobile tracking system, 2011] that
portrays an incorporated GPS-GSM framework to track vehicles utilizing Google Earth
application. The remote module has a GPS mounted on the moving vehicle to recognize
its present position, and to be exchanged by GSM with different parameters procured by
the car's information port as a SMS to a beneficiary station. The received GPS directions
or coordinates are sifted utilizing a Kalman filter to upgrade the precision of measured
position. After information processing, Google Earth application is utilized to view the
current area and status of every vehicle. This objective of this framework is to oversee
armada, police cars dissemination and auto burglary alerts.
A security system based on RFID, GPS and GSM by S. S. Pethakar, N. Srivastava
and S. D. Suryawanshi [RFID, GPS and GSM based vehicle tracing and employee
security system, 2012] consolidate the establishment of an electronic gadget in a vehicle,
with reason planned machine programming to empower the organization to track the
vehicle's area. At the point when the car pics the worker; he/she needs to swap the RFID
card. The micro controller matches the RFID card no. with its database records and sends
the representative's id, taxi id & the taxicab position co-ordinates to the organization unit
by means of GSM module. The GSM Modem will get the message through GSM in the
organization unit. On the off chance that worker ends up/herself in an issue, he/she will
press the catch. Microcontroller will distinguish the activity and sends a signal to the
GSM which will arrange with to the organization unit and police.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

The configuration and advancement of a burglary control framework for an


automobile, which is being utilized to anticipate/control the robbery of a vehicle has been
accounted for by Wankhade and Dahad [Real time vehicle locking and tracking system
using GSM and GPS technology-an anti-theft system, 2011]. The created framework
makes utilization of an implanted framework focused around Global System for Mobile
correspondence (GSM) engineering. The planned and created framework is introduced in
the vehicle. An interfacing portable is additionally associated with the microcontroller,
which is thusly, joined with the engine. Once, the vehicle is being stolen, the data is being
utilized by the vehicle manager for further handling. The data is passed onto the focal
handling protection framework which is as the SMS, the microcontroller unit peruses the
SMS and sends it to the Global Positioning System (GPS) module and utilizing the
triangulation system, GPS module sustains the precise area as scope and longitude to the
client's versatile.
Shaikh et al. [Arm7 based smart car security system, 2012] describe arm7 based
smart car security system. The principle point of this undertaking is to offer a
development security framework in automobile, which comprises of a face detection
subsystem, a GPS module, a GSM module and a control stage. The face location
subsystem can discover confronts in vehicle amid the period in which no one ought to be
in the auto, and make an alert uproariously or soundlessly. Alternate modules transmit
vital data to clients and help to keep eyes on vehicle constantly, actually when the vehicle
is lost. This framework model is based on the base of one inserted stage Arm7 which
controls all the processes.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

Jian-ming et al. [Automobile anti-theft system based on GSM and GPS module,
2012] describe vehicles against robbery framework utilizing GSM and GPS module. The
framework is created utilizing fast blended sort single-chip C8051f120 and stolen vehicle
is discovered by the utilization of vibration sensor. The framework stays in contact with
auto holder through the GSM module, for the safety and reliability of car.
Kaushik et al. [Anti-Theft vehicle security system, 2014] depicts an Anti-burglary
vehicle security framework which plans to permit access to the vehicle just if the
individual's finger impression matches with that put away in the framework .The
correlation will happen in MATLAB and result will be demonstrated on the LCD. On the
off chance that through illicit means the vehicle is accessed then vehicle fuel tank will be
bolted through Relay circuit so that at whatever point the tank gets unfilled, unapproved
individual will never again have the capacity to refuel the tank.
Ibrahim et al. [Microcontroller based anti-theft security system using GSM
networks with text message as feedback, 2012] describe a hostile to burglary security
framework that uses an installed framework outline with Dual Tone Multi Frequency
(DTMF) and a GSM to screen and shield an automobile. It secures the auto or vehicle
against burglary. Upon actuation, it naturally grounds the auto by detaching the ignition
scratch supply from the auto battery. In an attempt of theft through the car doors or boot,
the system sends text message to the car owner and at the same time starts up an alarm.
Nagaraja et al. [Design and development of a GSM based vehicle theft control
system, 2009] describe the outline and improvement of a GSM based vehicle robbery

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

control framework for a car. The created framework makes utilization of an inserted
framework focused around GSM innovation. An interfacing mobile or GSM modem is
associated with the microcontroller, which in term is joined with the engine through relay.
In the event that the vehicle is stolen, the data is sent to the owner that somebody has
stolen his vehicle. After that the user or owner will send the message to GSM modem or
mobile which is joined with motor ignition through transfer or relay to switch off the
engine.
Rashed et al. [A real time GSM/GPS based tracking system based on GSM mobile
phone, 2014] describe a GPS based tracking system that keeps track of the location of a
vehicle and its speed based on a mobile phone text messaging system. The system is able
to provide real-time text alerts for speed and location. The present location can be locked
and the system will alert the owner if the vehicle is moved from its present locked
location. In every one hour the GSM modem or mobile will inform the owner by
messaging its location in the form of latitude, longitude and speed information. The
owner or user can control or stop the vehicle by simply sending the message stop to GSM
modem or mobile connected to circuitry board. After receiving that message ignition
system will turn off.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

2.2 Local Research and Development


Philippines also had its contribution in the research of utilizing GSM GPS
technology as an added security feature of vehicles. Some of the relevant ones are as
follows.
Tolentino, I. M. and Talampas, M. R., describe the design, development, and
evaluation of a self-powered tracking system for vehicle security. 3 piezoelectric
generators (PG) in cantilever beam configuration were tuned to the dominant frequency
of a test vehicle. Voltage doublers were used to rectify the piezoelectric outputs and to
isolate the PGs. The harvester designed is not a perturb-and-observe type but directly
uses the rectified piezoelectric signals to track the maximum power point. With 30%
deviation from the nominal vibration magnitude and 1Hz deviation from the nominal
frequency, the harvester is able to maintain its operation within 6% of the MPP. The
harvester is able to operate with up to 70.86% efficiency and output 19.8mW of power
while consuming a maximum of 200uW. A 2-tank energy storage unit composed of a
super capacitor and an 860 mAh Li-Ion battery stores harvested energy and ensures
continuous operation of the harvester. The stored energy is used to power the harvester
circuitry, control unit, GPS and GSM modules. The tracking unit was tested by attaching
it to the rear axle of the test vehicle. The operation and performance of the overall system
were evaluated using the actual vibration profiles of the test vehicle.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

CHAPTER III
RESEARCH DESIGN AND METHODOLOGY

3.1 Designs and Procedure


3.2 Plan and Circuits

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

3.3 Respondents of the Study


The qualified respondents for this study are various drivers from different parts of
Quezon City. These drivers were selected as respondents regardless of age, socioeconomic status, religious affiliation, gender, educational attainment, occupation and
marital status. As long as they drive vehicles, they are fitted as target group. The
respondents are classified as drivers of two-wheel, three-wheel, and four-wheel vehicles.
They are the ones who are the well-informed enough to answer the problems posed in the
present study. They answered the questionnaire that the researchers gave them which
supplies the necessary information this study requires.
3.4 Research Instruments
In order for us to get all the data we need, we have conducted a survey. This
survey is a convenient way to gather their insights about a vehicle tracking and security
device. The instrument we use for us to get information is a survey questionnaire. We
produce a set of printed or written questions with a choice of answers for our
respondents. The survey questionnaire is prepared in Filipino in order for the respondents
to express their discernments better. The survey questionnaire used in the study is below:
SURVEY FOR VEHICLE TRACKING AND SECURITY DEVICE
1. Ano ang opinyon mo sa isang vehicle security device na hindi lang nagta-track ng
location ng iyong sasakyan, kundi kumukuha rin ng litrato ng isang potential na
vehicle thief gamit ang dashboard camera at isesend sayo gamit ang Internet?

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

(What is your opinion about a vehicle security device which not only tracks your
vehicle, but also captures photo of a potential vehicle thief via dashboard camera
and will send you the photo through the Internet?)
a) Maganda ito at nakatutulong ng malaki sa pangangalaga ng seguridad ng
sasakyan. (This is good and very helpful in keeping the vehicle security
tight.)
b) Maganda ito subalit may mga pag-aalinlangan ako ukol dito gaya ng (This
is

good

but

have

reservations

like)

_______________________________
___________________________________________________________.
c) Hindi,
sapagkat
(No,
because)
___________________________________.
d) Iba pang sagot (Other answers): ____________________________.
2. Sa iyong palagay, gaano ito makakatulong sa pagkontrol ng dumaraming kaso ng
pagnanakaw ng sasakyan? (In your opinion, how is this going to help the issue of
vehicle theft growth rate?)
a) Lubos itong makatutulong. (This is very helpful.)
b) Makatutulong ng bahagya. (This is going to help marginally.)
c) Hindi makatutulong at hindi rin makasasama. (This is not going to help
and is not going to be harmful either.)

3. Bilang isang may-ari ng sasakyan, ikaw ba ay naniniwalang personal na


makatutulong sa iyo ang device na ito? (Being an owner of a vehicle, do you
personally believe that this device is going to be helpful to you?)

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

a) Oo, sapagkat lubos nitong maagapan ang pagnanakaw ng sasakyan. (Yes,


because this going to prevent vehicle thievery to a great extent).
b) Oo, sapagkat dinaragdagan nito ang partisipasyon ng may-ari sa seguridad
ng sasakyan. (Yes, because this increases the involvement of the owner
with their vehicles security program).
c) Hindi,
sapagkat

(No,

because)

___________________________________.
4. Maliban sa pagta-track ng location at pagkuha ng litrato gamit ang dashboard
camera, mayroon ka bang nais na maidagdag na feature dito? Kung meron anuano ang mga ito? (Aside from tracking location and capturing a photo via
dashboard camera, do you have anything to add up on it? If yes, what are those?)
__________________________________________________________________
_________________________________________________________________.
5. Sa iyong palagay, anu-ano ang mga advantages at disadvantages ng device na it?
(In your view, what are the advantages and disadvantages of this device?)
__________________________________________________________________
_________________________________________________________________.

3.5 Statistical Treatment of Data

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

REFERENCES/ LITERATURE CITED


Federal Bureau of Investigation (2012). Uniform Crime Report: Crime in the United
States,

2012.

Retrieved

from

https://www.fbi.gov/about-us/cjis/ucr/crime-in-the-

u.s/2012/crime-in-the-u.s.-2012/property-crime/motor-vehicle-theft
United Nations Office on Drugs and Crime (2013). Retrieved from www.unodc.org
The Philippine Star (2015. Philippine crime rate up by 46%. Retrieved from
http://www.philstar.com/metro/2015/08/03/1483869/philippine-crime-rate-46
Philippine Daily Inquirer (2011). 8 out of 10 car thefts in Philippines occur in Metro
Manila. Retrieved

from

http://newsinfo.inquirer.net/40089/8-out-of-10-car-thefts-in-

philippines-occur-in-metro-manila
National Statistics Office (2011). The Philippines in Figures 2011. Retrieved from
https://psa.gov.ph/sites/default/files/2011%20PIF_final.pdf
Manila Bulletin (2015). Top 5 Metro Manila cities your car is most likely to get stolen in
Retrieved

from

http://www.mb.com.ph/top-5-metro-manila-cities-your-car-is-most-

likely-to-get-stolen-in/
Ramani, R. et al (2013). Vehicle Tracking and Locking System Based on GSM and GPS.
Retrieved from http://www.mecs-press.org/
Chen, H., Chiang, Y. Chang, F., H. Wang, H. (2010). Toward Real-Time Precise Point
Positioning: Differential GPS Based on IGS Ultra Rapid Product, SICE Annual
Conference, The Grand Hotel, Taipei, Taiwan, August 18-21, 2010
M. S. Joshi and D. V. Mahajan (2014). Arm 7 based theft control, accident detection and
vehicle positioning system, International Journal of Innovative Technology and Exploring
Engineering, vol. 4, no. 2, pp. 29-31.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

M. A. A. Khedher, (2011). Hybrid GPS-GSM localization of automobile tracking system,


International Journal of Computer Science and Information Technology, vol. 3, no. 6, pp.
75-85.
S. S. Pethakar, N. Srivastava, and S. D. Suryawanshi (2012). RFID, GPS and GSM based
vehicle tracing and employee security system, International Journal of Advanced
Research in Computer Science and Electronics Engineering, vol. 1, no. 10, pp. 91-96.
P. P. Wankhade and S. O. Dahad (2011). Real time vehicle locking and tracking system
using GSM and GPS technology-an anti-theft system, International Journal of
Technology and Engineering System, vol. 2, no. 3, pp. 272-275.
J. R. Shaikh and S. M. Kate (2012). Arm7 based smart car security system, International
Journal of Engineering Trends and Technology, vol. 3, no. 2, pp. 210-212.
J. M. Hu, J. Li, and G. H. Li, (2012). Automobile anti-theft system based on GSM and
GPS module, presented at the Fifth International Conference on Intelligent Networks and
Intelligent Systems, Tianjin, China.
N. Kaushik, M. Veralkar, P. Parab, and K. Nadkarny (2014). Anti-Theft vehicle security
system, International Journal for Scientific Research and Development, vol. 1, no. 12, pp.
2845-2848.
V. M. Ibrahim and A. A. Victor. (2012). Microcontroller based anti-theft security system
using GSM networks with text message as feedback, International Journal of Engineering
Research and Development, vol. 2, no. 10, pp. 18-22.
B. G. Nagaraja, R. Rayappa, M. Mahesh, C. M. Patil, and T. C. Manjunath (2009).
Design and development of a GSM based vehicle theft control system, presented at the
International Conference on Advanced Computer Control, Singapore.
M. A. A. Rashed, O. A. Oumar, and D. Singh. (2014) A real time GSM/GPS based
tracking system based on GSM mobile phone, IEEE Journal on Signals and
Telecommunication, vol. 3, no. 1, pp. 65-68.

QUEZON CITY POLYTECHNIC UNIVERSITY


673 Quirino Highway, San Bartolome, Novaliches, Quezon City
College of Engineering
Electronics Engineering Department

Tolentino, I. M. and Talampas, M. R. (2012) Design, development, and evaluation of a


self-powered GPS tracking system for vehicle security, University of the Philippines,
Diliman. Retrieved from http://ieeexplore.ieee.org/

Das könnte Ihnen auch gefallen