Beruflich Dokumente
Kultur Dokumente
TECHNOTSAV-2K15
CIRCUITRIX
ROUND -1 QUESTION PAPER
SET-Y
1. Which of the following equipment can check the condition of a transistor?
A
Current tracer
Ohmmeter (VOM)
2. In the active region, while the collector-base junction is ________-biased, the base-emitter is ________-biased.
A.
forward, forward
B.
forward, reverse
C.
reverse, forward
D.
reverse, reverse
3. What does a high resistance reading in both forward- and reverse-bias directions indicate?
A.
A good diode
B.
An open diode.
C.
A shorted diode
D.
A defective ohmmeter
4. Find the equivalent resistance, REQ for the following resistor combination circuit.
A. 10 Ohms
DEPT. OF ECE
B. 15 Ohms
C. 11 Ohms
D. 12 Ohms
TECHNOTSAV-2K15
CIRCUITRIX
SET-Y
5.
A.
455 Hz.
B.
455 kHz.
C.
4.55 MHz.
D.
6. The ________ has a physical channel between the drain and source.
A.
D-MOSFET.
C.
V-MOSFET
E-MOSFET
A.
0V
B.
2 V.
C.
4V
D.
2 V
8. Refer to this figure. If the value of R1 decreases, the voltage gain will ________ and the input impedance will
________.
A.
increase, increase
B.
Increase, decrease.
C.
decrease, decrease
D.
decrease, increase
B.
C.
D.
10 Ideally, for linear operation, a transistor should be biased so that the Q-point is
A.
near saturation.
DEPT. OF ECE
TECHNOTSAV-2K15
CIRCUITRIX
SET-Y
B.
near cutoff.
C.
where IC is maximum.
1. 12.
2
A.
reverse-biased
B.
Forward-biased.
C.
avalanched
D.
Saturated
A. Ground
c. Cathode
D. Anode
13.
A silicon diode is forward-biased. You measure the voltage to ground from the anode at ________, and the
voltage from the cathode to ground at ________.
A.
0 V, 0.3 V
B.
2.3 V, 1.6 V
C.
1.6 V, 2.3 V
D.
0.3 V, 0 V
A.
VZ
B.
IZM.
C.
IZ
D.
15. Each diode in a center-tapped full-wave rectifier is ________ -biased and conducts for ________ of the
input cycle.
A.
forward, 90
B.
reverse, 180
forward, 180
D.
reverse, 90
DEPT. OF ECE
TECHNOTSAV-2K15
CIRCUITRIX