Beruflich Dokumente
Kultur Dokumente
Build150417
1|Page
Table of Contents
Step 1: Networking .................................................................................................3
Step 2: Device Configuration...................................................................................4
Step 3:Router Configuration ...................................................................................8
Step 4: DDNS registration .....................................................................................12
Step 5: Mobile configuration ................................................................................17
2|Page
Step 1: Networking
Connect the DVR / NVR to router/switch through a lan cable.
On your PC >> Start Run cmd ipconfig
3|Page
Step 2: Device Configuration
MenuConfigurationNetworkGeneral
Disable DHCP
Assign local ip to the device in IPv4 segment
Give Preferred DNS server address
4|Page
MenuConfigurationNetworkExtranet Access
Disable ezviz cloud
Enable DDNS
DDNS type-HiDDNS / Hkddns / EasyDDNS
Server address : asdev.hik-online.com
Device domain name eg: hik_dvr, steve, etc
5|Page
MenuConfigurationNetworkNAT
Disable UPNP
6|Page
MenuConfigurationNetworkmore settings
Change RTSP port to 1024(Vodafone Users)
7|Page
Step 3:Router Configuration
Advance SetupNAT
Disable Firewall, SPI, UPNP, port scan (if option is available)
Enable DMZ Host
Put devices local IP in DMZ host
8|Page
Note:
If you have a single device then port forwarding can be done using
DMZ host.
If you have more than one device, please follow the port
forwarding procedure mentioned in Virtual server and disable DMZ
host.
9|Page
Open ping.eu website on your browser
Ping.euport check
Check whether ports 80, 8000 and 1024 are open.
10 | P a g e
If ports are closed, go to router page
Advance SetupNATVirtual Server
Port forwarding using your devices local IP as shown in figure
below:
11 | P a g e
Step 4: DDNS registration
Open Internet Explorer in the address bar, type IP address of DDNS
Management Server http://asdev.hik-online.com
If you dont have an account, please click register new user to
create a new user.
Register a new account and login into the DDNS page using the
same username and password
12 | P a g e
When you login at the first time, it will pop up a tip to remind you
to select the country. The country cannot be changed once saved,
so please select it prudently.
For better device management, its highly recommended to set it
same as the one you set for your device.
13 | P a g e
After registration is done, login with registered username and
password
A link will be sent to your registered mail id, click on the link as
shown in the snapshot so as to confirm your e-mail id:
14 | P a g e
In Device management , click on Add option.
Enter in Device name and serial number. By default, http port of
device is 80. If http port of device was changed from 80, please
enter new port in http Port area.
Note:
Please input here the registered domain name in the device
domain area and correct device serial no.
15 | P a g e
Click Device Status to show all added devices information like
Serial number, Dynamic IP, HTTP port, DDNS IP address.
You can access the device using the Device Link URL.
If the device status is offline, you can click diagnose to check the
reason.
16 | P a g e
Step 5: Mobile configuration
17 | P a g e
Click on PLUS sign (+) to add your device.
Select Manual Adding.
18 | P a g e
Select register mode as HiDDNS
19 | P a g e
Feed the information as shown below-
Device Domain Domain name registered in DDNS management
system
Username and password of DVR/NVR.
Click on save.
20 | P a g e
After the device is saved, click on Start Live View
hik_dvr
21 | P a g e
There is a provision of adjusting the live stream according to the
network bandwidth by selecting the options shown in above image.
22 | P a g e
Thanks You!
23 | P a g e