Beruflich Dokumente
Kultur Dokumente
KC SERIES
USER MANUAL
MODEL : KC25
KC50
KC100
KC150
Laney
THANK YOU
We at Laney are extremely pleased that you have decided to select a KC series product for
your sound requirements and we wish to reinforce your judgement by ensuring you get off
to a flying start by including this comprehensive user manual to assist you in getting to
know your equipment.
Before switching on please read this manual carefully since whilst you may well be an
experienced user no two brands are the same, and on reading this manual you will become
aware of the subtle advantageous differences that the KC series offers over its competitors.
UNPACKING
On unpacking your KC series please check carefully for any signs of damage that may
have occurred whilst in transit from the Laney factory to your dealer. In the unlikely event
that there has been damage please repack your unit in its original carton and consult your
dealer.
We would strongly advise you to store away your original transit carton since in the unlikely
event that some time in the future your unit should develop a fault, you will be able to
return it to your dealer for rectification securely packed.
EARTH OR GROUND
NEUTRAL
LIVE
GREEN/YELLOW
BLUE
BROWN
The KC series product should never be exposed to moisture or wetness under any
circumstances since this would represent a possible shock or fire hazard, and may cause
expensive damage to your valuable possession.
In the unlikely event that a fuse should blow, it is imperative that you or your engineer, use
a correctly rated replacement.
Details of the fuse required is printed on the rear panel of the amplifier, please take special
care to use a 'time delay' fuse wherever stated.
KC series manual
Laney
KC25
1
MIC
LINE
GAIN
5
TAPE LINE
& CD
6
GAIN
4
9
0
10
1-0+ 1
2
11
10
13
10
12
9
0
4
5
4
5
1-0+ 1
2
10
BASS
9
0
9
0
10
0
POWER
KEYBOARD
KC50
14
MIC
LINE
GAIN
5
LO
2
7
8
1
0
9
10
GAIN
REV
LO
2
7
8
4
3
REV
4
8
INJECT
9
10
4
5
4
5
1-0+ 1
2
9
10
HI
1-0+ 1
4
5
4
3
4
5
TAPELINE
& CD
1-0+ 1
2
15
HI
1-0+ 1
3
2
KC 25
9
10
0
POWER
KC100/150
GAIN
4
1-0+ 1
7
8
1
0
9
10
4
5
KC 50
17
BASS
3
2
KEYBOARD
19
MIDDLE TREBLE
1-0+ 1
4
5
GAIN
1-0+ 1
4
3
7
8
BASS
1-0+ 1
4
5
9
10
4
5
TREBLE
GAIN
1-0+ 1
4
3
7
8
9
0
BASS
1-0+ 1
4
5
10
4
5
1-0+ 1
4
3
LINE
FX
LINE
REV
LINE
FX
16
9
10
9
0
10
9
0
10
TAPE
OUT
REV
LINE
4
8
6
7
4
5
TAPE
/CD
MIC
PRESENCEREVERBMASTER
TREBLE
3
FX
REV
KEYBOARD
18
KC 150
20
ATTENTIONREMPLACER LE FUSIBLE
T2A
T5A
T1A
T2A
POWER
1
OUTPUT POWER
KC100 = 100 WATTS
KC150 = 150 WATTS
TOTAL MINIMIUM LOAD
SERIAL No:
4 OHMS
RAIN OR MOISTURE.
SPEAKER OUTPUTS
LINE OUT
CE
21
22
EXPLANATIONS OF TERMS
1
MIC: Jack input socket for low impedance microphone, balanced or unbalanced.
LINE: Jack input for line level input instruments such as keyboard/ Drum machine.
GAIN: Adjusts channel level. Enables the user to balance gain levels across each
channel
KC series manual
Laney
EXPLANATIONS OF TERMS
5
LINE: Jack input for line level input instruments such as keyboard/ Drum machine.
6 GAIN: Adjusts channel level. Enables the user to balance gain levels across each
channel.
7
12 DIRECT INJECT: Jack socket for the provision of a line level output signal for
13 HEADPHONES: Headphone output for silent practice. Plug headphones into this
SEND & RETURN: SEND and RETURN sockets for the buffered FX loop. Effects
units connected to these sockets can be channel assigned using FX switch (19).
21 SPEAKER: Onboard speaker input jack socket. The onboard speaker must be
KC series manual
Laney
EXPLANATIONS OF TERMS
REPLACING FUSES: Your amplifier leaves the factory correctly fused. Fuses are fitted
to protect the user from possible injury and your amplifier from possible permanent
damage. Fuses can blow simply from old age, or because the wrong fuse is fitted. If
after replacement with the correct fuse, failure occurs again, it is possible your amplifier
or the power supply to it, has developed a fault.
Under these circumstances you are strongly recommended to consult your local dealer or
a qualified engineer.
Replacing the POWER fuse is a procedure that can be safely undertaken by the user.
In the unlikely event that you are required to replace a blown POWER fuse it is important
to ensure that a fuse of the value and type recommended by Laney is fitted.
Ensure fuse carrier when refitted, indicates correct supply volrage.
The power fuse is located on the rear panel of your amplifier.
INTERNAL FUSE
NA
F3.15 x2
F5A x2
F5A x2
INTERNAL FUSE
NA
F3.15 x2
F5A x2
F5A x2
Your Laney amplifier has been designed to be of high quality and reliability. Each unit is
thoroughly examined and tested before leaving the factory. In the unlikely event that a fault
should develop contact the dealer from whom you made the purchase and seek their
assistance.
KC series manual
Laney
3.
TECHNICAL SPECIFICATIONS
Technical Specification
Supply Voltage
Supply Frequency
Output Power
Line Input Impedance
Mic Input Impedance
Tape/CD Input Impedance
Mic Sensitivity
Line Sensitivity
Tape/CD Sensitivity
DI Output Level
Speaker Impedance
Speaker Size
Speaker Rating
HxWxD
Line Out
FX Loop
KC25
230
50-60Hz
25W
10K
2K
2K
-40dB
-30dB
-34dB
-12dB Bal
4 Ohm
10"
30
420x390x250
NA
NA
KC50
230
50-60Hz
50W
10K
2K
2K
-40dB
-30dB
-34dB
-6dB Bal
4 Ohm
12"
50
430x520x270
NA
KC100
230
50-60Hz
100W
47K
2K
47K
-46dB Bal
-25dB
-12dB
N/A
4 Ohm
12"
120
475x545x300
0db
-12dB
KC150
230
50-60Hz
150W
47K
2K
47K
-46dB Bal
-25dB
-12dB
N/A
4 Ohm
15"+HF
150
475x545x300
0db
-12dB