Beruflich Dokumente
Kultur Dokumente
ELECTRONIC SCIENCE
Signature and Name of Invigilator
1. (Signature) __________________________
(Name) ____________________________
Roll No.
2. (Signature) __________________________
(Name) ____________________________
88
Roll No.________________________________
(In words)
1 6
1.
2. -
3. , -
-
, :
(i) -
-
(ii) -
/
-
-
(iii) - OMR
OMR -
4. (1), (2), (3) (4)
:
:
(3)
5. OMR
OMR
,
6.
7. (Rough Work)
8. OMR ,
,
, ,
,
9. OMR
-
OMR
10. C.B.S.E.
11. ()
12.
J-88-16
P.T.O.
ELECTRONIC SCIENCE
Paper II
Note : This paper contains fifty (50) objective type questions of two (2) marks each. All
questions are compulsory.
1.
(1)
(3)
2.
2.55 A
2.66 A
(2)
(4)
The threshold voltage of CMOS inverter (Vth = Vin = Vout) can be expressed as
Vton +
(1)
1
kR (VDD + Vtop)
1+
Vtop +
(3)
1
kR
1
kR (VDD + Vton)
1
3.
5.4 A
3.6 A
1
kR
Vton
(2)
1
kR (VDD + Vton)
1
kR
1
Vtop
(4)
1+
1
kR (VDD + Vtop)
1
kR (Vton)
(2)
(4)
2
lim SR(S)
1 + G(S)
R(S)
lim
s 0 1 SG(S)
s0
J-88-16
4.
5.
(3)
6.
( + 1)
RB
( + 1) + R
E
RB
1+R
(4)
( + 1)
RE
( + 1) + R
(1)
(3)
J K flip flop
T flip flop
(2)
(4)
R S flip flop
D flip flop
7.
8086 is interfaced to two 8259s (programmable interval timer). If 8259s are in master
slave configuration, the number of interrupts available to the 8086 microprocessor is
(1) 8
(2) 16
(3) 32
(4) 64
8.
9.
TRAPATT is used as
(1) amplifier in radars
(2) local oscillator in radars
(3) switch in communication systems
(4) low frequency oscillator
J-88-16
Paper-II
10.
11.
(2)
(4)
Clipper
Low frequency oscillator
(1)
(2)
(3)
(4)
8
1
1
8
1
1
8
1
1
8
1
1
12.
Which of the following cannot be the Fourier series expansion of a periodic signal ?
(1) x(t) = 2 cos t + 3 cos 3t
(2) x(t) = 2 cos t + 7 cos t
(3) x(t) = cos t + 0.5
(4) x(t) = 2 cos 1.5 t + sin 3.5 t
13.
14.
(3) RC dt = RC dt eo(t)
(4)
dt = RC
dt
Paper-II
J-88-16
15.
x 1
=
x2
1
1
0 x1 1
+ u(t)
1 x2 1
1
where u(t) is a unit step input occurring at t = 0 and x(0) = .
0
The time response of the system is
16.
(1)
2et + 1
2t et
(3)
2et + 1
2t et
(2)
2et 1
2t et
(4)
et + 1
2 et
(b)
L
tA
(c)
R
t
(d)
RW
L
17.
(1)
(2)
(3)
(4)
(i)
(ii)
(iii)
(a)
(b)
(c)
(d)
(2)
(3)
(4)
J-88-16
Paper-II
18.
V)
(b)
o
q NA ND
q NA + ND (o V)
(c)
2si NA ND
q NA + ND (V o)
(d)
(2)
(4)
2si NA ND
q NA ND V
(b) is correct and (c) is wrong
(d) is correct and (a) is wrong
19.
For the counter to count upwards starting from 0000 to 1111, following statement are
given :
20.
Assume that the 8255 gets selected whenever A15 A11 are high during I/O read or write
cycles. The A2 and A1 are connected to A1 and A0 of 8255 chip, then the address for
port C of 8255 is
(a) FEh
(b) 03h
(c) FF03h
(d) FFh
Codes :
(1) (a) and (b) are correct
(2) (c) and (d) are correct
(3) (a) and (d) are correct
(4) (b) and (d) are correct
21.
Paper-II
xyz (h, h) ;
xyz (g, g);
(b) and (d) are correct
(b) and (c) are correct
J-88-16
22.
23.
24.
25.
J-88-16
Paper-II
26.
List II
Vgs2
Idss 1 V
p
i.
b.
JFET
c.
PN Junction diode
d.
BJT
Codes :
a
(1) ii
(2) i
(3) iii
(4) i
27.
28.
b
i
iii
ii
ii
c
iii
ii
iv
iv
W
ii. K L (Vgs Vth)Vds
qV
iii. Io e kT 1
IC
iv. = I
B
d
iv
iv
i
iii
Paper-II
List II
i. Electrical activity of brain
ii. Eye movements
iii. Electrical activity of skeletal muscles
iv. Muscle activity in the gastro intestinal
i.
ii
iii.
iv.
List II
3.3 eV
1.12 eV
0.7 eV
1.43 eV
J-88-16
29.
30.
31.
J-88-16
List II
i. Heterogeneous
ii. Homogeneous
iii. Structure
iv. Qualifier
Paper-II
32.
List II
i.
ii.
c. Propagation coefficient
d. Characteristic impedance
Codes :
a
b
c
d
(1) i
iv
ii
iii
(2) iv
i
iii
ii
(3) iii
i
ii
iv
(4) i
iii
iv
ii
33.
34.
i.
ii.
iii.
iv.
1
(R + j L)
(G + j C)
iii. (R + j L) (G + j C)
iv. 1
List II
(Typical Application)
FM Broadcasting, TV
Satellite communication
AM Broadcasting
Optical communication
Paper-II
10
J-88-16
35.
i.
b.
ii
c.
iii.
d.
Codes :
a
(1) ii
(2) i
(3) ii
(4) i
List II
iv.
b
i
iv
i
iii
c
iv
iii
iii
iv
d
iii
ii
iv
ii
Assertion (A) :
Reason (R)
J-88-16
MOSFET can be used to drive high current and high voltage networks
without drawing current or power from the driving circuits.
The high input impedances of FET essentially isolates the two parts of
the network without the need of optical or electromagnetic linkages.
11
Paper-II
37.
Assertion (A) :
Reason (R)
Two circuits are said to be dual when the mesh equations that describe
38.
Assertion (A) :
Reason (R)
39.
Assertion (A) :
Reason (R)
40.
Assertion (A) :
Reason (R)
Paper-II
12
J-88-16
41.
Assertion (A) :
Reason (R)
42.
Assertion (A) :
Reason (R)
43.
Assertion (A) :
Reason (R)
44.
Assertion (A) :
In Lasers, the photons emitted has the same energy as the incident
photon and are in phase with it.
Reason (R)
45.
Assertion (A) :
Reason (R)
The poles or the roots of the characteristic equation should not lie in
the right half of s-plane for system stability.
J-88-16
13
Paper-II
Read the passage and answer the following questions numbering from 46 50 :
The physics of semiconductor devices is dependent on the physics of semiconductors itself. The
most important semiconductors are Germanium, Silicon and Gallium Arsenide. The GaAs has
different properties than Silicon or Germanium. Pure silicon is intrinsic and contains negligibly
small amount of impurities. Each silicon atom shares its four valance electrons with the four
neighbouring atoms forming covalent bonds. An extrinsic silicon is achieved by introducing the
impurities. The band structure of a solid can be obtained by solving a Schrodinger equation of
an approximate one electron problem.
46.
47.
(1)
n + p = ni
(2)
n p = ni
(3)
n p = ni
(4)
n 2 p = ni
(2)
(3)
(4)
Paper-II
1
E EF
1 exp kT
1
E EF
1 + exp kT
E
E EF
1 + exp kT
E
E EF
1 exp kT
14
J-88-16
48.
49.
(2)
(3)
(4)
(2)
50.
1
+
ND = ND 1
ED EF
1
1 + g exp kT
1
+
ND = ND 1 +
E
E
D
1
F
1 + g exp kT
(3)
ED EF
1
+
ND = ND 1 + g exp kT
(4)
EF ED
1
+
ND = ND 1 + g exp kT
(1)
.N(E) F(E) dE
.
0
Etop
(2)
.N(E) F(E) dE
.
EC
EC
(3)
.N(E) F(E) dE
.
EV
EV
(4)
.N(E) F(E) dE
.
EC
_____________
J-88-16
15
Paper-II
Paper-II
16
J-88-16