Beruflich Dokumente
Kultur Dokumente
RVVPX310.11BT
RVVPX310.11BT--Q2
Multiband Antenna, 694960 and 2x 16952690 MHz, 65 horizontal beamwidth,
internal electrical tilt with manual override. Internal Bias-Tee from both low band ports.
Top mounted connectors for high band arrays.
l Integrated Internal Remote Electrical Tilt (RET), with independent control of electrical
tilt with manual override on all arrays
l AISG 2.0 interfaces are via integrated internal smart bias tees on low band (694960
MHz) RF Ports and a single pair of AISG 8-pin DIN input (male) and output (female)
connectors
l Uses the 4.3-10 connector which is 40 percent smaller than the 7-16 DIN connector
Electrical Specifications
Frequency Band, MHz 694790 790890 890960 16951920 19202180 23002690
Gain, dBi 16.2 16.5 16.9 17.1 17.6 18.2
Beamwidth, Horizontal, degrees 69 67 65 62 63 61
Beamwidth, Vertical, degrees 10.1 8.9 8.1 7.5 6.6 5.5
Beam Tilt, degrees 010 010 010 010 010 010
USLS (First Lobe), dB 18 18 18 18 18 18
Null Fill, dB -22 -22 -22 -22 -22 -22
Front-to-Back Ratio at 180, dB 31 32 32 35 36 38
Isolation, dB 28 28 28 30 30 30
Isolation, Intersystem, dB 30 30 30 30 30 30
VSWR | Return Loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
PIM, 3rd Order, 2 x 20 W, dBc -150 -150 -150 -150 -150 -150
Input Power per Port, maximum, watts 300 300 300 250 250 250
Polarization 45 45 45 45 45 45
Impedance 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm 50 ohm
Gain by Beam Tilt, average, dBi 5 | 15.9 5 | 16.5 5 | 16.8 5 | 16.8 5 | 17.4 5 | 17.9
* CommScope supports NGMN recommendations on Base Station Antenna Standards (BASTA). To learn more about the benefits of BASTA,
download the whitepaper Time to Raise the Bar on BSAs.
General Specifications
Operating Frequency Band 1695 2690 MHz | 694 960 MHz
Antenna Type Sector
Band Multiband
2016CommScope, Inc. All rights reserved. All trademarks identified by or are registered trademarks, respectively, of CommScope. page 1 of 3
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: November 5, 2016 November 16, 2016
Product Specifications
RVVPX310.11BT
RVVPX310.11BT--Q2
Mechanical Specifications
RF Connector Quantity, total 6
RF Connector Quantity, low band 2
RF Connector Quantity, high band 4
RF Connector Interface 4.3-10 Female
Grounding Type RF connector body grounded to reflector and mounting bracket
Radiator Material Low loss circuit board
Radome Material Fiberglass, UV resistant
Reflector Material Aluminum
RF Connector Location Bottom | Top
RF Connector Quantity, per location as listed 2 | 4
Wind Loading, frontal 1126.0 N @ 150 km/h
253.1 lbf @ 150 km/h
Wind Loading, lateral 367.0 N @ 150 km/h
82.5 lbf @ 150 km/h
Wind Loading, rear 1229.0 N @ 150 km/h
276.3 lbf @ 150 km/h
Wind Speed, maximum 241 km/h | 150 mph
Dimensions
Length 2533.0 mm | 99.7 in
Width 350.0 mm | 13.8 in
Depth 208.0 mm | 8.2 in
Net Weight, without mounting kit 32.0 kg | 70.5 lb
Packed Dimensions
Length 2720.0 mm | 107.1 in
Width 436.0 mm | 17.2 in
Depth 320.0 mm | 12.6 in
Shipping Weight 54.0 kg | 119.0 lb
Regulatory Compliance/Certifications
Agency Classification
2016CommScope, Inc. All rights reserved. All trademarks identified by or are registered trademarks, respectively, of CommScope. page 2 of 3
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: November 5, 2016 November 16, 2016
Product Specifications
RVVPX310.11BT
RVVPX310.11BT--Q2
Included Products
T-125-GL Adjustable Tilt Pipe Mounting Kit for 3.0" (75mm) OD round members for panel antennas. Includes 2 clamp
sets.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
2016CommScope, Inc. All rights reserved. All trademarks identified by or are registered trademarks, respectively, of CommScope. page 3 of 3
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: November 5, 2016 November 16, 2016