Beruflich Dokumente
Kultur Dokumente
V1.1
Esmaeil Seyyed Alikhani
RAN Team
July 2015
>
USB Method
LMT Method
USB Method
Maker Software
U Maker software
is to make and
convert xml
configuration of
eNodeB to some
file which can load
through mini USB
port of BBU on site.
USB
1-Formatting USB Flash by PC
Commissioning
Steps 2-Open Umaker and Make USB Image
Preparing U 3- Select disk path, run mode and load xml file
Disk
4- Load SW PLAT and SW Product packages and FW package
Powering on eNodeB
Inserting U Disk
Resetting eNodeB
Commission eNodeB at the site
Observing Indicators on CC Board
Inserting U Disk
Resetting eNodeB
LMT Method
LMT Method
Xml Configuration fileFirmware Package
Necessary Materials FDD-LTE Product and Platform software
packages
for USB Commission
1-Open LMT version 13
LMT method 3- Load SW and FW packages path and xml file (Image and
commissioning burn)
5- Wait for 15 to 20 min and check link with RNC and OMMB
engineer.
3- Load SW and FW packages path and xml file (Image and Burn)
3- Load SW and FW packages path and xml file (Image and Burn)
5- Wait for 15 to 20 min and check link with RNC and OMMB engineer.