Beruflich Dokumente
Kultur Dokumente
First aid kits & AED are located onsite. All incidents must
be report to HSE.
PPE Requirements
PPE must be worn at
all time in the facility
and warehouse.
Yellow lines on the
floor is the safe travel
zone. PPE is not
required in these
areas
Pumping Unit
Power Unit
Unit Features
Long Stroke 240 to 372
Heavy Lift Capability 25,000 to 80,000 lbs
Automatic/Independent Variable Speed Up or Down
Integrated Pump-Off Control with SCADA
Safety Features
Fewer Moving Parts and Pinch-Points
Compared with a traditional beam unit
No Crane Required for Work-Over Activity
Simple Transportation and Installation
Less injury exposure
Less heavy equipment
No Heavy Mechanical Counterweight
Protection against automatic cold weather startup
Ease of Workover
Tracking System for Sliding Pumping Unit Back and Forward for
Well Work Over within 15 minutes manually
V-base Has Small Footprint Relative to Beam Units
Leveling Feet for Adjusting Cylinder Alignment.
V-Stops Maintain Proper post workover. Virtually eliminating
polish rod parts
Well Spacing
Smaller Footprint Means
Tighter Spacing Possible:
Model 250 15 Foot
Spacing possible
Model 400 15 Foot
Spacing Possible
Model 600 - 20 Foot
Spacing Possible
Model 800 - 20 Foot
Spacing Possible
Key Advantages
Provides Eight Independent Speeds for Up and Down Stroke
Independent Accels and Decels for Up and Down Stroke.
Reverses Motor Rotation for Up and Down Cylinder Travel.
Key Advantages
Reduced OPEX
Minimize Well Interventions
Fewer Cycles
Extended BHP, tubing and sucker rod life
Equal or Greater Production at a Lower SPM
Key Advantages
Rod Compression and Decompression is Minimal
Long slow stroke and soft turn-around
FAQ
SSI Leasing Options
SSI Warranty
FAQ
SSI Maintenance
Every 180 days - change all filters, adjust and lube cables, Balance the unit, optimize, change
the automatic greaser for the bearing on the pulley and full unit inspection.
Any Questions?
20