Sie sind auf Seite 1von 3

Rony Parvejs EEE Job Preparation Lecture No.

13 & 14 : REB Special


Recent- Recruitment Test Question (Preliminary) of Rural Electrification Board (REB)
Post: Assistant General Manager (O&M/P&M/E&C) for PBSs

1 Time: 1 hour
Collected from: Rasel Mahmud (DIU)
Compiled by: RonyParvej (IUT, EEE07)
Full Marks: 50
Exam Date: 01.01.2016 Venue: Kurmitola High School

Sl. Ans
Question .
1 What percentage of the maximum power is deliverer to a load if load resistance is 10 times greater than the Thevenin
resistance of the source to which it is connected?
a) 25% b) 3.5% c) 33.06% d) 40%
2 The form factor of a sinusoidal wave is . .... ....
a) 1.414 b) 1.11 c) 2 d) 1.5
3 The breakdown voltage of an insulation depends upon value of alternating voltage.
a) average b) r.m s c) peak d) twice the r.m.s
4 The current taken from a 230 V, 50Hz supply is measured as 10 A with a lagging p.f of 0.7. A capacitor is connected
in parallel with the load. The true power.
a) increases b) decreases c) unchanged d) cant be predicted
5 The impedance at parallel resonance is very large because is very large
a) R b) ratio L/C c) ratio C/L d) none of the above
6 If the length of the arc in a circuit breaker increases, its resistance
a) decreases b) increases c) remains same d) none
7 The armature of a d.c. machine is laminated in order to reduce
a) eddy current loss b) hysteresis loss c) copper loss d) frictional loss
8 The no-load voltage of a generator is 240 V and rated-load voltage is 220 V. The voltage regulation of the generator is
a) 4.5% b) 11.3% c) 2.8% d) 9.1%
9 The RPM is 1500 of 25 cycle/second enriched Alternator, what will be the nos. of poles of this Alternator?
a) 4 b) 2 c) 6 d) 3
10 A transformer has an efficiency of 80% and works at 100 V, 4 KW. If the secondary voltage is 240 V, find the
primary current?
a) 40 A b) 30 A c) 20 A d) 10 A
11 The effect of leakage flux in a transformer is to .......... losses
a) increase copper b) decrease copper c) cause voltage drop in the windings d) none
12 The opencircuit test on a transformer gives ....... losses
a) copper b) iron c) friction d) total
13 Opened circuit rotor, 4-pole 3 phase induction motor is connected with 3 phase 400 volt and 50 hz. Electric line . Now
the obtained rpm of this motor is-
a) 1500 b) 1480 c) 1450 d) 0
14 A 4 pole, 50 Hz induction motor operates at 5% slip. The frequency of e.m.f induced in the rotor will be ........
a) 25 Hz b) 50 Hz c) 2.5 Hz d) none
15 The full-load slip of a synchronous motor is ........
a) 5% b) 1% c) 2% d) zero
16 The capacity of a synchronous capacitor is generally in the range of ..................
a) VAR b) MVAR c) KVA d) none of the above
17 If the length of the transmission line in 300 to 400 km, the suitable transmission voltage would be
a) 11 kV b) 33 kV c) 66 kV d) 400 kV
18 Which Distribution Voltage is not used in BREB distribution network?
a) 33 KV b) 11 KV c) 66 KV d) 6.35 KV
19 The skin effect depends upon
a) nature of material b) diameter of wire c) frequency d) all above
20 Shunts are generally made of ......... a) copper b) aluminum c) silver d) manganin
21 The rated secondary current of current transformer for relays is generally
a) 10 A b) 5 A c) 20 A d) 30
22 A Differential relays are used to protect the equipment against
a) over current b) reverse current c) internal faults d) none of above
23 A fuse should have a) low melting point b) high conductivity c) slow cost d) all above
24 An n-type semiconductor is
a) positively charged b) electrically neutral c) negatively charged d) none of the above
Rony Parvejs EEE Job Preparation Lecture No. 13 & 14 : REB Special
25 A crystal diode is used as
a) an amplifier b) a rectifier c) an oscillator d) a voltage regulator
26 The synchronous speed of a 3-phase induction motor having 20 poles and connected to a 50 Hz source is ..
a) 600 r.p.m b)1000 r:p.m c) 1200 r.p.m d) 300 r p.m
27 During the short ckt. test of 6.35/240 kv distribution transformer, impedance voltage is found 158.75 volt. The
percentage impedance of this transformer is-
a) 2.45% b) 2.50% c) 3.00% d) 6.00%
28 Full copper loss of a transformer is 1600 watt. Which will be in half load
a) 6400 watt b) 3200 watt c) 800 watt d) 400 watt m
29 When the speed of a .d.c motor increases its armature current .......
a) increases b) decreases c) remains constant d) none
30 The economic size of a conductor is determined by
a) Ohm's law b) Kelvins law c) Kirchhoffs law d) none
31 The Zero sequence component of the unbalance system of vector VA, VB & VC is ....... of the vector sum transient
disturbance is produced in a ckt. whenever
a) 1/3 b) 1/2 c) 2/3 d) 1/4
32 Which of the following connection is best suited for 3 phase 4 wire service?
a) Delta-Delta b) Delta-Wye c) Wye-Wye d) Wye-Delta
33 If the average load increase the load factor .......
a) Increase b) Decrease c) Unchange d) None
34 An accurate clock shows 8 o'clock in the morning. Through how may degrees will the hour hand rotate when the clock
shows 2 o'clock in the afternoon?
a) 144 b) 150 c) 168 d) 180
35 What is the full name of C.N.N?
a) Cable News Network b) Central News Network
c) Cable Network News d) Common News Network
36 Methods of Power Factor Improvement
a) Static Capacitor b) Synchronous Condenser c) Phase Advancer d) Above All are correct
37 The Current from neutral to ground connection is 12 Amp. Then Zero phase sequence component in phases is
a) 3A b) 2A c) 4A d) 8A
38 The commercial efficiency of a shunt generator is Maximum when its variable loss equals....... Loss.
a) Stay b) Constantt c) Iron d) Friction and windage
39 The Capacitance of Capacitor is not influence by
a) Plate thickness b) Plate area c) Plate separation medium d) Nature of them
40 The Chief disadvantage of Low VAR is that
a) More power Consumed by the Load b) Current is higher
c) Active Power is higher d) Above (a) & (b)
41 When a 400 Hz transformer is operated at 50 Hz, its KVA rating is
a) Increased by 8 times b) Reduced to 1/8 c) Unaffected d) Increased by 64 times
42 Two transformer A & B having equal outputs and voltage ratios but unequal percentage impedance of 4 & 2 are
operated in Parrallel. A will be running overloaded by
a) 50% b) 66% c) 33% d) 25%
43 The maximum collector efficiency of a class - B power Amplifier is
a) 25% b) 50% c) 78.5% d) 60%
44 Burden of a CT is generally .......type of load.
a) purely resistive b) purely capacitive c) purely inductive d) R-L-C type
45 Sag is provided in overhead lines so that
a) sate tension is not exceeded b) repair can be made
c) conductor material is saved d) none of the above
46 An Ideal amplifier have a noise factor of
a) 1 dB b) 0 dB c) 50d8 d)0.5dB
47 Frequency can be determined by....
a) f=0.5PV b) f= P x 0.5N c) f= PN/120 d) f = 120 x PI
48 Who is known as the 'lady of the Lamp' ?
a) Soroini Naidu b) Hellen Killer c) Florence Nightingale d) Madame Teresa
49 - - - ?
) ) ) )
50 ?
) ) ) )
Rony Parvejs EEE Job Preparation Lecture No. 13 & 14 : REB Special
51 , ? ?
) )
) )
52 ?
) ) ) )
53 ?
) ) ) )
54 , - - - ?
) ) ) )
55 , ?
) ) ) )
56 , , ?
) ) ) )
57 They suffered much ....... tornado had hit their village.
a) untill b) since c) as if d) let alone
58 To end in smoke means
a) To create fire b) To go through sufferings c) To come to nothing d) To see fire
59
? ) ) ) )
60 f(x) = x3 2x + 10 f(0) ? ) ) ) )
61 ? ) ) ) )
62 ?
) , ) , ) , ) ,
63 ) ) ) )
64
) ) ) )
65
) ) ) )
66 ?
) ) ) )
67 If Lagging power factor of the load decreases, the line loss will
a) decrease b) increase c) remain same d) none
68 P, Q, R PQ=a, QR=b, RP=c (
)
a) a+b+c b) b+c-a c) c+a-b d) a-b+c
69 ?
a) ax2 + bx +c b) y2 = 0 c) x2 + y2 = 16 d) y2 = 2x +7
70 ?
) ) ) )
71 Choose the correct preposition: Police is looking ...... the matter.
a) after b) on c) up d) into
72 Which of the following Sentence is Correct?
a) I forbade him from going b) I forbade him to go
c) I forbade him to going d) I forbade him not to go
73 The word ecological is related to
a) atmosphere b) pollution c) environment d) demography
74 , , , , , ...... ? ) ) ) )
75 Sky is to bird as water is to ..... a)feather b) fish c)boat d) lotus

EEE Job Preparation Facebook Group https://www.facebook.com/groups/468599736538711/


EEE Job Preparation (Rony Parvej II) https://www.facebook.com/profile.php?id=100009221389358
( ) https://www.facebook.com/ronyiut
( ) - ronyiuteee@gmail.com

Das könnte Ihnen auch gefallen