Beruflich Dokumente
Kultur Dokumente
D
IIDAS Multi-site Trunking
IIDAS Single-site Trunking
IIDAS Multi-site Conventional
IDAS is Icoms digital land mobile radio system using the NXDN common air interface. IDAS offers a
complete system of handheld radios, mobile radios, repeaters, network interface/trunking controller,
remote communicator, system manager software and various accessories. IDAS is a complete digital
solution that system owners or operators can grow into as their time and budgets allow.
IDAS Trunking
The IDAS system utilizes 6.25kHz narrowband FDMA technology. This system is not only spectrum efficient, but meets
the FCC 2013 deadline for narrow band compliance.
Flexible IP Network
Secure conversation
Trunking
IIDAS single-site
g
trunking
Analog trunking
Conventional
Analog conventional
Analog system
1
r6QUPDIBOOFMTQFSTJUF
r6QUP
*%T
IIDAS conventional
r6QUPTJUFTDBOCFDPOOFDUFE
Digital migration
Individual/group call
Other features
The radio kill function disables a lost or stolen radio over the
air, eliminating security threats from undesired listeners.
When the radio stun command is received, all functions will
be temporary locked out until a revive command is received,
or the user password is entered.
IDAS multi-site conventional
UC-FR5000 #03
(1 unit required
per channel)
BUS
IP Network*
Digital Radios
RS-MGR1
RC-FS10
System Manager
Remote Communicator
IDAS digital
IP Network
Fleet management
The fleet management function allows the system manager to
control a user group in a fleet. Users can be divided in up to
5,000 fleets and the system manager can enable or disable the
use of the system for any fleet.
Fleet management examples
Fleet
(15000)
Alias name
Prefix ID
(130)
Individual ID
(12000)
Group ID
(12000)
Status
Security A
110,31400
120
Enable
Taxi B
1130
2125
Enable
Bus C
130
130
Disable
Truck D
10011005
5153
Enable
The system manager can enable or disable the use of the system for any fleet.
(On the example above, Fleet 3 is disabled.)
ESN authentication
High floors
Call priorities
Repeater
Mid floors
Repeater
Building B
Dispatch
Basement
IP Network*
Repeater
Other features
Load-leveling for trunk-out channels
Restriction control can limit use (TX) from the terminal radios
in case there is too much traffic.
Digital
Radios
Digital
Radios
The IDAS single-site trunking provides an affordable multi-channel digital radio system. Selective
call, group call, status message and short data
message can be used over the trunking system.
Ch2
Ch
Building A
Ch1
Up to 30 repeaters in a system
Ch3
IIP
P Ne
Network*
orrkkk**
Up to 2,000 IDs
The system has the ability to handle up to 2,000
individual ID codes and 2,000 group ID codes
per home channel.
Setting
Digital
Radios
IC-FR5000/FR6000
UC-FR5000 #01
(1 unit required per channel)
Ch2
Ch3
Ch30
BUS
Other features
r6OJU*%BVUIFOUJDBUJPO
r IC-F3101D, IC-F3210D, IC-F3230D, IC-F3261D,
IC-F3161D, IC-F5121D, IC-F5220D and IC-F5061D
series can be used as IDAS trunking radios*
* Single-site trunking only for IC-F3101D and IC-F5121D series transceivers.
r"SFBCJUTFUUJOH
4
IP Network
Digital Radio
Digital Radio
SITE A
SITE C
Repeater
Repeater
IP Network*
Repeater
SITE B
Digital Radio
* The IDAS conventional IP network cannot relay voice traffic over the IP
network if the uplink is analog.
IDAS digital
(Downlink)
Downlink
IP Network
Repeater
(TX Only)
Remote Communicator
Downlink
Repeater
(Rx only)
IP Network*
Uplink
Repeater
(Rx only)
Dispatch
(50W)
IDAS
ID
A F
AS
Features
e a tu
eatu
ea
ure
res
s
136174MHz,
136
617
174M
4M
MHz
Hz, 50
50W
0W
r 13
350400,
350
040
00, 400470,
400
004
470
70,, 45
450512,
450
051
512,
2, 4
450520MHz,
505
50
520
20MH
MHz,
z, 5
50W
0W
r 35
50W
0W output power at 50
50%
% du
duty, 25
25W
W at 1
100%
00%
00
% du
d
duty
ty ccycle
ycle
l
r 50
IDAS
AS
S multi-site
mul
ultititi-s
sitite
e conv
co
conventional
onv
nven
entitition
en
onal
on
all w
with
itith
h op
optional
ptition
on
nal
a U
UC-FR5000
C-FR
CFR50
5000
00 and
nd
r ID
UR-FR5000 series,
Channel Module
UC-FR5000
CF-FR5000MT
IP Network connection
UR-PA5000 series,
Power Amplifier
+ OPC-2202 cable
CF-FR5000MC
Two RF units can be installed in the unit.
(Left side is an option.)
UC-FR5000
CF-FR5000MC
2 channels in 1 box
configuration
CF-FR5000MC
CF-F
CF
FR5
R500
000M
MC
IDAS
AS multi-site/single
mul
ultiti-sit
site/
e/si
sing
ngle
le ssite
itite
e tr
trun
trunking
unki
king
ng w
with
itith
h op
opti
optional
tion
onal
al UC-FR
UC-FR5000
FR50
5000
00
r ID
r IDAS conventional/FM mixed mode operation
r Digital RAN (Radio Access Number) code
r Digital voice scrambler
r Individual and group selective call
r Talk back function and call mode selection
r Status message and SDM (Short Data Message)
r Radio kill, stun and revive (Tx only)
r Call alert and radio check
r Remote monitor (Tx only)
Features
F
Feat
Fe
eat
atur
u es
ur
CF-FR5000MT
RoIP GATEWAY
IDAS
(IDAS conventional
and multi-site trunking)
RC-FS10
Remote
communicator
IP Network*
IP Phone
System
VE-PG3
Analog Phone
Analog
External equipment
CT-24
Features
add
system, siren, warning light and other external
r Public address
equipment can be connected to the VE-PG3
equipmen
virtual serial port function for remote control connected
r The virtua
equipment from a PC over the IP network
radios or e
mo connection
r Bridge mode
r IP router function: PPPoE/IPv6 bridge, NAT, Dynamic DNS,
VPN pass through, IP filter, SNMP and SYSLOG
r USB flash drive connection for firmware updates and data backup
VPN ROUTER
Site B
Site C
Site D
SR-VPN1
xDSL or FTTH
modem
SR-VPN1
xDSL or FTTH
modem
SR-VPN1
VPN Tunnel
SR-VPN1
IDAS
(IDAS conventional
and multi-site trunking)
RC-FS10
Remote
communicator
VE-PG3
IP Phone
System
Analog
Site A
Features
Multi-site trunking
IP Network*
r USB flash drive containing the software and for the hardware
key protection
Multi-site conventional
Multi-site trunking
USB cable
Audio cable
BC-147SA/SE
CT-24
Digital Voice Converter
Supplied with RC-FS10
or
Optional
CT-23
SM-26
HM-152
RC-FS10
Features
call,
group call, selective call, all call, status call, status polling, and so on
r Caller
ID/alias name, called ID/alias name and call type information are
displayed on the ANI area for easy recognition
REMOTE COMMUNICATOR
Traffic
T
ffi L
Log
Features
which
r Optional
IP67
GPS
Multi-site conventional
(5W)
Multi-site trunking
(5W)
(5W)
Single-site trunking
Generall Features
IDAS Features
136174MHz,
4MHz, 5W
r 136174
350400,
0, 400470, 450512, 450520MHz, 5W
r 350400
512
memory
mem
mory
channels and 12
128 zones
r
Dot-matrix,
rix, multi-function disp
display
r Dot-mat
dust-tight
st-tight and waterproo
waterproof protection
r IP67, du
GPS receiver*
r Built-in G
man down function*
r Built-in m
capacity
apacity Lithium-Ion ba
battery pack
r Large ca
r 800mW (typical) loud audio
autodial
r Priority sscan r DTMF autodia
Lone
worker
wo
orker
function
r
r Power ON password
Surveillance
ance function
r Surveilla
accessory
ccessory
ccess
ory connector
connect with B
BTL amplifier output
r 14 pin ac
Voting
oting Scan
S n
r Vo
(* De
Depending
ependiing o
on the transceiver
transc
ve
version)
IP55
IP
Multi-site
Multi-s
site trunking
Single-site
Single-s
site trunking
IC-F4261DS
Multi-site conventional
co
onventional
UHF MOB
MOBILE
BILE TRANSCEIVER
(50W)
Multi-site
e trunking
(45W)
Single-site
e trunking
General Features
IP54
Controller and
RMK-3 only.
IC-F5061D series
The above photo includes the optional RMK-3 separation kit and OPC-609 separation cable.
General Features
Multi-site
Mu
ulti-site conventio
conventional
onal
M
Multi-site
trunking
trunkiing
(5W)
(4W)
Single-site
Si
ingle-site trunking
trunking
IDAS Features
r 136174MHz, 5W
r 350400, 400470, 450512, 450520MHz, 4W
r 128 memory channels and 8 zones
r 8 character alphanumeric display
r IP67, dust-tight and waterproof protection
r Operating time: Approximately 20 hours* with
runking
r IDAS multi-site/single site trunking
r IDAS conventional/multi-sitee conventional
ecode
r PTT ID and ANI r Block decode
r Up to 500 individual and up to 500 group ID aliasess
r Status r SDM (Short Data Message)
(RX)
X)
r Stun/kill/revive (RX) r Call alertrt r Radio check (RX
r Call alert and radio check (RX)
r Remote monitor (RX) r Callll log
er) r Emergency
r RAN (Radio Access Number)
r Digital voice scrambler
r ATB (All Trunks Busy) ring back
Roaming Scan (Multi-site trunking)
runking)
r Roa
* IC-F3230DT/F4230DT
IC-F32
is not available in some countries.
(Not available
av
in the USA.)
IC-F3230DT
VHF HANDHELD
HANDHEL
LD TRANSCEIVER
IP54
Multi-site trunking
(4W)
Single-site trunking
IDAS Features
136174MHz,
36174MHz, 5W
r 13
400470,
00470, 450512
450512, 450520MHz, 4W
r 40
16
6
memory
channe
channels r 3-color LED
r
Operating time: App
Approximately 1617.5 hours* with
rO
BP
P-265 battery pack * Tx: Rx: standby=5:5:90. Power save on.
BP-265
General
Ge
eneral Feature
Features
Channel announce
announcement function
rC
800mW
80
00mW
(typical)
loud
lou speaker audio
r
Internal
nternal VOX capab
capability for hands-free operation
r In
IP54,
P54, dust-protectio
dust-protection and water resistance
r IP
Lone
one worker functi
function r Surveillance function
r Lo
Voting
oting scan r Option
Optional GPS microphone, HM-171GP
r Vo
58(W)
8(W) 111.5(H) 36.5(D) mm compact body
r 58
CTCSS and DTCS built-in (For analog FM)
rC
IC-F3210D
Multi-site
ite
te conventional
conve
IC-F4230DS
General Features
(4W)
(5W)
IC-F4210D
Multi-site trunking
(45W)
General Features
IDAS Features
r 136174MHz, 50W
r 350400, 400470, 450512, 450520MHz, 45W
r 128 memory channels and 8 zones
r 8 character alphanumeric display
r 4W (typical) front mounted speaker
r Lone worker function
r Surveillance function r Voting scan
r GPS receiver connection with optional ACC cable
r Channel announcement function
r Microphone hanger action programmable
r CTCSS and DTCS built-in (For analog FM)
Single-site trunking
Multi-site conventional
VHF MOBILE TRANSCEIVER
IC-F5220D series
10
(5W)
(50W)
(4W)
(45W)
IP54
Multi-site conventional
Single-site trunking
General Features
(IC-F5121D series)
IC-F5121D series
IC-F3161DT/DS
IC-F4161DT/DS
series
IC-F5061D
IC-F6061D
series
IC-F3230DT/DS
IC-F4230DT/DS
series
IC-F3210D
IC-F4210D
series
IC-F5220D
IC-F6220D
series
IC-F3101D
IC-F4101D
series
IC-F5121D
IC-F6121D
series
RC-FS10
PTT ID
TX only
TX only
Individual List
Talkgroup List
Block Decode
Status
TX only *1
TX only *1
Call Alert
RX only
Radio Check
RX only
RX only
RX only
RX only
RX only
Stun/Revive/Kill
RX only
RX only
RX only
RX only
RX only
TX only
Emergency
Remote Monitor
RX only
RX only
RX only
RX only
RX only
TX only
DTMF autodial
*3
*4
GPS
GPS microphone
1
*2
TX only
TX only
RX only
HM-170GP
HM-171GP
HM-171GP
* Power ON/OFF status only. * GPS built-in, depending on the transceiver version. * DTMF dialing is possible with IC-F3230DT/F4230DT.
*4 DTMF dialing is possible with optional DTMF microphone. Tx: Transmit, RX: Receive
Icom, Icom Inc. and the Icom logo are registered trademarks of Icom Incorporated (Japan) in the United States, the United Kingdom, Germany, France, Spain, Russia, Japan and/or other countries.
IDAS, IDAS logo are trademarks of Icom Incorporated. NXDN is a trademark of Icom Incorporated and JVC KENWOOD Corporation. AMBE+2 is a trademark and property of Digital Voice Systems
Inc. Windows is a registered trademark or trademark of Microsoft Corporation in the United States and/or other countries. LTR is a trademark of the E.F. Johnson Technologies, INC.
1-1-32, Kami-minami, Hirano-ku, Osaka 547-0003, Japan
Communication Equipment
Auf der Krautweide 24
65812 Bad Soden am Taunus, Germany
Phone : +49 (6196) 76685-0
Fax
: +49 (6196) 76685-50
E-mail : info@icomeurope.com
URL : http://www.icomeurope.com
www.icom.co.jp/world
Zac de la Plaine,
1 Rue Brindejonc des Moulinais, BP 45804,
31505 Toulouse Cedex 5, France
Phone : +33 (5) 61 36 03 03
Fax
: +33 (5) 61 36 03 00
E-mail : icom@icom-france.com
URL : http://www.icom-france.com
Count on us!
Printed in Japan