Beruflich Dokumente
Kultur Dokumente
UTILITY UNIT
WORK PERMITS QUESTIONS
(1)- The issuer must stop work if ------------a) The issuer leaves the job site.
b) More men are working than stated on the permit.
(c)The job site was found to be unsafe.
d) The issuer looses his copy of the permit.
_________________________________________________________________
_
(2)-a pipe fitter can not work on the same pieces of equipment using welders
permit because.
a) Welders are usually contractors.
b) Gas tests are not needed for pipefitters.
c) Each type of work involves different hazards.
d) Joint site inspections are not needed for pipefitters.
_________________________________________________________________
_
(3)-if a work permit is not issued during an emergency, what must be done to do
the work?
a) Superintendent must approve.
b) All safety precautions must be taken.
c) Wear Scott air Pak.
d) Joint site inspection.
(4)-The receiver must stop work if_____________.
a) He can not find the issuer.
b) The work site becomes un safe.
c) The issuer leaves the job site (d) the designated representative must leave
(18)- What are the basic precautions for cold work? Select all items that apply.
a) Gas test.
b) PPE.
c) Special work precautions.
d) Standby man.
e) Fire watch.
f) Barricade and warning signs.
_________________________________________________________________
(19)-What is oxygen deficiency?
a) A lower than normal amount of oxygen.
b) Higher than normal amount of oxygen.
c) Less than 23.5% oxygen.
d) Oxygen that above its flash point.
(20) What are the basic precautions for hot work permit? Select all items that
apply?
a) Blind, isolate, clean, and purge equipment.
b) Fire watch.
c) Fire protection equipment.
d) Cover sewer drains.
e) Gas test.
_________________________________________________________________
_
(21)- What is the acceptable level of LEL to allow hot work?
a) 10 to 100 PPM.
b) 0.0 PPM.
c) 5% to 50%.
d) 21% 23.5%.
_________________________________________________________________
_
(22)- select the statement where all THREE items are needed before allowing
entry into a confined space?
a) Air mover, respirators, and countersignatures.
b) Fire watch, air mover, gas test.
c) Gas test, fire extinguisher, barricades.
d) Lighting, standby man, air mover.
(23)-the receiver can leave the job site any time as long as he gets the
Permeation from his supervisor.
a) True.
b) False
(24)- Who should keep the work permit?
a) The standby man.
b) The issuer.
c) The receiver.
d) The fire watch.
(25)- What should be a assigned when working near combustible materials?
a) Standby man.
b) Fire watch.
c) Fire men.
d) Flag man.
(26)- What training should a fire watch have?
a) Safety devices.
b) Equipment condition.
c) Gas test.
d) Attendance report.
(32)- Who decides whether an area should be restricted or not?
a) The department manager.
b) The superintendent.
c) The issuer.
d) The receiver.
__________________________________________________________________
(33) - what type of work does the work permit system authorize?
a) Specific construction, maintenance, or repair work.
b) All work constructed for Saudi Aramco.
c) All work done by maintenance or contractors.
d) Non- hazardous work where safety is important.
(34)- Who is a work permit receiver?
a) A qualified Saudi Aramco employee.
b) A person certified to receive permits.
c) A person nominated by his supervisor.
d) A maintenance or contract worker.
(35)- The safety of work site is a sole responsibility of an issuer?
a) True.
b) False.
(36)- What responsibility do issuers and receivers share when signing a work
permit?
d) Operations