204-01B-1 Front Suspension Four Wheel Drive (4WD) 204-01B-1
REMOVAL AND INSTALLATION
Wheel Bearing and Wheel Hub
Special Tool(s) Remover, Front Wheel Hub 205-D070 (D93P-1175-B) or equivalent
Copyright 2005, Ford Motor Company
Last updated: 3/9/2007 2006 Explorer, Mountaineer, 10/2005 204-01B-2 Front Suspension Four Wheel Drive (4WD) 204-01B-2 REMOVAL AND INSTALLATION (Continued) Removal and Installation
Item Part Number Description Item Part Number Description
204-01B-3 Front Suspension Four Wheel Drive (4WD) 204-01B-3 REMOVAL AND INSTALLATION (Continued) CAUTION: Suspension fasteners are 4. CAUTION: Do not allow the caliper critical parts because they affect performance of and anchor plate assembly to hang from the vital components and systems and their failure brake hose or damage to the hose can occur. can result in major service expense. A new part Remove the bolts and position the caliper, pads with the same part number or an equivalent part and anchor plate assembly aside. must be installed, if installation is necessary. Do not use a part of lesser quality or substitute Discard the bolts. design. Torque values must be used as specified Support the caliper and anchor plate during reassembly to make sure of correct assembly using mechanics wire. retention of these parts. To install, tighten to 165 Nm (122 lb-ft). 1. With the vehicle in NEUTRAL, position it on a 5. Remove the brake disc. hoist. For additional information, refer to Section 100-02. 6. NOTE: A new wheel bearing and wheel hub comes with the wheel speed sensor installed. 2. Remove and discard the halfshaft nut and Disconnect the wheel speed sensor harness washer. electrical connector and remove and discard the To install, tighten to 250 Nm (184 lb-ft). wheel speed sensor harness bracket bolt. 3. Using the special tool, separate the outboard To install, tighten to 8 Nm (71 lb-in). CV joint from the wheel hub. 7. Remove the 3 bolts and the wheel bearing and hub assembly. Discard the bolts. To install, tighten to 122 Nm (90 lb-ft).