Beruflich Dokumente
Kultur Dokumente
1.If two induction motors A and B are identical except that the air-gap of motor A is 50% greater
than that of motor B then
2.Which of the following statements regarding skewing of motor bars in a squirrel-cage induction
motor are correct?
1. It prevents cogging.
2. It produces more uniform torque.
3. It increases starting torque.
4. It reduces motor hum during its
operations
Select the correct answer using the codes given below:
a. 2,3 and 4
b. 1,2, and 3
c. 1, 2 and 4
d. 1, 3 and 4
3.The rotor power output of a 3-phase induction motor is 15kW and the corresponding slip is 4%. The
rotor copper loss will be
a. 600 W
b. 625 W
c. 650W
d. 700 W
4.A 3-phase wound rotor induction motor, when stated with load connected to its shaft, was found to
start but settee down at about half synchronous speed. If the rotor winding as well as the stator
winding were star connected, then the cause of the malfunctioning could be attributed to
5.In the case of a converter- inverter speed control arrangement for an induction motor operating with
v/f constant and with negligible stator impedance
6.A 3-phase induction machine draws active power P and reactive power Q from the grid. If it is
operated as a generator, P and Q will respectively be
a. positive and negative
b. negative and negative
c. positive and positive
d. negative and positive
7.The deep bar rotor of an induction motor is considered equivalent to a double cage rotor for the
purposes of starting and performance. At the time of starting, the current distribution in deep bar
rotor slot will be as shown in
8.A 3-phase induction motor fed f a 3-phase voltage controller is suitable for driving loads whose
torque is
9. A 3-phase induction motor is used as an adjustable speed drive from zero to 2.0 per unit speed
using a variable frequency inverter. In the speed range of 1.0 to. 2.0
per unit, in order to ensure satisfactory operation. Which one of the following sets of quantities is to
be maintained approximately constant?
10. A 3-phase slip-ring induction motor has chopper controlled resistance in the rotor circuit. Its power
factor and efficiency can be characterized respectively as
11.A 3-phase slip-ring induction motor when started picks up speed but runs stably at about half the
normal speed. This is because of
12. The phenomenon of crawling in a 3-phase cage induction motor may be due to
Of these statements :
a. 1, 2 and 3 are correct
b. 2, 3 and 4 are correct
c. 1, 3 and 4 are correct
d. 1 and 2 are correct
List II
1. Rotor resistance starting
2. Not self-starting
3. Auto-transformer starting
Codes;
---A B C
a. 2 1 3
b. 1 2 3
c. 2 3 1
d. 3 1 2
16.A 3-phase induction motor is driving a content torque load of 1 Pu at 5% slip. It has a maximum
torque of 2 Pu at 10% slip. Torque-speed variation in stable zone is assumed to be linear. For the
stable operation of the motor, the minimum pu supply voltage is approximately
a. 0.25
b. 0.50
c. 0.707
d. 0.80
17.100. As compared to DOL starting, a cage induction motor with star-delta starting shall have
18. The speed of a 3-phase induction motor is controlled from 1 pu to 2 pu using a variable frequency
inverter. The equivalent circuit parameter most likely to vary is
21. A 3-phase slip-ring induction motor is wound for 4 poles on stator and 6 poles on
rotor. When 3-phase balanced voltage source at 50 Hz is applied to the motor, it will run at :
a. 1500rpm
b. 1000rpm
c. 750 rpm
d. zero speed
22. If the rotor power factor of a 3-phase induction motor is 0.866, the spatial displacement between
the stator magnetic field and the rotor magnetic field will be
a. 30
b. 90
c. 120
d. 150
23. The stator of a 6-pole, 3-phase induction motor is fed from a 3phase, 50 Hz supply which contains
a pronounced fifth time harmonic. The speed of the fifth space harmonic field produced by the fifth
time harmonic in the stator supply will be
a. 200 rpm
b. 1500 rpm
c. 1000 rpm
d. 5000 rpm
24. A 6-pole, 50 Hz wound rotor induction motor when supplied at the rated voltage and frequency
with slip-ring opencircuited, developed a voltage of 100 V between any wo rings. If the rotor is driven
by an external means at 1000 rpm opposite to the direction of stator field, the frequency of voltage
across slip-rings will be
a. zero
b. 50 Hz
c. 100 Hz
d. 200 Hz
25. In a 3-phase squirrel cage induction motor, skewing of rotor slots reduces
a. parasitic torque and noise but increases pullout torque
b. parasitic torque and noise but increases starting torque
c. noise but increases pullout torque and parasitic torque
d. parasitic torque, noise, pullout torque and starting torque
26.The advantage of the double squirrel-cage induction motor over single cage rotor is that its
a. Efficiency is higher
b. Power factor is higher
c. Slip is larger
d. Starting current is lower
27. An induction motor when started on load does not accelerate up to full speed but runs at 1/7th) of
the rated speed. The motor is said to be
a. Locking
b. Pluming
c. Crawling
d. Cogging
28.The rotor power output of 3-phase induction motor is 15 kW The rotor copper losses at a s1p of
4% will be
a. 600W
b. 625W
c. 650W
d. 700W
30.The starting current of a 3 phase induction motor is 5 times the rated current, while the rated slip
is 4%. The ratio of starting torque to full-load torque is
a. 0.6
b. 0.8
c. 1.0
d. 1.2