HIGH QUALITY PROTECTIVE BLACK BITUMEN PAINT DESCRIPTION Black Bitumen Paint is a general purpose paint suitable for brush application. It complies with BS3416: 1975 Type 1 Class A and Type II. AREAS OF USE Black Bitumen Paint can be applied to most substrates, including iron and steel structures, metal fabrications, castings, asbestos cement sheeting, and structural concrete. ADVANTAGES Simple brush application Rapid drying Can be used with potable water APPLICATION Preparation New surfaces must be cleaned to remove all traces of grease, oil and other foreign matter. All mill scale and any rust that has formed must be removed prior to painting. Where previous paint is firmly adhering and sound, it need not be removed. All loose flaking paint, scale, rust, dirt, grease etc., should be removed so that the surface is completely free from loose matter. On surfaces where all existing rust cannot be removed and where long term protection is required, use a fast drying red lead primer, zinc phosphate or other rust inhibitive primer in accordance with the manufacturers instructions, and ensure this is dry before proceeding with the treatment. On clean, rust free surfaces where priming is required, apply one coat of Bitumen Primer by brush and allow to dry, under normal ambient conditions, for 20 - 40 minutes. Black Bitumen Paint can also be sprayed or dipped; for dipping it can be thinned if necessary using white spirit. Placement: A minimum of two coats is recommended to eliminate pin-holes and inadequate coverage of high spots. Apply second coat after the first has dried. N.B. For best results on cold water storage tanks, three coats are recommended.
Black Bitumen Paint should be allowed to
cure at ambient temperatures for a period of at least seven days prior to contact with potable water. N.B. Black Bitumen Paint is NOT suitable for use in fish ponds. Cleaning Tools and spillage may be cleaned using white spirit or paraffin COVERAGE The generally recommended coverage rate is : Steel 11m/L per coat Concrete (dependent on porosity) 5m/L per coat. TECHNICAL DATA Specific Gravity at 15C 0.91 - 0.93 Viscosity (B4) cup at 20C 235-245 secs Approx. Solids content W/W 59-61% Drying time at 15C 2 - 4 hours Flash Point (abel closed cup) Min 32C Film thickness per coat applied at 11m/L Wet 0.1mm Dry 0.05mm PACKAGING Black Bitumen Paint is available in 5 and 25 litre containers. STORAGE Black Bitumen Paint contains a flammable solvent and all precautions against fire must be taken during both storage and use. Store in cool conditions. Keep away from sources of ignition. No Smoking. Refer to Health and Safety data sheet available upon request. Shelf Life Two years when stored in unopened containers according to the manufacturers instructions.
Building Chemical Research Ltd. Sion Street, Radcliffe, Manchester, M26 3SJ, England. Tel:0161 723 2237 Fax: 0161 724 7699 E-mail sales@buildchem.co.uk