Beruflich Dokumente
Kultur Dokumente
Operation Guide
7th Edition: July 2007
897N0425D (010-050-60)
Double Cassette
Triple Cassette
Green mark
Green mark
Front
Front
TOP
Pb
FUJI
35.4 83.7cm
FU
IP
JI
LO
NG
VIE
W
CA
SS
ET
TE
TO
P
.4
35
83
.7 c
m
Rear
Rear
N T
O H
TI C O
U SI D
A R A P
/C O UID T O XH L
N/V C E O SE
O E/ /L R
TI N N PO
N ZIO CIO A/ DVA S
TE N AU R /A TU
AT TE C RVE TIG U
AT RE IG MA
P BSE S O
O R HU
FO
m
.7 c
83
.4
35
FUJ
IP
LO
NG
VIE
CA
SS
ET
TE
M
O
TT
O
Pb
BOTTOM
Pb
FUJI
35.4 83.7cm
N T
O H
TI C O
U SI D
A R A P
/C O UID T O XH L
N/V C E O SE
O E/ /L R
TI N N PO
N ZIO CIO A/ DVA S
TE N AU R /A TU
AT TE C RVE TIG U
AT RE IG MA
P BSE S O
O R HU
FO
/CAUTION
ATTENTION/VORSICHT
ATTENZIONE/CUIDADO
PRECAUCION/LET OP
OBSERVERA/POOXH
FORSIGTIG/ADVARSEL
HUOMAUTUS
/CAUTION
ATTENTION/VORSICHT
ATTENZIONE/CUIDADO
PRECAUCION/LET OP
OBSERVERA/POOXH
FORSIGTIG/ADVARSEL
HUOMAUTUS
When closing the cassette back lid after inserting the IP, ensure
that the IP has been inserted into the cassette correctly, then
press the latches at both corners of the back lid to firmly close it.
Latched corner
Preparing Cassettes/IPs
Coupling bar
1
Slide the button to
the direction marked
with an arrow.
Do not use a compensation filter that controls the X-ray transmittance value.
X-ray Exposure
IP Registration
(Reading the IP barcode)
TOP
BOTTOM
Operation Guide
For the Double Cassette
2 Register the first IP starting from the TOP side on
the rear of the long-view exposure cassette.
When registration of the first IP is completed, three
exposure menus are displayed automatically. Note
that three exposure menus will be displayed even
if the third exposure is not per formed.
3 Perform registration of the second and third IPs.
The second IP is registered by automatically reversing the first IP up-side-down.
Image Reading/
Stitching
Start to insert the cassette that covers the thickest body part.
Film Printout/Transfer
of Stitched Images
One image on
26
36cm film
21%
Two images on
36cm film
26
40%
27%
50%
34%
25%*
67%
45%
33%*
* Image reduction ratios applicable when output formats are specified from an
external WS, such as HI-C 655, etc.
Use the procedure below to register IPs from the green mark side.
For the Double Cassette: IP at the TOP and then IP at the BOTTOM
For the Triple Cassette : After it has been divided into two cassettes,
(1) IP at the TOP of the Single Cassette,
(2) IP at the TOP of the Double Cassette and
(3) IP at the BOTTOM of the Double Cassette
Insert first the cassette from the TOP into the same Image Reader
for exposure of the whole lower extremities, and from the
BOTTOM for exposure of the whole spine.
Image Restitching
Processing
Image Output
Cassette Storage
To output stitched images, follow the standard operation procedure that can be used on the Console.
For operations on the Console, see the Console
Operation Manual.
Holder
Long-view cassette