Sie sind auf Seite 1von 3

RULES OF

TECHNICAL DRAWING

: Sept 7th 2013


:: LS-TI-MT-6/R3

REVISION DATE
EXPIRED DATE
DOCUMENT CODE

THE GENERAL RULES ON TECHNICAL DRAWING PRACTICUM


Prior to and during the practicum sessions, student needs to understand the following rules:
1.

Rules and Regulation


a.

Plagiarism Definition:
The Act of using a part or a whole of someone elses work without his/her
permission or without giving any credits to the original work or author.
Plagiarism Penalty: FAILED (E)
APPLICABLE

TO

BOTH,

THE

MAIN

AND

SUPPORTING

STUDENTS.

b.

Practicum comprises 13 sessions @ 100 minutes. Group member composition,


rules, grade distribution and practicums final project will be socialized during
the first session only.

c.

Any students lateness exceeding 5 minutes, according to the laboratorys time,


is considered absent. Furthermore, student is not allowed to participate in the
practicum exams (trial test and presentation), if he/she has more than two
absences.

d.

Student is obliged to bring the Technical Drawing module and the required
equipment.

e.

Practicum sessions 3, 5, 7, and 9 will begin with a quiz.

f.

Only student wearing white laboratory coat and bring Technical Drawing
module is allowed to attend the practicum.

g.

Student is not allowed to bring into practicum room other than the following
items: Technical Drawing module, writing note, practicum equipment, and
writing tools.

h.

No eating, drinking or smoking inside the laboratory.

i.

A switched off mobile phone is allowable in the practicum room. Any


misconduct will be penalized as absent.

j.

Student is responsible for any damage or loss during the usage of practicum
equipment.

Integrated Industrial Engineering Laboratory


Faculty of Engineering
BINUS University

Version : 6

Revision : 4

RULES OF
TECHNICAL DRAWING

k.

REVISION DATE
EXPIRED DATE
DOCUMENT CODE

: Sept 7th 2013


:: LS-TI-MT-6/R3

Student is required to read, sign, and submit the laboratory code of conduct
during the first practicum session.

2.

Practicum Report
a.

Task and Quiz


a) Hardcopy of the report shall be submitted in the beginning of each session. The
status of No report submission is applied, for report submitted five minutes after
the deadline.
b) Answer only in the quiz answer sheet. Failure to follow any instruction will result
in ZERO SCORE.

3.

Grade Distribution
Assessment

Weight (%)

Assignment, Quiz and Final Project

40

UTP

30

UAP

30

Integrated Industrial Engineering Laboratory


Faculty of Engineering
BINUS University

Version : 6

ii

Revision : 4

RULES OF
TECHNICAL DRAWING

REVISION DATE
EXPIRED DATE
DOCUMENT CODE

: Sept 7th 2013


:: LS-TI-MT-6/R3

Prepared by,

Zefaniyah

Bernardus Bandriyana, Ir., M.Si

Technical Drawing Laboratory Coordinator

Cognizant Faculty

Checked by,

Rida Zuraida, ST., M.T

Ketut Gita Ayu, MSIE

Head of Integrated
Industrial Engineering Laboratory

Head of Industrial Engineering Department

Integrated Industrial Engineering Laboratory


Faculty of Engineering
BINUS University

Version : 6

iii

Revision : 4

Das könnte Ihnen auch gefallen