Beruflich Dokumente
Kultur Dokumente
In the figure of the right, Y-axis and the Z-axis are moving in the
direction.
Sample
In this example, shaved 45 degrees of
surface and 90 degrees of surface.
Because the easy-to-understand form, and
taken as an example of the inclined surface
machining command G68.2.
Shake up to 90 degrees to consider the
fixture and tooling will be conducted to
consider the interference of the spindle
from.
Fixture (jig).
Study of interference.
There is a need to examine the table and the main shaft other
interference.
Such as the main spindle and table fixture and tooling to
make sure that it does not interfere in the process.
The right of the figure, is shown without the most spindle has
assumed a state that would be close to the table in the
process.
If the gap is small, you need to change the fixture and tooling.
Of course, 1 pawl in actual machining, check while checking in
a single step.
Study on Path.
Consider the path (passing the path of the blade).
Photo album.
Angle of 45 degrees.