Beruflich Dokumente
Kultur Dokumente
TOPICS
PAGE
EVX-Link Programming
Overview / FAQs
Pre-Installation Activities
Programming EVX-Link
EVX Mobile Programming (for use with EVX-Link)
Overview / FAQs
Programming EVX-5300/5400 (utilizing EVX-Link)
1
2
3-5
6
7-9
OVERVIEW
Product: EVX-LINK
Required Equipment:
Latest Firmware
Laptop/Desktop PC
Windows XP Service Pack 3, Windows 7 Home Premium Edition and Professional Edition, or Vista
Home Premium Edition and Business Edition
Actions
If Problem Persists
EVX-LINK Programming
PRE-INSTALLATION ACTIVITIES
STEP 1: Contact Internet provider to obtain Static IP address for modem/internet connection.
NOTE: This will be your Gateway IP address
STEP 2: Obtain the IP address of router from operators manual provided by manufacturer.
STEP 3: Enter Gateway IP address obtained from internet provider into router/modem.
NOTE: Programming may vary by manufacturer (refer to router/modem operators manual).
STEP 4: Setup router to pass UDP port 2100, this is specific for each router, and is typically found in the advanced
settings.
STEP 5: Determine Subnet mask accordingly to router IP address.
NOTE: You may not limit a network to be larger than its class.
Example:
Class A can be setup like a class A, B, or C level network with that many devices/hosts.
Class B can be setup like a class B or C level network with that many devices/hosts.
Class C can only be setup with class C level of devices/hosts.
Example:
Subnet for router IP of 192.168.1.1 subnet mask would be 255.255.255.0 (default mask)
STEP 6: Determine IP Address of EVX-Link.
NOTE: IP address has to fall within the network IP address of router
NOTE: A router is typically Class C so there can only be 256 different IP addresses.
Example:
With the example of IP address of router 192.168.1.1
EVX-LINK may be IP address 192.168.1.2 to 192.168.1.254
NOTE: Define which IP address is utilized and each device must have a unique address. EVX-Link is one (1) device.
Revised 1/13/16, Ver 008 KC
EVX-LINK Programming
PROGRAMMING EVX-LINK
STEP 1: Install device driver.
NOTE: Done only during initial installation of program.
EVX-LINK Programming
PROGRAMMING EVX-LINK continued
STEP 5: Click on FINISH
STEP 7: Run EVX-link set up icon (no installation required) STEP 8: Enter IP address and subnet mask of the EVX-Link
and read EVX-Link box. and Gateway IP address (both provided by Customers IT
department).
Select to read
EVX-Link
Enter Local EVX-Link (being
programmed) information.
EVX-LINK Programming
PROGRAMMING EVX-LINK continued
STEP 9: Enter the IP address and a description tag
for each EVX-Link box (up to 32 sites).
Laptop/Desktop PC
Windows XP Service Pack 3, Windows 7 Home Premium Edition and Professional Edition, or Vista
Home Premium Edition and Business Edition
Actions
If Problem Persists
N/A
Select Enable
STEP 10: Enter the list number into the channel selector field.
Write
Program to
Radio