Beruflich Dokumente
Kultur Dokumente
TERMINALS YUASA
1 3 19
AUTOMOTIVE
+0.2
6.5
6.5
15.7
+0.2 15.7
Taper
Taper
Taper
Taper
5
18.5
18.5
1:9
1:9
1:9
1:9
12
12
10
YUASA BATTERY
3
14.7
+0 +0 0 0 14.7 8
19.5 -0.3 17.9 -0.3 14.7 -0.3 13.0 -0.3
181
181
181
181
7 7
24.6
24.6
440.5 420.5
N
B4 19
B1 10.5
29
10.5
B5
B3 10.5 10.5
Base ledges at longitudinal sides 10.5mm high
Base ledges 10.5mm high at longitudinal and broad sides Base ledges at broad sides 29mm high
A-Maintenance of Stock
Wet-Charged Batteries
1. Check the open-circuit voltage of the batteries in your stock every month using a digital voltmeter or a multimeter.
If any have a voltage below 12.40V (6.20V for 6Vbatteries), give them a refreshing charge.
2. Scrap any batteries that drop below 11.00V (These batteries will have developed a sulphation that cannot be completely reversed by charging, and so will
not give the expected performance and life to the customer).
Dry-Charged Batteries
1. If you keep the batteries cool and dry, and do not remove the seal, dry-charged batteries do not need any other attention.
2. The maximum storage time of dry-charged batteries before setting up by filling with acid is 24months.
B-Setting Up
Wet-Charged Batteries
1. Do not supply a battery to a customer (end-user) if the voltage is below 12.40V (6.20V for 6V batteries). Change any batteries with voltages below these values.
2. We recommend you check the condition of the battery before selling it.
A SA
Dry-Charged Batteries
YU
1. Only setting up a dry-charged battery when it is needed for a customer.
of
2. If fitted, remove and discard any sealing plugs, tape or foil.
t
3. If fitted, remove and keep normal vent-plugs and terminal covers (usually red and black).
bea
4. For filling, use battery-grade dilute sulphuric acid of specific gravity 1.270-1.280 at 25 conforming to better. (Note:contaminated acid with impurities can
r t
seriously damage the life of the battery, in some cases reducing this to a few days. Do not use acid from old batteries).
ea
5. The temperature of the acid and the battery should both be at room-temperature in the range 15-30.
h
6. Fill each cell with acid to a level of 3-6mm above the tops of the separators. Fill each cell one after the other and complete the filling in one operation.
he
7. Leave the battery for 20-30 minutes and then measure the open-circuit voltage. If it is below 12.50V, charge the battery. If it is above 12.50V,
Feel t
adjust the acid-levels to the correct operating levels with dilute sulphuric acid of specific gravity 1.270-1.280.
8. Adjust levels to the maximum levels only after the battery has stood for at least an hour after charging.
9. Fit the normal vent-plugs and terminal covers.
10. Wash the battery with hot water and dry it.
1 2
2
MAINTENANCE FREE BATTERIES
"YUASA" sealed maintenance free batteries are the best choice especially Sealed Maintenance Free Battery (JIS)
for the high-end car which covers Japanese, European & American cars. Dimensions(mm) Capacity Reserved CCA CA Terminal Weight
Voltage Cell
Model Capacity (AMP) (AMP) type With Acid
It has been designed for excellent performance, high durability and reliability. Length Width
Total (V) 5HR 20HR
(Min) at0 F at32 F
Layout
pole shape kgs
Height (Ah) (Ah)
After installing it, car owners will no longer experience water loss SMF 40B19L 187 127 226 12 27 33 49 300 410 , SMALL 9.5
and other battery troubles they experienced before. SMF 40B19R 187 127 226 12 27 33 49 300 410 , SMALL 9.5
SMF NS40ZL(40B20L) 197 129 224 12 27 35 49 300 410 , SMALL 10.00
SMF NS40Z(40B20R) 197 129 224 12 27 35 49 300 410 , SMALL 10.00
SMF NS40ZLS(40B20LS) 197 129 224 12 27 35 49 300 410 , STD 10.00
SMF NS40ZS(40B20RS) 197 129 224 12 27 35 49 300 410 , STD 10.00
SMF NX100-S6L(55B24L) 238 129 225 12 36 45 80 430 540 , SMALL 12.50
SMF NX100-S6(55B24R) 238 129 225 12 36 45 80 430 540 , SMALL 12.50
SMF NX100-S6LS(55B24LS) 238 129 225 12 36 45 80 430 540 , STD 12.50
SMF NX100-S6S(55B24RS) 238 129 225 12 36 45 80 430 540 , STD 12.50
SMF 50D20L 202 173 225 12 42 50 85 450 590 , STD 15.00
SMF 50D20R 202 173 225 12 42 50 85 450 590 , STD 15.00
SMF 55D23L 232 173 225 12 48 60 100 500 630 , STD 15.80
SMF 55D23R 232 173 225 12 48 60 100 500 630 , STD 15.80
SMF 70D23L 232 173 225 12 52 65 110 580 710 , STD 16.60
SMF 70D23R 232 173 225 12 52 65 110 580 710 , STD 16.60
SMF N50L(48D26L) 260 173 222 12 40 50 80 420 550 , STD 15.00
SMF N50(48D26R) 260 173 222 12 40 50 80 420 550 , STD 15.00
SMF N50ZL(55D26L) 260 173 222 12 48 60 100 500 630 , STD 16.50
SMF N50Z(55D26R) 260 173 222 12 48 60 100 500 630 , STD 16.50
SMF NX110-5L 260 173 222 12 56 70 115 600 730 , STD 18.00
SMF NX110-5 260 173 222 12 56 70 115 600 730 , STD 18.00
SMF N70L(65D31L) 303 173 225 12 56 70 105 560 690 , STD 19.00
SMF N70(65D31R) 303 173 225 12 56 70 105 560 690 , STD 19.00
SMF N70ZL(75D31L) 303 173 225 12 60 75 120 630 760 , STD 20.50
SMF N70Z(75D31R) 303 173 225 12 60 75 120 630 760 , STD 20.50
SMF NX120-7L(95D31L) 303 173 225 12 72 90 145 730 860 , STD 22.00
SMF NX120-7(95D31R) 303 173 225 12 72 90 145 730 860 , STD 22.00
SMF 1000LA 330 173 232 12 80 100 182 870 1000 , STD 26.00
SMF 1000RA 330 173 232 12 80 100 182 870 1000 , STD 26.00
SMF 1000LS 330 173 232 12 80 100 182 870 1000 , STUD 26.00
SMF 1000RS 330 173 232 12 80 100 182 870 1000 , STUD 26.00
SMF N100L(95E41L) 410 175 235 12 80 100 180 830 960 , STD 25.50
SMF N100(95E41R) 410 175 235 12 80 100 180 830 960 , STD 25.50
SMF N120L(115F51L) 505 183 240 12 96 120 230 820 950 STD 33.00
SMF N120(115F51R) 505 183 240 12 96 120 230 820 950 STD 33.00
SMF N150L(145G51L) 508 222 241 12 120 150 300 1000 1130 STD 39.00
SMF N150(145G51R) 508 222 241 12 120 150 300 1000 1130 STD 39.00
SMF N200L(190H52L) 523 279 248 12 160 200 430 1150 1280 STD 55.00
SMF N200(190H52R) 523 279 248 12 160 200 430 1150 1280 STD 55.00
20ft container loading quantity : 12pallets
The specications in this catalogue are subject to change with or without notice.
4 5
3
4
MAINTENANCE FREE BATTERIES
Sealed Maintenance Free Battery (DIN) Sealed Maintenance Free Battery (BCI)
A. Passenger Car & Light Commercial Batteries
Dimensions(mm) Capacity CCA Weight Bottom Dimensions(mm) RESERVED CCA CA BCI Terminal Weight Loading
Voltage RC Cell Voltage
Model Total 20h SAE EN With Acid Hold- Terminals Model Total Capacity(Min) (AMP) (AMP) FIGURE type With Acid Qty per Remarks
Length Width (V) (Min) Layout Length Width (V)
Height rate(Ah) (A) (A) kgs Down Height AT 80 F at0 F at32 F NO. pole shape kgs pallet
SMF 53528 211 175 175 12 35 52 340 300 12.00 , B3 FORD SMF 35-500 232 173 225 12 100 500 630 11 STD 15.80 88 Available by
SMF 53527 211 175 175 12 35 52 340 300 12.00 , B3 FORD SMF 35-580 232 173 225 12 110 580 710 11 STD 16.50 88 BC125
SMF 53529 211 175 175 12 35 52 340 300 12.00 , B3 STD SMF 70-450 208 179 185 12 65 450 580 17 Side posts 13.80 112
SMF 53638 211 175 175 12 36 52 340 300 12.00 , B1 STD SMF 70-520 208 179 185 12 74 520 650 17 Side posts 14.00 112
SMF 70-615 208 179 185 12 94 615 745 17 Side posts 14.60 112
SMF 53637 211 175 175 12 36 52 340 300 12.00 , B3 STD
SMF 70DT-520 208 179 205 12 74 520 650 10,17 Dual posts 14.00 112
SMF 53646 211 175 175 12 36 52 340 300 12.00 , B1/B4 STD SMF 70DT-615 208 179 205 12 94 615 745 10,17 Dual posts 14.60 112
/53653
SMF 34-550 260 171 205 12 84 550 680 10 STD 16.00 80
SMF 54316 211 175 175 12 43 70 380 360 12.90 , B3 STD
SMF 34-710 260 171 205 12 110 710 840 10 STD 17.50 80
SMF 54317 211 175 175 12 43 70 380 360 12.90 , B3 FORD SMF 34-760 260 171 205 12 115 760 890 10 STD 18.00 80
SMF 54459 208 175 190 12 50 71 415 380 13.30 , B3 STD SMF 78-450 260 179 185 12 65 450 580 17 Side posts 15.50 80
SMF 54464 208 176 190 12 50 71 415 380 13.30 , B3 STD SMF 78-550 260 179 185 12 84 550 680 17 Side posts 16.00 80
Available by
SMF 54519 245 175 175 12 45 80 430 400 13.50 , B4 STD SMF 78-710 260 179 185 12 110 710 840 17 Side posts 17.50 80 more CCA
SMF 55040 245 175 175 12 50 86 415 380 13.80 , B3 STD SMF 78DT-550 260 179 205 12 84 550 680 10,17 Dual posts 16.00 80
SMF 55066 208 175 190 12 50 86 415 380 13.50 , B3 STD SMF 78DT-710 260 179 205 12 110 710 840 10,17 Dual posts 17.50 80
SMF 55414 277 175 175 12 54 94 500 460 15.00 , B3/B4 STD SMF 78DT-760 260 179 205 12 115 760 890 10,17 Dual posts 18.00 80
SMF 75-550 231 179 185 12 84 550 680 17 Side posts 15.00 96
SMF 55457 245 175 175 12 54 94 500 460 14.30 , B3 STD
SMF 75-660 231 179 185 12 100 660 790 17 Side posts 16.00 96
SMF 55458 245 175 175 12 54 94 500 460 14.30 , B3 STD
SMF 75DT-550 231 179 205 12 84 550 680 10,17 Dual posts 15.00 96
SMF 55459 245 175 175 12 54 94 500 460 14.30 , B3 FORD
SMF 75DT-660 231 179 205 12 100 660 790 10,17 Dual posts 16.00 96
SMF 55523 245 175 190 12 55 94 500 460 14.80 , B3 FORD
SMF 22F-470 240 174 205 12 86 470 590 11-F.J DF/STD 14.00 88
SMF 55559 245 175 190 12 55 94 500 460 14.80 , B3 STD SMF 22F-530 240 174 205 12 95 530 650 11-F.J DF/STD 14.50 88
SMF 55565 245 175 190 12 55 94 500 460 14.80 , B3 STD SMF 86-550 230 174 205 12 84 550 680 10 STD 15.00 96
SMF 56219 245 175 190 12 62 100 550 510 15.00 , B3 STD SMF 86-615 230 174 205 12 97 615 745 10 STD 15.50 96
SMF 56217 245 175 190 12 62 100 550 510 15.00 , B3 STD SMF 58-490 236 183 177 12 90 490 620 21-K STD 14.00 100
SMF 56048 269 174 226 12 60 100 530 440 17.00 , B9 STD SMF 58-530 236 183 177 12 100 530 660 21-K STD 14.50 100 Available by
reversetype
SMF 56318 277 175 175 12 63 110 580 540 16.50 , B3/B4 STD SMF 65-660 292 189 191 12 120 660 790 21-K STD 18.80 72
&more CCA
SMF 56323 277 175 175 12 63 110 580 540 16.50 , B3/B4 FORD SMF 65-730 292 189 191 12 138 730 860 21-K STD 20.00 72
SMF 56330 277 175 175 12 63 110 580 540 16.50 , B3/B4 STD
B. Heavy-Duty Commercial Batteries
SMF 56638 278 175 190 12 66 110 580 540 16.80 , B3 STD
Dimensions(mm) RESERVED CCA CA BCI Terminal Weight Loading
SMF 56639 278 175 190 12 66 110 580 540 16.80 , B3 FORD Voltage
Model Total Capacity(Min) (AMP) (AMP) FIGURE type With Acid Qty per Remarks
SMF 56640 278 175 190 12 66 110 580 540 16.80 , B3 STD Length Width (V)
Height AT 80 F at0 F at32 F NO. pole shape kgs pallet
SMF 57029 269 174 226 12 70 120 560 520 18.00 , B9 STD
SMF 30H-730 330 173 229 12 156 730 860 10 STD 23.50 60
SMF 57113 277 175 175 12 71 115 610 580 16.80 , B3/B4 STD
SMF 30H-830 330 173 229 12 180 830 960 10 STD 24.00 60 Available by
SMF 57114 277 175 175 12 71 115 610 580 16.80 , B3/B4 FORD
SMF 31-730 330 173 240 12 156 730 860 18 Stud/STD 24.50 60 more CCA
SMF 57219 277 175 190 12 72 120 640 600 17.80 , B3 STD
SMF 31-930 330 173 240 12 200 930 1060 18 Stud/STD 26.00 60
SMF 57220 277 175 190 12 72 120 640 600 17.80 , B3 STD
SMF 58014 315 175 175 12 80 135 730 660 19.00 , B3 STD
C. General utility & Marine Batteries
SMF 58515 353 175 175 12 85 140 730 660 21.50 , B3 STD
Dimensions(mm) RESERVED CCA CA BCI Terminal Weight Loading
SMF 58827 353 175 190 12 88 148 770 700 22.50 , B3 STD Voltage
Model Total Capacity(Min) (AMP) (AMP) FIGURE type With Acid Qty per Remarks
SMF 58828 353 175 190 12 88 148 770 700 22.50 , B3 STD Length Width (V)
Height AT 80 F at0 F at32 F NO. pole shape kgs pallet
SMF 60044 353 175 190 12 100 170 850 780 24.50 , B3 STD
SMF U1-200 197 132 186 12 27 200 310 10( ) Lug 6.50 180
Type of base hold-down(BHD) SMF U1-230 197 132 186 12 33 230 340 10( ) Lug 7.00 180
B1 : 2 bottom hold-downs 10.5mm high on long sides SMF U1-250 197 132 186 12 38 250 360 10( ) Lug 7.80 180
B3 : 4 bottom hold-downs 10.5mm high on all four sides with 3 or 5 notches SMF U1R-200 197 132 186 12 27 200 310 11( ) Lug 6.50 180
B4 : 2 bottom hold-downs 19mm high on long sides SMF U1R-230 197 132 186 12 33 230 340 11( ) Lug 7.00 180
B9 : 2 bottom hold-downs 29mm high on short sides SMF U1R-250 197 132 186 12 38 250 360 11( ) Lug 7.80 180
B3/B4 : B4 BHD available with adaptor on the long sides SMF M24-420 260 174 225 12 80 420 550 , side by side 15.50 80
/B1 : with or without B1 BHD(optional by customer's request) SMF M24-700 260 174 225 12 135 700 830 , side by side 20.50 80
/B3 : with or without B3 BHD(optional by customer's request) SMF M27-560 304 173 225 12 105 560 690 , side by side 20.60 72
SMF M27-630 304 173 225 12 120 730 860 , side by side 22.30 72
5 6
DRY CHARGED BATTERIES
"YUASA PAFECTA" Dry charged batteries has been well known from the DRY CHARGED BATTERIES (JIS)
market for a long times and especially has the advantage for heavy duty-use. Capacity CCA RC Overall Dimensions(mm)
New JIS Jaso Nearest Other
It has been designed for quick activation, high durability and reliability. Type Type UK Type
20HR
(Ah)
5HR
(Ah)
(AMP)
-18
(Mins)
25 Length Width Height
Total Layout Terminal
Features
Height
The products cover almost full range of models for JIS & DIN specifications. 32B20R NS40 154/054
(Reference Only)
7 8
DRY CHARGED BATTERIES