Beruflich Dokumente
Kultur Dokumente
(The Variator)
The co-efficient of rolling resistance for a truck weighing 63 500 N is 0.018. The rolling
resistance to the truck is
A
1.143 N
.
B.11.43 N
C.114.3 N
D
1143 N
.
The information provided by the oxygen (O2) sensor to the feedback control system is about the
A
air-fuel ratio
.
B.air temperature
C.air flow speed
D
exhaust gas volume
.
B.0.4
D.1.2
.
B.eliminates the gear shift lever
C.reduces the number of automatic-transmission components
D
reduces shift shock and achieves more efficient transmission of engine torque
.
The air resistance to a car at 20 kmph is R. The air resistance at 40 kmph will be
A
R
.
B.2 R
C.4R
D
4 R2
.
The driveshafts are connected to the differential and wheel hubs through universal joints because
the universal joints
A
absorb the vibrations transferred from the surface of the road
.
Compensate for variations in the relative positions of the differential and the wheels which
B.
result from bumpy road surfaces or other similar driving conditions.
C.absorb any difference in speed between the left and right wheels when the vehicle is turning
D
none of the above
.
Two advantages of using helical gears rather than spur gears in a transmission system are
A
strength and cost
.
B.strength and less end thrust
C.noise level and strength
D
noise level and economy
.
D
60 mm
.
B.10
D.40
A
1.6694 N
.
B.16.694 N
C.166.94 N
D
1669.4 N
.
B.2
D.4
Which one of the following statement correctly describes the construction of a bevel-gear type
differential?
A
The drive shafts are splined to the differential carrier.
.
B.The left side gear and the differential carrier rotate in constant unison.
The differential carrier houses differential pinion gears and side gears, each pinion gear
C.
meshes with a different side gear.
D
The differential carrier houses differential pinion gears and side gears
.
What drive line will STOP quickest on a slippery surface?
A. All Wheel Drive.
B. Rear Wheel Drive.
C. Both A and B will stop equally well.
In a gear box the clutch shaft pinion has 14 teeth and lower main shaft pinion 32 teeth. The
corresponding lay shaft pinions have 36 teeth and 18 teeth. The axle ratio is 3.7:1 and effective
radius of the rear type is 35.5 cm. Calculate the car speed in the above arrangement at an
engine speed of 2500 rpm.
Which one of the following can completely balance several masses revolving in
different planes on a shaft?
a A single mass in different planes (b) Two masses in any two planes (c) A single mass
in one of the planes of the revolving masses (d) Two equal masses in any two planes
If the rotating mass of a rim type flywheel is distributed on another rim type flywheel
whose mean radius is half the mean radius of the former, then energy stored in the
latter at the same speed will be
a four times the first one (b) same as the first one (c) one fourth of the first one (d) one
and a half times the first one
11. The pitching of a ship produces forces on the bearings which act __________ to the
motion of the ship
a vertically and parallel (b) vertically and perpendicular (c) horizontally and parallel
(d) horizontally and perpendicular
12. A Hartnell governor is a ----------------- type governor.