Beruflich Dokumente
Kultur Dokumente
c. Equalization
d. Amplification
210. Signal contamination by extraneous or external
sources, such as, other transmitters, power lines,
and machinery.
a. Noise
b. Distortion
c. Harmonics
d. Interference
211. Man-made or industrial noise is also known as
a. Noise
b. Distortion
c. Interference
d. Thermal Noise
212. The noise performance of a receiver or circuit.
It is expressed as ratio of the S/N power at the
output.
a. Noise figure
b. S/N ratio
c. Signal figure
d. Figure of merit
213. Noise that is caused by natural disturbances
such as lightning discharge.
a. Static noise
b. Space noise
c. Atmospheric noise
d. A or C
214. Atmospheric or static noise becomes less
severe at frequencies
a. Below 30 KHz
b. Between 30 KHz and 300 KHz
c. Between 300 KHz and 30 MHz
d. Above 30 MHz
215. Considered as space noise or extraterrestrial
noise
a. Solar noise
b. Cosmic noise
c. Black-body noise
d. All of the above
216. Which statement is true
a. Industrial noise is usually of impulse type
b. Distant stars produce atmospheric noise
c. Active switches are sources of man-made
noise
d. Static noise is due to lightning discharges
and other natural electric disturbances
occurring in the atmosphere.
217. Noise performance of microwave system is
usually expressed in terms of
a. Noise voltage, Vn = 4KTBR
b. Noise power, Pn = KTB
a. line resistance
b. line inductance
c. line capacitance
d. all of the above
226. There are a number of different sources of
radio noise, the most important being
a. Galactic noise
b. Man-made noise
c. Atmospheric noise
d. All of the above
227. The amount of noise power is measured using
a psophometric weighting network. This unit of
measurement is generally used in Europe where the
standard reference tone is 800 hertz, 1 picowatt.
a. dBa
b. dBm
c. dBaO
d. pWp
228. Noise produced mostly by lightning discharges
in thunderstorms.
a. White noise
b. Industrial noise
c. Atmospheric noise
d. Extraterrestrial noise
229. Propagation of man made noise is chiefly by
a. Transmission over power lines and by
ground wave
b. Space wave
c. Sky wave
d. None of these
230. A more precise evaluation of the quality of a
receiver as far as noise is concerned
a. S/N
b. VSWR
c. Noise factor
d. Noise margin
231. NIF stands for
a. Non-intrinsic figure
b. Noise interference figure
c. Noise improvement factor
d. Narrow intermediate frequency
232. External noise fields are measured in terms of
a. Dc values
b. Rms values
c. Peak values
d. Average values
233. Form of interference caused by rain, hail, snow
or dust storms
a. Shot noise
b. Galactic noise
c. Impulse noise
d. Precipitation static
c. Noise suppression
d. Noise degradation
250. Noise generated within electronic equipment
by either passive or active components.
a. Shot noise
b. Thermal noise
c. Circuit noise
d. External noise
ANSWERS
201. -13 dBm
202. 31.6 W
203. 3.98 dB
204. Reduced by a factor of 10
205. Noise
206. Attenuation
207. Distortion
208. Amplification
209. Equalization
210. Interference
211. Interference
212. Noise figure
213. A or C
214. Above 30 MHz
215. All of the above
216. Distant stars produce atmospheric noise
217. Noise temperature, Te = (F 1)290
218. RF amplifier
219. 1.5 dB
220. dBa
221. dBa0
-14
222. 1.656 x 10 Watts
223. dBmC
224. dBmCo
225. line inductance
226. All of the above
227. pWp
228. Atmospheric noise
229. Transmission over power lines and by ground
wave
230. Noise factor
231. Noise improvement factor
232. Peak values
233. Precipitation static
234. 8 MHz to 1.43 GHz
235. 15 to 160 MHz
236. Transit-time
237. Greater than 1
238. Amplification noise
239. Background noise
240. Ignition noise
241. dBk