Beruflich Dokumente
Kultur Dokumente
D 51021
(Pages : 3)
Name ....................................... .
Reg. No .................................... .
Maximum : 70 Marks
1 Draw (a) sectional view from the front and (b) view from the side of a hydraulic pipe joint of
flanged type, to connect two pipes, each of diameter 50 mm.
Or
2 Sketch the necessary view of a step cone pulley with four steps, operating with flat belts.
Assume that the pulleys are to be mounted on shafts of diameter 50 mm.
(15 marks)
II.
3 By means of neat sketches and explanatory notes, interpret the meaning of the geometrical
tolerances shown in Figure.
(a)
(b)
Or
4 Draw (a) view from the front and (b) sectional view from the side of a plummer block with
double row self-aligning ball bearing, suitable for supporting a shaft of diameter 30 mm.
(20 marks)
Turn over
D 51021
2
III.
5. Figure shows that details of a lathe tail-stock. Assemble the parts and draw to a suitable scale,
(a) sectional view from the front and (ii) view from the left.
M13
Pltr.
Hili
........
'
,...
' .,.......
..
,..,
t
8Gdr
2 BINI
...
1:20
s
7
18
c.
SIH& ...
11811
att
Cl
1
1
t
1
t
us
us
cs
a
Cl
us
us
,'
1
II I
us
D 51021
6. The part drawings of a blow-off cock are shown in Figure. Assemble the parts and draw,
(a) sectional view from the front and (ii) view from above.
&No.
Mimi
1
2
3
8otl
"
Stul
Codl
Qnl
MI1L Qlr.
cs 1
GM 1
cs 1
us
Fig. Blow-off-cock
(35 marks)