Beruflich Dokumente
Kultur Dokumente
Q.
No.
1.
2.
3.
4.
5.
Unit IV
Question
Marks
Thinking
Skill
(Blooms
Taxonomy)
U
A) at a temperature higher than the saturation temperature corresponding to a steam pressure
B) at a pressure more than the boiler steam pressure
C) separated from water particles before being supplied to turbine
D) at a pressure less than the maximum cycle pressure.
The equipment installed in power plants to reduce air pollution due to smoke is
U
A) Induced draft fans
B) De-super heaters
C) Electrostatic precipitators
D) Re-heaters.
Permissible pH value of water for boilers is
An
A) 1
B) 7
C) slightly more than 7
D) 10
A condenser in a thermal power plant condenses steam combing out of
R
A) Boiler
B) Super-heater
C) Economizer
D) Turbine.
Which of the following, is not a high pressure boiler ?
U
A) Loeffler boiler
B)
Lancashire boiler
C)
Velox boiler
D)
Lamont boiler.
6.
7.
8.
9.
10.
11.
12.
13.
What is the maximum size of steam turbine usually being installed, for thermal
power plants ?
A)
120 MW
B)
250 MW
C)
500 MW
D)
1000 MW.
Overall thermal efficiency of a steam power station is in the range
A)
18-24%
B)
30-40%
C)
44-62%
D)
68-79%.
Which of the following is not the voltage at which power is usually transmitted?
A)
132 kV
B)
66 kV
C)
33 kV
D)
20 kV.
Most of the generators in thermal power plants run at
A)
3000 rpm
B)
1500 rpm
C)
1000 rpm
D)
750 rpm
In regenerative cycle, bled steam is
A)
discharged to atmosphere
B)
condensed in steam condenser
C)
used to beat feed water for boiler
D)
is mixed with steam supplied to turbine.
In power station practice "spinning reserve" is
A)
reserve generating capacity that is in operation but not in service
B)
reserve generating capacity that is connected to bus and ready to take the
load
C)
reserve generating capacity that is available for service but not in operation
D)
capacity of the part of the plant that remains under maintenance.
Bagasse is
A)
low quality coal
B)
a fuel consisting of wood
C)
fibrous portion of sugarcane left after extracting the juice
D)
a kind of rice straw.
In a steam locomotive the engine is
A)
Single cylinder
B)
Vertical
C)
Condensing
D)
Non-condensing.
An
An
14.
15.
16.
17.
18.
19.
20.
21.
Ap
Ap
22.
23.
24.
25.
In an impulse turbine
A)
water must be admitted over the whole circumference of the wheel
B)
it is net possible to regulate the flow without loss
C)
wheel must run full and be-kept entirely submerged in water below the tail
race
D)
the pressure in the driving fluid as it moves over the vane, is atmospheric.
In binary vapor cycle
A)
steam at 2 different pressures is used
B)
two fluids are used
C)
steam is expanded in 2 turbines
D)
vapor and liquid are used as working substances.
In a thermal power plant cooling towers are used to
A)
condense low pressure steam
B)
cool condensed steam
C)
cool water used in condenser for condensing steam
D)
cool feed water of boiler.
Major constituent of methane gas is
A)
CO
B)
methane
C)
oxygen
D)
hydrogen.
PART B
Ap
Q.
No.
Question
Thinkin
g Skill
(Blooms
Taxono
my)
U
1.
2.
3.
4.
5.
6.
7.
9.
What do you mean by Interlocks? Where are interlocks employed in boiler operation?
Why?
10.
11.
12.
An
13.
14.
15.
16.
17.
What is deaerator?
18.
19.
20.
8.
PART C
Q.
No.
Question
Thinking
Skill
(Blooms
Taxonomy)
An
1.
2.
An
3.
An
4.
Ap
5.
Ev
6.
Ev
7.
8.
An
9.
Ap
10.
11.
12.
13.
Ev
14.
Ap
15.
An
16.
An
17.
18.
19.
An
20.