Beruflich Dokumente
Kultur Dokumente
TECHNOTSAV-2K15
CIRCUITRIX
ROUND -1 QUESTION PAPER
SET-Z
1. Which of the following equipment can check the condition of a transistor?
A
Current tracer
Ohmmeter (VOM)
2. In the active region, while the collector-base junction is ________-biased, the base-emitter is ________-biased.
A.
forward, forward
B.
forward, reverse
C.
reverse, forward
D.
reverse, reverse
3. What does a high resistance reading in both forward- and reverse-bias directions indicate?
A.
A good diode
B.
An open diode.
C.
A shorted diode
D.
A defective ohmmeter
4. Find the equivalent resistance, REQ for the following resistor combination circuit.
A. 10 Ohms
DEPT. OF ECE
B. 15 Ohms
C. 11 Ohms
D. 12 Ohms
TECHNOTSAV-2K15
CIRCUITRIX
SET-Z
5.
A.
455 Hz.
B.
455 kHz.
C.
4.55 MHz.
D.
6. The ________ has a physical channel between the drain and source.
A.
D-MOSFET.
C.
V-MOSFET
E-MOSFET
A.
0V
B.
2 V.
C.
4V
D.
2 V
reverse-biased
B.
Forward-biased.
C.
avalanched
D.
Saturated
1.9. The wide end arrow on a schematic indicates the ________ of a diode.
2
A. Ground
c. Cathode
D. Anode
10.
A silicon diode is forward-biased. You measure the voltage to ground from the anode at ________, and the
voltage from the cathode to ground at ________.
A.
0 V, 0.3 V
B.
2.3 V, 1.6 V
C.
1.6 V, 2.3 V
D.
0.3 V, 0 V
DEPT. OF ECE
TECHNOTSAV-2K15
CIRCUITRIX
SET-Z
A.
VZ
B.
IZM.
C.
IZ
D.
12. Each diode in a center-tapped full-wave rectifier is ________ -biased and conducts for ________ of the
input cycle.
A.
forward, 90
B.
reverse, 180
forward, 180
D.
reverse, 90
13. Refer to this figure. If the value of R1 decreases, the voltage gain will ________ and the input impedance will
________.
A.
increase, increase
B.
Increase, decrease.
C.
decrease, decrease
D.
decrease, increase
B.
C.
D.
15 Ideally, for linear operation, a transistor should be biased so that the Q-point is
A.
near saturation.
B.
near cutoff.
C.
where IC is maximum.
DEPT. OF ECE
TECHNOTSAV-2K15
CIRCUITRIX