Beruflich Dokumente
Kultur Dokumente
Notes
Abstract
Fier Thermal Power Plant Albania (Shutdown) is located at Fier, Fier, Albania. Location coordinates are: Latitude= 40.7009, Longitude= 19.5507.
infrastructure is of TYPE Oil Power Plant with a design capacity of 186 MWe. and the last in . It is operated by Korporata Elektroenergjitike Shqiptare (KESH).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Oil
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Fier Thermal
Power Plant
Decommissioned 42696 Lek
Albania
(Shutdown)
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
40.7009 19.5507 Exact 186
Steam Turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
Korporata
Elektroenergjitike
National grid
Shqiptare
(KESH)
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 12
2 12
3 25
4 25
5 25
6 60
Unit Information
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
perator Information Comments
Korporata
Elektroenergjitike
Shqiptare
(KESH)
References
http://www.narucpartnerships.org/Documents/Generation%20sources
%20and%20power%20sector%20infrastructure%20development%20in
%20Albania_Nashi_Eng.pdf and
http://en.wikipedia.org/wiki/Fier_Power_Station
http://seebusinessguides.com/alb_energy.html
ID
Notes
Abstract
TEC Vlora CCGT Power Plant Albania is located at 6 km NW of Vlore, Vlore, Albania. Location coordinates are: Latitude= 40.4874, Longitude= 19.434.
infrastructure is of TYPE Gas Power Plant with a design capacity of 97 MWe. It has 1 unit(s). The first unit was commissioned in 2011. It is operated by Korpo
Elektroenergjitike Shqiptare (KESH).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Gas
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
TEC Vlora
CCGT Power Operating Fully 42697 Lek
Plant Albania
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Combined Cycle
40.4874 19.434 Approximate 97
Gas Turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
6 km NW of
One 1+1+1
Distillate Oil Base Load Vlore, Vlore,
CCGT block
Albania
Description
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
Korporata
Elektroenergjitike
National grid
Shqiptare
(KESH)
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
200000000 2009
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 97 2011-11
Unit Information
Decommission
Turbine Turbine Generator Generator Boiler/HRSG Boiler/HRSG
Date (yyyy-mm-
Manufacturer Model/Type Manufacturer Model/Type Manufacturer Model/Type
dd)
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
Ansaldo, Maire
Tecnimont
perator Information Comments
http://www.kesh.com.al/content.aspx?id=4&idd=28
http://www.industcards.com/cc-europe.htm
http://http://www.kesh.com.al/ (Annual report 2010)
ID
Notes
Abstract
Bitola Coal Power Plant Macedonia is located at Novaci, Bitola, Macedonia. Location coordinates are: Latitude= 41.058, Longitude= 21.4832. This infrastructu
of TYPE Coal Power Plant with a design capacity of 675 MWe. It has 3 unit(s). The first unit was commissioned in 1982 and the last in 1988. It is operated by M
and Power Company Bitola.
Oslomej Coal Power Plant Macedonia is located at Oslomej, Kicevo, Macedonia. Location coordinates are: Latitude= 41.5824, Longitude= 21.0006.
infrastructure is of TYPE Coal Power Plant with a design capacity of 125 MWe. It has 1 unit(s). The first unit was commissioned in 1980. It is operated by M
and Power Complex Oslomej.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Bitola Coal
Power Plant Operating Fully 42700 Denar
Macedonia
Oslomej Coal
Power Plant Operating Fully 42701 Denar
Macedonia
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
41,058 21,4832 Exact 675
Thermal
Sub-critical
41.5824 21.0006 Exact 125
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
produces about
Novaci, Bitola,
70% of national Coal Lignite Base Load
Macedonia
total
Oslomej, Kicevo,
Coal Lignite Base Load
Macedonia
Des
Water
Electric Power Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
Grid Connected SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
To Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Adjacent
Nationa Grid Suvodol Lignite
mine
AD Elektrani na Adjacent
Nationa Grid Makedonia Oslomej-Zapad
(ELEM) Coal Mine
Description
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
3 Heller cooling
towers
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Particulates(PM
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify: ) Control Device
Device Device Type Device Type
Type
Unit Informatio
Date Decommission
Boiler
If other, specify: nit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
Regulatory Project
Authority Financed By
Comments
Comment 1
Suvodol is an open-pit mine equipped with three coal extraction systems (excavator,conveyer, spreader). The caloric value is about 7000-8000 kJ/kg.
generating unit consumes about 2 million tonnes of lignite per year.
http://www.elem.com.mk/index.php?
option=com_content&view=article&id=121&Itemid=151&lang=en
http://www.industcards.com/st-coal-kosovo-macedonia.htm
http://www.elem.com.mk/index.php?
option=com_content&view=article&id=198&Itemid=166&lang=en (Annual Reports)
http://www.elem.com.mk/index.php?
option=com_content&view=article&id=122&Itemid=151&lang=en
http://www.industcards.com/st-coal-kosovo-macedonia.htm
http://www.elem.com.mk/index.php?
option=com_content&view=article&id=198&Itemid=166&lang=en (Annual Reports)
ID
Notes
Abstract
Negotino Thermal Power Plant Macedonia is located at Negotino, Macedonia. Location coordinates are: Latitude= 41.49205, Longitude= 22.09354.
infrastructure is of TYPE Oil Power Plant with a design capacity of 210 MWe. It has 1 unit(s). The first unit was commissioned in 1978.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Oil
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Negotino Thermal
Power Plant Decommissioned 42702 Denar
Macedonia
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
41.49205 22.09354 210
Steam Turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
National grid
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: Unit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 210 1978
Unit Information
2008
Environmental Issues Past and Future Major U
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
perator Information Comments
http://www.ero-ks.org/GIS/Final_Appendix_8.pdf
ID
Notes
Abstract
TE-TO AD Skopje Thermal Power Plant Macedonia is located at Skopje, Macedonia. Location coordinates are: Latitude= 41.994474, Longitude= 21.452807. T
infrastructure is of TYPE Gas Turbine Combined Cycle Power Plant with a design capacity of 227 MWe. Power plant have 1 gas turbine with 1 HRSG and Ste
turbine with district heating system.
Kogel Sever Thermal Power Plant Macedonia is located at Skopje, Macedonia. Location coordinates are: Latitude= 42.008892, Longitude= 21.466676. This
infrastructure is of Reciprocating gas engines with a design capacity of 30 MWe. Power plant have 10 gas engines.
ELEM Energetika Thermal Power Plant Macedonia is located at Skopje, Macedonia. Location coordinates are: Latitude= 42.019346, Longitude= 21.465973. T
infrastructure is of Reciprocating gas engines with a design capacity of 30 MWe. Power plant have 10 gas engines with .
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Gas
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
TE-TO AD
Operating Fully Denars
Skopje CCPP
ELEM
Operating Fully Denars
Energetika
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
25 96 Sub-critical thermal
Configuration
Power Plant Used of
Short Description Type of Fuel Primary Secondary Location
For Boiler/Turbine/
Gen
Intermediate/Peak Skopje,
Natural Gas One 1+1+1
Load Macedonia
Total steam
Intermediate/Peak Skopje,
production 20 t/h Natural Gas 10 Gas engines
Load Macedonia
(12,96 Mwh)
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
National Grid
Natural gas
National Grid
(from Russia)
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 180.703
2 76
1 3.014 2011
2 3.014 2011
3 3.014 2011
4 3.014 2011
5 3.014 2011
6 3.014 2011
7 3.014 2011
8 3.014 2011
9 3.014 2011
10 3.014 2011
1 12.5 1967
2 12.5 1967
Unit Information
Decommission
Generator Generator
Date (yyyy-mm- Turbine Manufacturer Turbine Model/Type
Manufacturer Model/Type
dd)
TPK G32
TPK G32
nvironmental Issues Past and Future Major Upgrades
Joint stock
Kogel Sever Doo Skopje
company
Project
Comment 1
Financed By
From 1967 heavy fuel oil (mazut), in 2000 with Natural gas
References
http://www.moepp.gov.mk/wp-content/uploads/2014/10/Baranje%20za%20dobivanje%20%20A-Dozvo
ID
Notes
Abstract
Plomin Thermal Power Plant Croatia is located at Plomin luka 51, Istarska, Croatia. Location coordinates are: Latitude= 45.137, Longitude= 14.164.
infrastructure is of TYPE Coal Power Plant with a design capacity of 330 MWe. It has 2 unit(s). The first unit was commissioned in 1969 and the last in 2000.
operated by TE Plomin d.o.o..
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Plomin Thermal
Power Plant Operating Fully 44820 Croatian Kuns
Croatia
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
45.137 14.164 Exact 330
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Water
Electric Power Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
Grid Connected SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
To Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Longterm PPA
Imported via
National grid with Croatian
nearby coal port
Utility HEP
Description
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
Seawater
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Particulates(PM
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify: ) Control Device
Device Device Type Device Type
Type
Unit Informatio
Date Decommission
Boiler
If other, specify: nit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
Regulatory Project
Authority Financed By
Comments
Comment 1
References
http://www.hep.hr/proizvodnja/en/basicdata/thermal/plomin.aspxhttp://www.rwe.com/web/cms/en/192
ID
Notes
Abstract
Jertovec CCGT Power Plant Croatia is located at Jertovec, Krapinsko-Zagorska, Croatia. Location coordinates are: Latitude= 46.0386, Longitude= 16.1814.
infrastructure is of TYPE Gas Power Plant with a design capacity of 78 MWe. It has 4 unit(s). The first unit was commissioned in 1975 and the last in 1956.
operated by Hrvatska elektroprivreda (HEP) d.d..
Osijek TE-TO CHP Power Plant Croatia is located at Martina Divalta 203, 31000 Osijek, Osjecko-Baranjska, Croatia. Location coordinates are: Latitude= 45.
Longitude= 18.7449. This infrastructure is of TYPE Gas Power Plant with a design capacity of 89 MWe. It has 3 unit(s). The first unit was commissioned in 1
and the last in 1985. It is operated by Hrvatska elektroprivreda (HEP) d.d..
Zagreb El-To CHP Power Plant Croatia is located at Grad Zagreb, Croatia. Location coordinates are: Latitude= 45.8069, Longitude= 15.9498. This infrastruc
is of TYPE Gas Power Plant with a design capacity of 86.8 MWe. It has 4 unit(s). The first unit was commissioned in 1970 and the last in 1998. It is operate
Hrvatska elektroprivreda (HEP) d.d..
Zagreb Te-To CHP Power Plant Croatia is located at Grad Zagreb, Croatia. Location coordinates are: Latitude= 45.7816, Longitude= 16.0169. This infrastruc
is of TYPE Gas Power Plant with a design capacity of 328 MWe. It has 6 unit(s). The first unit was commissioned in 1979 and the last in 2009. It is operate
Hrvatska elektroprivreda (HEP) d.d..
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Gas
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Jertovec CCGT
Power Plant Operating Fully 44825 Croatian Kuna
Croatia
Osijek TE-TO
CHP Power Operating Fully 44826 Croatian Kuna
Plant Croatia
Zagreb El-To
CHP Power Operating Fully 44824 Croatian Kuna
Plant Croatia
Zagreb Te-To
CHP Power Operating Fully 44823 Croatian Kuna
Plant Croatia
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Combined Cycle
46.0386 16.1814 Exact 78
Gas Turbine
OCGT and
45.542 18.7449 Exact 89 139
CCGT
Combined Cycle
45.8069 15.9498 Exact 86.8 439
Gas Turbine
Combined Cycle
45.7816 16.0169 Exact 328 740
Gas Turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Jertovec,
Light Fuel Krapinsko- two 1+1+1
Natural Gas
Oil/Diesel Zagorska, CCGT blocks
Croatia
Martina Divalta
203, 31000 one 2+2+1
Natural Gas Fuel oil Osijek, Osjecko- CCGT. three
Baranjska, steam boilers
Croatia
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
Hrvatska
National Grid Elektroprivreda
(HEP)
Hrvatska
National Grid Elektroprivreda
(HEP)
Industry,
National Grid Commercial and
Residential
Adjacent
National Grid Seva River
substation
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
50
160
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 27.5 1975
2 10.5 1956
3 27.5 1975
4 10.5 1956
1 25 1976
2 25 1976
3 45 1985
1 11 1970
2 30 1980
3 23.9 1998
4 23.9 1998
1 120 1979
2 71 2003
3 71 2003
4 66 2003
5 75 2009
6 37 2009
Unit Information
Decommission
Turbine Turbine Generator Generator Boiler/HRSG Boiler/HRSG
Date (yyyy-mm-
Manufacturer Model/Type Manufacturer Model/Type Manufacturer Model/Type
dd)
GT-1
ST-1
GT-1
ST-1
GT-1
GT-2
ST-1
ST-1
ST-2
GT-1
GT-2
ST-1
GT-1
GT-2
ST-2
GT-3
ST-3
Environmental Issues Past and Future Major U
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
Hrvatska
2012 - 2013 elektroprivreda
(HEP) d.d.
Hrvatska
elektroprivreda Government
(HEP) d.d.
Hrvatska
elektroprivreda Government
(HEP) d.d.
Hrvatska
Elektroprojekt,
elektroprivreda Government
Parsons E&C
(HEP) d.d.
perator Information Comments
Hrvatska
elektroprivreda The GT can operate in open mode
(HEP) d.d.
Hrvatska
elektroprivreda The GT can operate in open mode
(HEP) d.d.
Hrvatska
elektroprivreda
(HEP) d.d.
Hrvatska
elektroprivreda
(HEP) d.d.
References
http://www.hep.hr/proizvodnja/en/basicdata/thermal/jertovec.aspx
http://www.hep.hr/proizvodnja/en/basicdata/thermal/osijek.aspx
http://www.hep.hr/proizvodnja/en/basicdata/ther
mal/elto.aspx
http://www.industcards.com/st-other-croatia.htm
http://www.izvoznookno.si/Dokumenti/EU27-
projects%20background.pdf
http://www.hep.hr/proizvodnja/en/basicdata/ther
mal/teto.aspx
http://www.industcards.com/st-other-croatia.htm
ID
Notes
Abstract
Rijeka Thermal Power Plant Croatia is located at Southeast of Rijeka, Primorsko-Goranska, Croatia. Location coordinates are: Latitude= 45.2862, Longitu
14.5207. This infrastructure is of TYPE Oil Power Plant with a design capacity of 320 MWe. It has 1 unit(s). The first unit was commissioned in 1978. It is oper
by Hrvatska elektroprivreda (HEP) d.d..
Sisak Thermal Power Plant Croatia is located at Ulica brae Bobetko 40, 44010 Sisak, Sisacko-Moslavacka, Croatia. Location coordinates are: Latitude= 45.4
Longitude= 16.4144. This infrastructure is of TYPE Oil Power Plant with a design capacity of 420 MWe. It has 2 unit(s). The first unit was commissioned in 1
and the last in 1976. It is operated by HEP Proizvodnja d.o.o..
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Oil
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Rijeka Thermal
Power Plant Operating fully 44822 Croatian Kuna
Croatia
Sisak Thermal
Power Plant Operating fully 44821 Croatian Kuna
Croatia
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
45.2862 14.5207 Exact 320
Steam Turbine
Sub-critical
45.4538 16.4144 Exact 420
Steam Turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Southeast of
Rijeka,
Peaking Load
Heavy Fuel Oil Primorsko-
and Backup
Goranska,
Croatia
Ulica brae
Bobetko 40,
44010 Sisak,
Oil Natural Gas
Sisacko-
Moslavacka,
Croatia
Description
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
National Grid
1 320 1978
1 210 1970
2 210 1976
Unit Information
250
Past and Future Major Upgrades Owner and Operator Information
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
Hrvatska
elektroprivreda Government Ansaldo
(HEP) d.d.
Hrvatska
elektroprivreda
(HEP) d.d.
http://www.hep.hr/proizvodnja/en/basicdata/thermal/rijeka.aspx
http://www.industcards.com/st-other-croatia.htm
http://en.wikipedia.org/wiki/TE_Rijeka
xhttp://www.hep.hr/proizvodnja/en/basicdata/thermal/sisak.aspx
http://www.industcards.com/st-other-croatia.htm
http://www.power-m.ru/es/press/news.aspx?news=2281
ID
Notes
Abstract
Ljubljana (TE-TOL) Coal CHPP Slovenia is located at Osrednjeslovenska, Slovenia. Location coordinates are: Latitude= 46.058, Longitude= 14.5451.
infrastructure is of TYPE Coal Power Plant with a design capacity of 124 MWe. It has 3 unit(s). The first unit was commissioned in 1966 and the last in 1984.
operated by Termoelektrarna Toplarna Ljubljana, d.o.o..
Sostanj (TES) Coal Power Plant Slovenia is located at Cesta Lole Ribarja 18, 3310, Sostanj, Slovenia. Location coordinates are: Latitude= 46.3723, Longitu
15.0534. This infrastructure is of TYPE Coal Power Plant with a design capacity of 695 MWe. It has 7 unit(s). The first unit was commissioned in 1956 and the
in 2008. It is operated by Termoelektrarna Sostanj d.o.o..
Trbovlje (TES) Coal Power Plant Slovenia is located at Trbovjle, Zasavska. Location coordinates are: Latitude= 46.1258, Longitude= 15.06114. This infrastruc
is of TYPE Coal Power Plant with a design capacity of 125 MWe. It has 1 unit(s). The first unit was commissioned in 1966. It is operated by Termoelektra
Trbovlje, d.o.o..
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Ljubljana (TE-
TOL) Coal CHPP Operating fully 41126 Euro
Slovenia
Sostanj (TES)
Coal Power Operating fully 41125 Euro
Plant Slovenia
Trbovlje (TES)
Coal Power Operating fully 41124 Euro
Plant Slovenia
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
46.058 14.5451 Exact 124 340
Thermal
Sub-critical
46.3723 15.0534 Exact 695
Thermal
Sub-critical
46.1258 15.06114 Exact 125
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Coal
Cesta Lole
Ribarja 18, 3310,
Coal Lignite Natural Gas
Sostanj,
Slovenia
Trbovjle,
Lignite Natural Gas
Zasavska
Des
Water
Electric Power Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
Grid Connected SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
To Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Imported Coal
from Indonesia
Lignite from
National Grid
Velenje
Zasavje Coal
Mines
Description
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
Adjacent canal
Premogovnik Sostansko
Velenje Jezero
Sava River
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Particulates(PM
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify: ) Control Device
Device Device Type Device Type
Type
Unit Informatio
Date Decommission
Boiler
If other, specify: Unit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
1 42 1966
2 32 1966
3 50 1966
1 1956 3/31/2010
2 1956 2008
3 1960
4 1973
5 1/27/1978
6 2008
7 2008
ST-1
ST-2
ST-3
ST-4
ST-5
64,57 %
Government Slovenian
Termoelektrarna
Government Toplarna
Ljubljana, d.o.o.
City of Ljubljana
35,43 %
Regulatory Project
Authority Financed By
Comments
Comment 1
Annual average from 1996-2007 is Heat 1095 GWh; Electricity 400 GWh; Coal consumption: 480000 tons
Since 2002 use Indonesian coal with high calorific value and very low sulfur content (less than 0.2%) and ash (1-3%). Use 8% woodchips since 2008
Average annual electricity production ranges between 3500 and 3800 GWh. Average annual production of thermal energy for district heating Salek Valley is
- 450 GWh. For such an annual production of electricity and thermal energy is consumed between 3.5 and 4.2 million tons of coal and about 60 MMSCM of na
gas.
A high efficiency 600 MWe unit will replace existing units and become operation in 2014
Average annual consumption of coal in the period 2003 to 2010 amounted to 4,100 thousand tonnes
The steam unit was modernized in 1999 and the site also hosts two 32-MW combustion turbines
References
http://www.te-tol.si/
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.industcards.com/st-coal-slovenia.htm
http://www.te-sostanj.si/
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.te-sostanj.si/en/presentation/tes-in-slovenia
http://www.tet.si http://www.tet.si/si/elektricna-energija/proizvodni-rezultati/
http://www.industcards.com/st-coal-slovenia.htm
http://www.tet.si/si/o-podjetju/razvojni-projekti/
http://prtr.ec.europa.eu/FacilityLevels.aspx
ID
Notes
Abstract
Gacko Coal CHP Power Plant Bosnia and Herzegovina is located at Gacko, Srpska, Bosnia and Herzegovina. Location coordinates are: Latitude= 43.1
Longitude= 18.5128. This infrastructure is of TYPE Coal Power Plant with a design capacity of 300 MWe. It has 1 unit(s). The first unit was commissioned in 1
It is operated by Elektroprivreda Republike Srpske.
Kakanj CHP Power Plant Bosnia and Herzegovina is located at Kakanj, Federation of Bosnia and Herzegovina, Bosnia and Herzegovina. Location coordin
are: Latitude= 44.08988, Longitude= 18.11426. This infrastructure is of TYPE Coal Power Plant with a design capacity of 450 MWe. It has 7 unit(s). The first
was commissioned in 1956 and the last in 1988. It is operated by JP Elektroprivreda BiH.
Tuzla CHP Power Plant Bosnia and Herzegovina is located at Tuzla, Federation of Bosnia and Herzegovina, Bosnia and Herzegovina. Location coordinates
Latitude= 44.5215, Longitude= 18.6056. This infrastructure is of TYPE Coal Power Plant with a design capacity of 730 MWe. It has 6 unit(s). The first unit
commissioned in 1963 and the last in 1978. It is operated by JP Elektroprivreda BiH.
Ugljevik CHP Coal Power Plant Bosnia and Herzegovina is located at Ugljevik, Srpska, Bosnia and Herzegovina. Location coordinates are: Latitude= 44.6
Longitude= 18.9671. This infrastructure is of TYPE Coal Power Plant with a design capacity of 300 MWe. It has 1 unit(s). The first unit was commissioned in 1
It is operated by Elektroprivreda Republike Srpske.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification
and Impact Rating Identification
Number
Number
Super-critical
Coal Lignite Base Load
Thermal
Sub-critical
Coal Brown Base Load
Thermal
Sub-critical
Coal Lignite Base Load
Thermal
Super-critical
Coal Lignite Base Load
Thermal
Configuration
Electric Power
of
Location Grid Connected
Boiler/Turbine/
To
Gen
Kakanj, Federation of Bosnia and Herzegovina, Bosnia and Herzegovina National Grid
Tuzla, Federation of Bosnia and Herzegovina, Bosnia and Herzegovina National Grid
Water
Name of Onsite Storage Withdrawal Onsite Storage Kilometers to
Name/operator
SubStation Source of Coal Capacity Rate at Full Capacity Coal Mines
PPA(years)
Connected To (Tonnes) Power (Tonnes) (Average)
(cum/hour)
Adjacent
opencast lignite 2
mine Gracanica
Central Bosnia
coal basin
Adjacent
opencast and
underground 5
lignite mine
Ugljevik
Water
Withdrawal
Name of Major Type of Cooling Source of Source of
Rate (cum/day) Rate (cum/day) Rate at Full
Mines System Cooling Water Makeup Water
Power
(cum/hour)
Gracanica
Industry,
towns of Tuzla
Commercial and
and Lukavac
Residential
Particulates(PM
Mercury Control SOx Control NOx Control
If other, specify: If other, specify: ) Control Device If other, specify:
Device Device Type Device Type
Type
Unit Information
Date Decommission
Boiler
Unit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
1 32 1956 1997
2 32 1956 1997
3 32 1960 1997
4 32 1960 1997
5 110 1969 Timace
6 110 1977 Timace
7 230 1988 Timace
1 32 1963 2005
2 32 1964 2005
3 100 1966
4 200 1971
5 200 1974
6 230 1978
ST-1
ST-2
ST-3
ST-4
Skoda ST-5 Koncar
Skoda ST-6 Koncar
Skoda ST-7 Koncar 300
ST-1
ST-2
ST-3 100
ST-4 165
ST-5 165
ST-6 165
Elektroprivreda
Elektroprivreda Republike Tehnograd,
100% Government Republike
Srpske Termoelektro
Srpske
JP
JP Elektroprivreda BiH Elektroprivreda
BiH
JP
JP Elektroprivreda BiH Elektroprivreda
BiH
Elektroprivreda
Elektroprivreda Republike
100% 100 Republike
Srpske
Srpske
mation
Regulatory Project
Authority Financed By
Comments
Comment 1
In Dec 2006, CEZ signed an agreement to invest up to 1.5bn in a 51% stake in a new company to build a second unit at Gacko and complete mine upgrade
expansion
Annual generation of electricity about 2300 GWh and Annual coal consumption - about 1.8 million tons
Annual generation about 3100 GWh and coal consumption about 3.3 million tons of coal
http://www.ers.ba/index.php?
option=com_content&view=article&id=7%3Arite-gacko&Itemid=26&lang=ba
http://www.energy-community.org/pls/portal/docs/85835.PDF
http://www.industcards.com/st-coal-bosnia-montenegro.htm
http://www.elektroprivreda.ba/eng/page/tpp-kakanj
http://www.energy-community.org/pls/portal/docs/85835.PDF
http://www.industcards.com/st-coal-bosnia-montenegro.htm
http://en.wikipedia.org/wiki/Thermal_Power_Station_Kakanj,_Catici
http://www.elektroprivreda.ba/eng/page/tpp-tuzlahttp://www.energy-community.org/pls/portal/docs/85835.PDFhttp://uk.reuters.com/article/2
http://www.ers.ba/index.php?
option=com_content&view=article&id=47%3Ariteugljevik&Itemid=78&lang=
ba
http://www.energy-community.org/pls/portal/docs/85835.PDF
http://www.industcards.com/st-coal-bosnia-montenegro.htm
http://en.wikipedia.org/wiki/List_of_power_stations_in_Bosnia-Herzegovina
ID
Notes
Abstract
Pljevlja Coal Power Plant Montenegro is located at Pljevlja, Pljevlja, Montenegro. Location coordinates are: Latitude= 43.3342, Longitude= 19.3271.
infrastructure is of TYPE Coal Power Plant with a design capacity of 218.5 MWe. It has 1 unit(s). The first unit was commissioned in 1982. It is operated
Elektroprivreda Crne Gore AD Niksic (EPCG).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Pljevlja Coal
Power Plant Operating Fully 42685 Euro
Montenegro
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
43.3342 19.3271 Exact 218.5
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Water
Electric Power Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
Grid Connected SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
To Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Elektroprivreda
Crne Gore AD
Niksic (EPCG)
Description
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
Otilovici
Reservoir of 18
3 Million cum 8 km
away on river
Cehotina
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Particulates(PM
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify: ) Control Device
Device Device Type Device Type
Type
Unit Informatio
Date Decommission
Boiler
If other, specify: Unit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
Elektroprivreda
2009 - 2010 Crne Gore AD
Niksic (EPCG)
mation
Regulatory Project
Authority Financed By
Comments
Comment 1
http://www.epcg.co.me/en01_04_02_03.html
http://en.wikipedia.org/wiki/Pljevlja_Power_Station and
http://www.industcards.com/st-coal-bosnia-montenegro.htm
http://www.ifandp.com/article/004802.html
ID
Notes
Abstract
Kosovo A Coal Power Plant Kosovo is located at Pristina, Kosovo. Location coordinates are: Latitude= 42.67675, Longitude= 21.0867. This infrastructure
TYPE Coal Power Plant with a design capacity of 800 MWe. It has 5 unit(s). The first unit was commissioned in 1962 and the last in 1975. It is operated
Korporata Elektroenergjetike e Kosoves (KEK).
Kosovo B Coal Power Plant Kosovo is located at Kastriot, Pristina, Kosovo. Location coordinates are: Latitude= 42.69374, Longitude= 21.05695.
infrastructure is of TYPE Coal Power Plant with a design capacity of 678 MWe. It has 2 unit(s). The first unit was commissioned in 1983 and the last in 1984.
operated by Korporata Elektroenergjetike e Kosoves (KEK).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Loe Efficiency
Kosovo A Coal
Operating and High
Power Plant 42698 Euro
Partially Environmental
Kosovo
Impact
Kosovo B Coal
Power Plant Operating Fully 42699 Euro
Kosovo
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
42.67675 21.0867 Exact 800 230
Thermal
Sub-critical
42.69374 21.05695 Exact 678 500
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Damaged in war
years and
Coal Lignite Base Load Pristina, Kosovo
neglected over
time
Damaged in war
years and Kastriot, Pristina,
Coal Lignite Base Load
neglected until Kosovo
refurbishment
Electric Power Name of
Name/operator
Grid Connected SubStation Source of Coal
PPA(years)
To Connected To
Adjacent Sibovc Lignite Field (Mirash (1958) and Bardh (1969) open-pit
National Grid
mines in Kosovo Basin)
Korporata
Elektroenergjetik Adjacent Sibovc Lignite Field (Mirash (1958) and Bardh (1969) open-pit
National Grid
e e Kosoves mines in Kosovo Basin)
(KEK)
Description
Water
Onsite Storage Withdrawal Onsite Storage Kilometers to
Name of Major Type of Cooling Source of
Capacity Rate at Full Capacity Coal Mines
Mines System Cooling Water
(Tonnes) Power (Tonnes) (Average)
(cum/hour)
3
Water
Withdrawal Cogen Mode:
Source of
Rate (cum/day) Rate (cum/day) Rate at Full Steam Supplied (Tonnes/hour) Description
Makeup Water
Power To
(cum/hour)
Environmental Capital Cost of and/or In US Mercury Control SOx Control
In Year (YYYY) If other, specify:
Issues Plant Dollars Device Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 65 1962-10
2 125 5/20/1965
3 200 4/18/1970
4 200 5/15/1971
5 210 7/8/1975
1 339 9/10/1983
2 339 7/14/1984
Unit Information
Decommission
Boiler Turbine
Date (yyyy-mm- Boiler Manufacturer Turbine Manufacturer Generator Manufacturer
Model/Type Model/Type
dd)
182
182
Past and Future Major Upgrades Owner an
Korporata
Elektroenergjetik
e e Kosoves
(KEK)
Korporata
Elektroenergjetik
Government
e e Kosoves
(KEK)
Comments
Comment 1
Units 1 and 2 are currently decommissioned and the full plant is set to be decommissioned in 2014
http://enrin.grida.no/htmls/kosovo/SoE/energy.htm
http://kek-energy.com/en/gjenerimi.asp
http://www.industcards.com/st-coal-kosovo-macedonia.htm
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://kek-energy.com/en/gjenerimi.asp
http://enrin.grida.no/htmls/kosovo/SoE/energy.htm
http://www.industcards.com/st-coal-kosovo-macedonia.htm
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
ID
Notes
Abstract
Aghios Dimitrios Coal Power Plant Greece is located at near Agios Dimitrios, Kozani, Greece. Location coordinates are: Latitude= 40.3933, Longitude= 21.9
This infrastructure is of TYPE Coal Power Plant with a design capacity of 1595 MWe. It has 5 unit(s). The first unit was commissioned in 1984 and the last in 1
It is operated by Public Power Corp (DEH).
Aminteo (Amyntaio) Coal Power Plant Greece is located at near Amyntaio, Florina, Western Macedonia, Greece. Location coordinates are: Latitude= 40.6
Longitude= 21.6838. This infrastructure is of TYPE Coal Power Plant with a design capacity of 600 MWe. It has 2 unit(s). The first unit was commissioned in 1
and the last in 1988. It is operated by Public Power Corp (DEH).
Florina Coal Power Plant Greece is located at Meliti, Ahlada, Florina, Western Macedonia, Greece. Location coordinates are: Latitude= 40.8114, Longitu
21.6014. This infrastructure is of TYPE Coal Power Plant with a design capacity of 330 MWe. It has 1 unit(s). The first unit was commissioned in 2003.
operated by Public Power Corp (DEH).
Kardia Coal Power Plant Greece is located at Kozani, West Macedonia, Kozani, Greece. Location coordinates are: Latitude= 40.4105, Longitude= 21.7851.
infrastructure is of TYPE Coal Power Plant with a design capacity of 1250 MWe. It has 4 unit(s). The first unit was commissioned in 1975 and the last in 1981.
operated by Public Power Corp (DEH).
Megalopoli Coal Power Plant Greece is located at near Megalopoli, Arcadia, Peloponnese, Greece. Location coordinates are: Latitude= 37.418, Longitu
22.1083. This infrastructure is of TYPE Coal Power Plant with a design capacity of 850 MWe. It has 4 unit(s). The first unit was commissioned in 1970 and the
in 1991. It is operated by Public Power Corp (DEH).
Ptolemais Coal Power Plant Greece is located at Kozani, West Macedonia, Kozani, Greece. Location coordinates are: Latitude= 40.4807, Longitude= 21.7
This infrastructure is of TYPE Coal Power Plant with a design capacity of 550 MWe. It has 4 unit(s). The first unit was commissioned in 1959 and the last in 1
It is operated by Public Power Corp (DEH).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification
and Impact Rating Identification
Number
Number
Sub-critical
Coal lignite Base load
Thermal
Sub-critical
Coal lignite Base load
Thermal
Super-critical
Coal lignite Base load
Thermal
Sub-critical
Coal lignite Base load
Thermal
Ranked as a
Sub-critical Coal lignite and
highly polluting Base load
Thermal bituminous
plant
Sub-critical
Coal lignite Base load
Thermal
Configuration
Electric Power
of
Location Grid Connected
Boiler/Turbine/
To
Gen
Water
Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Public Power
Adjacent Florina Lignite mines
Corp (DEH)
Public Power
Corp (DEH)
Public Power
Adjacent Ptolemais-Amyntaio coal basin
Corp (DEH)
ription
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
Western
Macedonia
11
Lignite Mines
owned by DEH
3.5
Florina Lignite
mines
Megalopoli,
5 Thoknia and Alpheus River
Kyparissia Mines
Ptolemais coal
1
Mine
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Listed as one of
high polluting
power plants
district heating
for 45% of the
Utility Company
town of
Ptolemais
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify:
Device Device Type Device Type
1 300 1984
2 300 1984
Electrostatic Precipitator 3 310 1984
4 310 1984
5 365 1997
1 300 1987
2 300 1988
1 330 10/2/2003
1 300 1975
2 300 1975
Electrostatic Precipitator
3 325 1981
4 325 1981
1 125 1970
2 125 1970
3 300 1991
4 300 1991
1 70 1959 2010-06-18
2 125 1965
3 125 1965
4 300 1973
Unit Information
Boiler Turbine
Boiler Manufacturer Turbine Manufacturer Generator Manufacturer
Model/Type Model/Type
174
174
174
174
174
200
200
Past and Future Major Upgrades Owner an
Public Power
Government Alsaldo (unit 5)
Corp (DEH)
Public Power
Government
Corp (DEH)
Public Power
Government Alstom
Corp (DEH)
Public Power
Corp (DEH)
Public Power
Government
Corp (DEH)
Public Power
Government
Corp (DEH)
Comments
Comment 1
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-coal-greece.htm
http://en.wikipedia.org/wiki/Agios_Dimitrios_Power_Station
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-coal-greece.htm
http://en.wikipedia.org/wiki/Amyntaio_Power_Station
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-coal-greece.htm
http://www.scdhec.gov/environment/baq/docs/SanteeCooper/Comments/psd_
SELC_attachment16.pdf
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-coal-greece.htm
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-coal-greece.htm
http://en.wikipedia.org/wiki/Megalopoli_Power_Plant
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-coal-greece.htm
http://www.turbinetec.com/Download_GE_Layer.html
ID
10
10
11
12
13
Notes
Abstract
Aglos Georgios Thermal Power Plant Greece is located at Keratsini, Attica, Greece. Location coordinates are: Latitude= 37.9539, Longitude= 23.61037.
infrastructure is of TYPE Gas Power Plant with a design capacity of 360 MWe. It has 2 unit(s). The first unit was commissioned in 1968 and the last in 1971.
operated by Public Power Corp (DEH).
Distomo CCGT Heat and Power Plant Greece is located at Agios Nikolaos, Boeotia, Greece. Location coordinates are: Latitude= 38.3585, Longitude= 22.6
This infrastructure is of TYPE Gas Power Plant with a design capacity of 316 MWe. It has 3 unit(s). The first unit was commissioned in 2007 and the last in 2
It is operated by Mytilineos Group.
Heron-I OCGT Power Plant Greece is located at 4 km south of the city of Thiva on old Thiva Elefsina National Road, Boeotia, Greece. Location coordinates
Latitude= 38.2801, Longitude= 23.3264. This infrastructure is of TYPE Gas Power Plant with a design capacity of 148 MWe. It has 3 unit(s). The first unit
commissioned in 2004 and the last in 2004. It is operated by Heron Thermoelectric S.A..
Heron-II CCGT Power Plant Greece is located at 4 km south of the city of Thiva on old Thiva Elefsina National Road, Boeotia, Greece. Location coordin
are: Latitude= 38.2792, Longitude= 23.3299. This infrastructure is of TYPE Gas Power Plant with a design capacity of 435 MWe. It has 2 unit(s). The first unit
commissioned in 2010 and the last in 2010. It is operated by Heron Thermoelectric S.A..
Komotini CCGT Power Plant Greece is located at Komotini, Rodopi, Greece. Location coordinates are: Latitude= 41.0645, Longitude= 25.4895.
infrastructure is of TYPE Gas Power Plant with a design capacity of 485 MWe. It has 3 unit(s). The first unit was commissioned in 2001 and the last in 2002.
operated by Public Power Corp (DEH).
Korinthos Power CCGT Power Plant Greece is located at Motor Oil Refinery, Agioi Theodori, Corinth, Greece. Location coordinates are: Latitude= 37.9
Longitude= 23.0694. This infrastructure is of TYPE Gas Power Plant with a design capacity of 437 MWe. It has 2 unit(s). The first unit was commissioned in 2
and the last in 2011. It is operated by Korinthos Power SA.
Lavario Megalo CCGT Power Plant Greece is located at Lavrio, Attica Region, Greece. Location coordinates are: Latitude= 37.7464, Longitude= 24.065.
infrastructure is of TYPE Gas Power Plant with a design capacity of 570 MWe. It has 4 unit(s). The first unit was commissioned in 1997 and the last in 1999.
operated by Public Power Corp (DEH).
Lavario Thermal Power Plant Greece is located at Lavrio, Attica Region, Greece. Location coordinates are: Latitude= 37.7464, Longitude= 24.067.
infrastructure is of TYPE Gas Power Plant with a design capacity of 450 MWe. It has 2 unit(s). The first unit was commissioned in 1972 and the last in 1973.
operated by Public Power Corp (DEH).
Lavario-V CCGT Power Plant Greece is located at Lavrio, Attica Region, Greece. Location coordinates are: Latitude= 37.745, Longitude= 24.068.
infrastructure is of TYPE Gas Power Plant with a design capacity of 378 MWe. It has 2 unit(s). The first unit was commissioned in 2006 and the last in 2006.
operated by Public Power Corp (DEH).
Megalopolis V CCPP Power Plant Greece is located at Megalopolis, Greece. Location coordinates are: Latitude= 37.41415, Longitude= 22.06626.
infrastructure is of TYPE Gas Power Plant with a design capacity of 811 MWe. It has 3 unit(s). The first unit was commissioned in 2016 and the last in 2016.
operated by Public Power Corporation.
Protergia CCGT Power Plant Greece is located at Agios Nikolaos, Boeotia, Greece. Location coordinates are: Latitude= 38.3585, Longitude= 22.6883.
infrastructure is of TYPE Gas Power Plant with a design capacity of 430 MWe. It has 2 unit(s). The first unit was commissioned in 2011 and the last in 2011.
operated by Mytilineos Group.
Protergia CCGT Power Plant Greece is located at Agios Nikolaos, Boeotia, Greece. Location coordinates are: Latitude= 38.3585, Longitude= 22.6883.
infrastructure is of TYPE Gas Power Plant with a design capacity of 430 MWe. It has 2 unit(s). The first unit was commissioned in 2011 and the last in 2011.
operated by Mytilineos Group.
Thermie Serres CHP Power Plant Greece is located at Serres, Serres, Kentriki Makedonia, Greece. Location coordinates are: Latitude= 41.0634, Longitu
23.5184. This infrastructure is of TYPE Gas Power Plant with a design capacity of 16 MWe. It has 4 unit(s). The first unit was commissioned in 2007 and the la
2007. It is operated by Serres Thermi SA.
Thessaloniki CCGT Power Plant Greece is located at Thessaloniki, Greece. Location coordinates are: Latitude= 40.6872, Longitude= 22.885. This infrastructu
of TYPE Gas Power Plant with a design capacity of 400 MWe. It has 2 unit(s). The first unit was commissioned in 2005 and the last in 2005. It is operate
Elpedison.
Thisvi CCGT Power Plant Greece is located at Industrial Estate, Thisvi, Boeotia, Greece. Location coordinates are: Latitude= 38.2369, Longitude= 22.949.
infrastructure is of TYPE Gas Power Plant with a design capacity of 420 MWe. It has 2 unit(s). The first unit was commissioned in 2010 and the last in 2010.
operated by Elpedison.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Gas
Country
GEO Assigned
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification
and Impact Rating Identification
Number
Number
Light Fuel
Combined Cycle Gas Turbine Natural Gas Base Load
Oil/Diesel
Intermediate/Pea
Sub-critical Thermal Natural Gas Fuel Oil
k Load
Light Fuel
Combined Cycle Gas Turbine Natural Gas Base Load
Oil/Diesel
Light Fuel
Combined Cycle Gas Turbine Natural Gas Base Load
Oil/Diesel
Description
Electric Power
Configuration of
Location Grid Connected
Boiler/Turbine/Gen
To
Agios Nikolaos, Boeotia, Greece One 2+2+1 CCGT Block National Grid
4 km south of the city of Thiva on old Thiva Elefsina National Road, Boeotia,
National Grid
Greece
4 km south of the city of Thiva on old Thiva Elefsina National Road, Boeotia,
National Grid
Greece
Lavrio, Attica Region, Greece One 3+3+1 CCGT Block National Grid
Serres, Serres, Kentriki Makedonia, Greece four TCG2032V16 gas-engines Regional grid
Industrial Estate, Thisvi, Boeotia, Greece One 1+1+1 CCGT block National Grid
Description
Water
Name of Withdrawal Cogen Mode:
Name/operator (Tonnes/hour)
SubStation Source of Fuel Source of Water Rate at Full Steam Supplied
PPA(years) Description
Connected To Power To
(cum/hour)
Public Power
Corp (DEH)
Aluminium of
Seawater Industry
Greece (AOG)
Seawater
Public Power
Corp (DEH)
Seawater
Seawater
Public Power
Corp (DEH)
Water Injection
42000000 2007
1 160 1968
2 200 1971
1 105 2007-06
2 105 2007-06
3 106 2007-06
1 49.3 2004
2 49.3 2004
3 49.3 2004
1 290 2010
2 145 2010
1 165 2001
2 165 2001
3 160 2002
1 290 2011
2 147 2011
1 127 1997
2 127 1997
3 127 1997
4 190 1999
1 150 1972
2 300 1973
1 256 2006-04
2 128 2006-04
1 270 2016
2 270 2016
3 271 2016
1 285 2011
2 145 2011
1 4 2007
2 4 2007
3 4 200
4 4 2007
1 254 2005-12
2 146 2005-12
1 275 9/12/2010
2 145 9/12/2010
Unit Information
Generator
Turbine Manufacturer Turbine Model/Type Generator Model/Type
Manufacturer
Ansaldo Ansaldo
GE GT-1 9001E
GE GT-2 9001E
ST-1
GE GT-2 LM6000 P GE
GE GT-1 PG9371FB GE
GE GT-1 9001FB GE
GE ST-1 GE
AEG Alstom
AEG Alstom
GE GT-1 109FA GE
GE ST-1 GE
GE GT-1 9001FB GE
GE ST-1 GE
Ansaldo Italy ST-1 RHTCSF 43 Ansaldo Italy WY21Z-092 air cooled generator
Environmental Issues
Babcock Power
Limited
Alstom
Alstom
38%
38%
38%
Doosan Heavy
Industries
Ansaldo Italy
Ansaldo Italy
57%
Vereinigte
Kesselwerke
Stein
Alstom
NEM
NEM
CMI
Nooter Erickson
Past and Future Major Upgrades
Public Power
Public Power Corp (DEH) Government
Corp (DEH)
65%
Mytilineos Holdings S.A.
Korinthos Power
Private Metka
SA
Motor Oil (Hellas) Corinth Refineries S.A.
65%
Public Power
Public Power Corp (DEH) Government Alstom, Metka
Corp (DEH)
Public Power
Public Power Corp (DEH) Government
Corp (DEH)
Metka,
Empresarios
Public Power
Public Power Corp (DEH) Government Agrupados, Expo
Corp (DEH)
Power Systems
Ltd
Serres Thermi
Serres Thermi SA
SA
Helcor
Hellenic S.A.
Petroleum 1.5%
37,9%
Edison Spa 37,9%
IPP Alsaldo, Aktor Elpedison
Ellaktor HE&D 22,7%
Helcor S.A. 1,5%
Comments
Project
Comment 1
Financed By
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-other-greece.htm
http://www.mytilineos.gr/site/en-US/home/groups_activities/epc_projects/default.aspx?
tab=metka
http://www.industcards.com/cc-greece.htm
http://www.heron.gr/index.php/en/2008-12-11-10-16-35/2008-12-11-10-19-26/-1
http://www.industcards.com/cc-greece.htm
http://www.heron.gr/index.php/en/2008-12-11-10-16-35/2008-12-11-10-19-26/-2
http://www.industcards.com/cc-greece.htm
http://www.empresariosagrupados.es/projects/thiva-greece/?lang=en
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/cc-greece.htm
http://www.mytilineos.gr/uploads/nea/2009/metka_27.04.2009_korinthospower_eng.pdf
http://www.industcards.com/cc-greece.htm
http://haipp.gr/en/content/our-members
http://www.empresariosagrupados.es/projects/central-termica-de-ciclo-combinado-
korinthos/
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/cc-greece.htm
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-other-greece.htm
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/cc-greece.htm
http://www.empresariosagrupados.es/projects/lavrion-v-greece/?lang=en
http://www.empresariosagrupados.es/projects/megalopolis-greece/?lang=en
http://www.metka.com/en/activity-sectors/projects/ahs-megalopolhs-monada-v-
syndyasmenou-kyklou-811-mw
http://www.mytilineos.gr/site/en-US/home/groups_activities/epc_projects/default.aspx?
tab=metka
http://www.industcards.com/cc-greece.htm
http://www.mytilineos.gr/site/en-US/home/groups_activities/epc_projects/default.aspx?
tab=metka
http://www.industcards.com/cc-greece.htm
http://www.industcards.com/ic-greece.htm
http://thermieserres.gr/
http://www.elpedison.gr/en/the-group/business-activities/energy-production/the-power-
plants/ and http://www.elpedison.gr/en/the-group/thegroup-structure/
http://www.industcards.com/cc-greece.htm
http://www.elpedison.gr/en/the-group/business-activities/energy-production/the-power-
plants/ and http://www.elpedison.gr/en/the-group/thegroup-structure/
http://www.industcards.com/cc-greece.htm
http://www.iene.gr/energyB2B/articlefiles/hlektrismos/tzouros.pdf
ID
Notes
Abstract
Aliveri Thermal Power Plant Greece is located at Aliveri, Euboea, Greece. Location coordinates are: Latitude= 38.3896, Longitude= 24.0524. This infrastructu
of TYPE Oil Power Plant with a design capacity of 380 MWe. It has 4 unit(s). The first unit was commissioned in 1953 and the last in 1969. It is operated by Pu
Power Corp (DEH).
Atherinolakkos IC Power Plant Greece is located at Atherinolakkos, Lasithi, Crete, Greece. Location coordinates are: Latitude= 35.0038, Longitude= 26.1397.
infrastructure is of TYPE Oil Power Plant with a design capacity of 102 MWe. It has 2 unit(s). The first unit was commissioned in 2004 and the last in 2004.
operated by Public Power Corp (DEH).
Chania Power Plant Crete Greece is located at Khania, Greece. Location coordinates are: Latitude= 35.488, Longitude= 24.0384. This infrastructure is of T
Oil Power Plant with a design capacity of 118 MWe. It has 6 unit(s). The first unit was commissioned in 1969 and the last in 1998. It is operated by DEI Pu
Power Corporation.
Chios Extension Power Plant Greece is located at Chios (Khios) Island, Greece. Location coordinates are: Latitude= 38.331, Longitude= 26.154.
infrastructure is of TYPE Oil Power Plant with a design capacity of 14.8 MWe. It has 1 unit(s). The first unit was commissioned in 2008. It is operated by Pu
Power Corp (DEH).
Linoperamata Power Plant Crete Greece is located at Linoperamata, Crete. Location coordinates are: Latitude= 35.34, Longitude= 25.0523. This infrastructu
of TYPE Oil Power Plant with a design capacity of 193 MWe. . It is operated by DEI Public Power Corporation.
Soroni Rodos Power Plant Greece is located at Soroni, Rodos. Location coordinates are: Latitude= 36.37887, Longitude= 28.01857. This infrastructure
TYPE Oil Power Plant with a design capacity of 84 MWe. and the last in . It is operated by DEI Public Power Corporation.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Oil
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Aliveri Thermal
Power Plant Operating Fully 42776 Euro
Greece
Atherinolakkos
IC Power Plant Operating Fully 42778 Euro
Greece
High Efficiency
Chania Power
and Medium Worth
Plant Crete Operating Fully 45687 Euro
Enviromental Duplicating
Greece
Impact
Chios Extension
Power Plant Operating Fully 42779 Euro
Greece
Medium
Linoperamata efficiency and
Power Plant Operating Fully Medium 45686 Euro
Crete Greece Enviromental
Impact
High Efficiency
Soroni Rodos
and Medium
Power Plant Operating Fully 45688 Euro
Enviromental
Greece
Impact
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
38,3896 24.0524 Exact 380
Steam Turbine
Aliveri, Euboea,
Heavy Fuel Oil Peaking Load
Greece
Atherinolakkos,
2 12K90M-C
Heavy Fuel Oil Lasithi, Crete,
engines
Greece
Diesel Oil
Chios (Khios)
Heavy Oil Base Load One IC engine
Island, Greece
Base/Intermediat Linoperamata,
Heavy Fuel Oil
e Load Crete
Base/Intermediat
Heavy Fuel Oil Soroni, Rodos
e Load
Description
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
Public Power
National Grid
Corp (DEH)
Regional Grid
DEI Public
Regional Grid Power
Corporation
Regional Grid
DEI Public
Regional Grid Power
Corporation
DEI Public
Regional Grid Power
Corporation
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: Unit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 40 1953
2 40 1953
3 150 1969
4 150 1969
1 51 2004
2 51 2004
1 16 1969
2 45 1992
3 45 1992
4 45 1992
5 59 5/1/1998
6 59 8/1/1998
1 14.8 2008
1 28
2 28
3 28
Unit Information
AEG
AEG
Alsthom
Alsthom
HSD Engine Co
nvironmental Issues Past and Future Major Upgrades
Comment 1
http://www.dei.gr/Default.aspx?id=146&nt=123&lang=2
http://www.industcards.com/st-other-greece.htm
http://www.industcards.com/ic-greece.htm
Turbinetec
http://www.industcards.com/ic-greece.htm
ID
Notes
Abstract
Kostolac-A Coal Power Plant Serbia is located at Kostolac, Viminacium, Branicevo, Serbia. Location coordinates are: Latitude= 44.7229, Longitude= 21.1
This infrastructure is of TYPE Coal Power Plant with a design capacity of 310 MWe. It has 2 unit(s). The first unit was commissioned in 1967 and the last in 1
It is operated by Elektroprivreda Srbije (EPS).
Kostolac-B Coal Power Plant Serbia is located at Kostolac, Viminacium, Branicevo, Serbia. Location coordinates are: Latitude= 44.7307, Longitude= 21.2
This infrastructure is of TYPE Coal Power Plant with a design capacity of 697 MWe. It has 2 unit(s). The first unit was commissioned in 1987 and the last in 1
It is operated by Elektroprivreda Srbije (EPS).
Morava Coal Power Plant Serbia is located at Svilajnac, Pomoravlje, Serbia. Location coordinates are: Latitude= 44.2248, Longitude= 21.1627. This infrastruc
is of TYPE Coal Power Plant with a design capacity of 115 MWe. It has 1 unit(s). The first unit was commissioned in 1969. It is operated by Elektroprivreda S
(EPS).
Nikola Tesla A Coal Power Plant Serbia is located at Obrenovac, Belgrade, Serbia. Location coordinates are: Latitude= 44.6707, Longitude= 20.1592.
infrastructure is of TYPE Coal Power Plant with a design capacity of 1564 MWe. It has 6 unit(s). The first unit was commissioned in 1970 and the last in 1979.
operated by Elektroprivreda Srbije (EPS).
Nikola Tesla B Coal Power Plant Serbia is located at Vorbis, Ushce, Belgrade, Serbia. Location coordinates are: Latitude= 44.6553, Longitude= 20.0052.
infrastructure is of TYPE Coal Power Plant with a design capacity of 1240 MWe. It has 2 unit(s). The first unit was commissioned in 1983 and the last in 1985.
operated by Elektroprivreda Srbije (EPS).
TE Kolubara Coal Power Plant Serbia is located at Veliki Crljeni, Belgrade, Serbia. Location coordinates are: Latitude= 44.4806, Longitude= 20.2934.
infrastructure is of TYPE Coal Power Plant with a design capacity of 270 MWe. It has 5 unit(s). The first unit was commissioned in 1956 and the last in 1979.
operated by Elektroprivreda Srbije (EPS).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned
Plant Efficiency and Plant Overall Assigned
Name Status of Plant Identification
Impact Rating Identification
Number
Number
Kostolac,
Sub-critical Viminacium,
Coal Lignite Base Load
Thermal Branicevo,
Serbia
Kostolac,
Sub-critical Viminacium,
Coal Lignite Base Load
Thermal Branicevo,
Serbia
Svilajnac,
Sub-critical
Coal Lignite Base Load Pomoravlje,
Thermal
Serbia
Sub-critical Obrenovac,
Coal Lignite Base Load
Thermal Belgrade, Serbia
Elektrostok
National Grid
Beagrad
Kolubara lignite
National Grid 110 kV
mines
Description
Drmno,
Once through
5 Cirikovac, Danube River Danube River
wet cooling
Klenovnik mines
Drmno,
Once through
1 Cirikovac, Danube River Danube River
wet cooling
Klenovnik mines
Once through
30 Kolubara Sava River Sava River
wet cooling
Once through
30 Kolubara Sava River Sava River
wet cooling
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of
Rate (cum/day) Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant
Power To
(cum/hour)
Industry,
cities of Kostolac
Commercial and
and Pozarevac
Residential
Heat for
Obrenovac
and/or In US Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify:
Dollars Device Device Type Device Type
U
1 100 1967
2 210 1980
1 32 10/20/1956 Steinmuller
2 32 1957 Steinmuller
3 64 1961 Steinmuller
4 32 1961 Steinmuller
5 110 1979 Steinmuller
Unit Information
Boiler
Turbine Manufacturer Turbine Model/Type Generator Manufacturer Generator Model/Type
Model/Type
295
295
150
150
220
220
220
220
ast and Future Major Upgrades Owner and Operator Informati
Type of
Cost Year Owner 1 % Share
Ownership
Elektroprivreda Srbije
Government
(EPS)
Elektroprivreda Srbije
Government
(EPS)
Elektroprivreda Srbije
Government
(EPS)
Elektroprivreda Srbije
(EPS)
Elektroprivreda Srbije
G
(EPS)
Elektroprivreda Srbije
(EPS)
and Operator Information
Elektroprivreda
Srbije (EPS)
Elektroprivreda
Elektroproject
Srbije (EPS)
Elektroprivreda
Elektroproject
Srbije (EPS)
Elektroprivreda
Srbije (EPS)
Elektroprivreda
Elektroproject
Srbije (EPS)
Elektroprivreda
Srbije (EPS)
Comments
Comment 1
An agreement has been signed in 2010 for the redevelopment of the Kostolac Power Plant
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://en.wikipedia.org/wiki/TPP_Nikola_Tesla
http://www.industcards.com/st-coal-serbia.htm
http://www.sourcewatch.org/index.php/TPP_Kostolac_Power_Station
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://en.wikipedia.org/wiki/TPP_Nikola_Tesla
http://www.industcards.com/st-coal-serbia.htm
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://en.wikipedia.org/wiki/TPP_Nikola_Tesla
http://www.industcards.com/st-coal-serbia.htm
http://www.eps.rs/Pages/Article.aspx?lista=Sitemap&id=85
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://en.wikipedia.org/wiki/TPP_Nikola_Tesla
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://en.wikipedia.org/wiki/TPP_Nikola_Tesla
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.sourcewatch.org/index.php/Serbia_and_coal
http://www.industcards.com/st-coal-serbia.htm
ID
Notes
Abstract
Novi Sad CHP Power Plant Serbia is located at Novi Sad, South Backa, Vojvodina, Serbia. Location coordinates are: Latitude= 45.2681, Longitude= 19.8
This infrastructure is of TYPE Oil Power Plant with a design capacity of 230 MWe. It has 2 unit(s). The first unit was commissioned in 1981 and the last in 198
is operated by Elektroprivreda Srbije (EPS).
Sremska Mitrovica CHP Power Plant Serbia is located at Sremska Mitrovica, Srem, Serbia. Location coordinates are: Latitude= 44.9611, Longitude= 19.6
This infrastructure is of TYPE Oil Power Plant with a design capacity of 45 MWe. It has 3 unit(s). The first unit was commissioned in 1963 and the last in 1979.
operated by Elektroprivreda Srbije (EPS).
Zrenjanin CHP Power Plant Serbia is located at Zrenjanin, Central Banat, Vojvodina, Serbia. Location coordinates are: Latitude= 45.3572, Longitude= 20.4
This infrastructure is of TYPE Oil Power Plant with a design capacity of 120 MWe. It has 1 unit(s). The first unit was commissioned in 1989. It is operated
Elektroprivreda Srbije (EPS).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Oil
Country
Plant Efficiency Plant Overall Assigned
Name Status of Plant
and Impact Rating Identification
Number
Cogeneration
Power and Heat Fuel Oil Heavy Natural gas
Steam Turbine
Cogeneration
Power and Heat Natural gas Heavy Fuel Oul Base Load
Steam Turbine
Cogeneration
140 Power and Heat Natural gas Heavy Fuel Oul Base Load
Steam Turbine
Description
Configuration
Electric Power Name of
of Name/operator
Location Grid Connected SubStation Source of Oil Source of Water
Boiler/Turbine/ PPA(years)
To Connected To
Gen
Sremska
Elektrostok
Mitrovica, Srem, National grid
Beagrad
Serbia
Zrenjanin,
Fuel oil and
Central Banat, Elektrostok
National grid natural gas by Begej River
Vojvodina, Beagrad
pipeline
Serbia
Water
Withdrawal Cogen Mode:
(Tonnes/hour) Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied In Year (YYYY)
Description Issues Plant Dollars
Power To
(cum/hour)
Industry,
Commercial and
Residential
Industry,
Commercial and Zrenjanin
Residential
Particulates(PM
SOx Control NOx Control
If other, specify: If other, specify: ) Control Device If other, specify: Unit #
Device Type Device Type
Type
1
Unit Information
R. Koncar
R. Koncar
PT 120/51-10,885-0,63-014 R. Koncar
nvironmental Issues Past and Future Major Upgrades
Elektroprivreda Srbije
Elektroprivreda Srbije (EPS) Government
(EPS)
Elektroprivreda Srbije
Elektroprivreda Srbije (EPS) Government
(EPS)
Elektroprivreda Srbije
Elektroprivreda Srbije (EPS) Government
(EPS)
Comments
Project
Comment 1
Financed By
References
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://www.industcards.com/st-other-eur-s.htm
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://panonske.rs/lat/branches/tpp-hp-sremska-mitrovica/
http://www.eps.rs/Eng/Article.aspx?lista=Sitemap&id=70
http://www.reneuer.com/upload/RENEUER-Legislation-059.pdf
http://www.panonske.rs/en/branches/tpp-hp-zrenjanin/
ID
Notes
Abstract
Bobov Dol Coal Power Plant Bulgaria is located at S of Bobov Dol, Kyustendil, Bulgaria. Location coordinates are: Latitude= 42.285556, Longitude= 23.032
This infrastructure is of TYPE Coal Power Plant with a design capacity of 630 MWe. It has 3 unit(s). The first unit was commissioned in 1973 and the last in 19
Maritsa 3 Coal Power Plant Bulgaria is located at Dimitrovgrad, Haskovo, Bulgaria. Location coordinates are: Latitude= 42.0524, Longitude= 25.62377.
infrastructure is of TYPE Coal Power Plant with a design capacity of 120 MWe. It has 1 unit(s). The first unit was commissioned in 1971.
Maritsa Iztok-1 Coal Power Plant Bulgaria is located at Galabovo, Stara Zagora, Bulgaria. Location coordinates are: Latitude= 42.1573, Longitude= 25.9
This infrastructure is of TYPE Coal Power Plant with a design capacity of 670 MWe. It has 2 unit(s). The first unit was commissioned in 2011 and the last in 2
It is operated by Natsionalna Elektricheska Kompania EAD (NEK).
Maritsa Iztok-2 Coal Power Plant Bulgaria is located at Radetski, Stara Zagora, Bulgaria. Location coordinates are: Latitude= 42.255, Longitude= 26.135.
infrastructure is of TYPE Coal Power Plant with a design capacity of 1450 MWe. It has 8 unit(s). The first unit was commissioned in 1966 and the last in 1995.
operated by Maritsa East-2 TPP plc.
Maritsa Iztok-3 Coal Power Plant Bulgaria is located at Galabovo, Stara Zagora, Bulgaria. Location coordinates are: Latitude= 42.1444, Longitude= 26.0033.
infrastructure is of TYPE Coal Power Plant with a design capacity of 840 MWe. and the last in . It is operated by Energiina Kompaniya Maritsa Iztok 3 AD.
Varna Coal Power Plant Bulgaria is located at Ezerovo, Varna, Bulgaria. Location coordinates are: Latitude= 43.196, Longitude= 27.7644. This infrastructure
TYPE Coal Power Plant with a design capacity of 1260 MWe. It has 6 unit(s). The first unit was commissioned in 1968 and the last in 1979. It is operated by C
Czech Republic.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Coal
Country
GEO Assigned
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification
and Impact Rating Identification
Number
Number
Sub-critical
Coal Base Load
Thermal
Sub-critical
Coal Fuel Oil Base Load
Thermal
Sub-critical
Lignite Base Load
Thermal
Super-critical
Lignite Base Load
Thermal
Sub-critical
Lignite Base Load
Thermal
Sub-critical
Anthracite coal Base Load
Thermal
Configuration
Electric Power
of
Location Grid Connected
Boiler/Turbine/
To
Gen
Name of
Name/operator PPA(years) SubStation Source of Coal
Connected To
Water
Onsite Storage Withdrawal Onsite Storage Kilometers to
Name of Major Type of Cooling Source of
Capacity Rate at Full Capacity Coal Mines
Mines System Cooling Water
(Tonnes) Power (Tonnes) (Average)
(cum/hour)
Maritsa River
Rozov Kladenets
Reservoir
Ovcharista Lake
Lake Varna
Water
Withdrawal Cogen Mode:
Source of
Rate (cum/day) Rate (cum/day) Rate at Full Steam Supplied (Tonnes/hour) Description
Makeup Water
Power To
(cum/hour)
Lake Varna
Environmental Capital Cost of and/or In US Mercury Control SOx Control
In Year (YYYY) If other, specify:
Issues Plant Dollars Device Device Type
1 210
2 210
3 210
1 150
2 150
3 150
4 150
Electrostatic Precipitator dust removal is 96%
5 210
6 230
7 215
8 215
1 210
2 210
3 210
4 210
1 210
2 210
3 210
4 210
5 210
6 210
Unit Information
Date Decommission
Boiler
Commissioned Date (yyyy-mm- Boiler Manufacturer Turbine Manufacturer
Model/Type
(yyyy-mm-dd) dd)
Alstom
Alstom
Maritsa East-2
of Bulgarian Energy Holding EAD Government
TPP plc
Comment 1
A firm controlled by Hristo Kovachk acquired the plant in 2008. Plans to build two new units
New plant is equipped with ALSTOM advanced lignite-firing pulverised coal boilers using state-of-the-art low NOx burners
Mitsui, contracted in a consortium with Toshiba to rehabilitate the four generating units 1-4 of Maritsa Iztok 2 thermal power plant largely funded by Japan Ban
International Cooperation
construction of FGDs for units 5 and 6 at total budget of 86 mln. Euro. The Italian-Chinese consortium Idreco-Insigma selected
Rehab/Replacement by Toshiba of turbines and generators of units 1, 3, 4, the capacities increased from 150 MW to 177 MW. A new generator of unit
nominal capacity 165 MW was put into operation. Turbine of unite 6 was increased from 210 to 230 MW
Enel is planning to invest in a new 700-800 MW coal-fired power plant next to the existing Maritsa Iztok-3 plant. Expected cost 900 million
Enel has a commitment to ehabilitate and upgrade and to acquire de-sulphurising sections. The 580 million euro project is financed by ten banks in Eu
including four in Bulgaria.
2 CCGT units of 440MW are being planned with possible schedule for 2013
References
http://en.wikipedia.org/wiki/Bobov_Dol_Power_Plant and
http://www.industcards.com/st-coal-bulgaria.htm
http://tec-marica3.com/?act=show_page&category_id=4
http://tec-marica3.com/?act=show_page&category_id=1 and http://tec-
marica3.com/?act=show_page&category_id=2
http://en.wikipedia.org/wiki/Maritsa_3_Power_Plant
http://tec-marica3.com/modules/download.php?file_id=89
http://en.wikipedia.org/wiki/Maritsa_Iztok_Complex
http://www.alstom.com/power/news-and-events/press-releases/ALSTOM-to-supply-670-
MW-Clean-Power-Station-in-Bulgaria-20060925/
http://www.tpp2.com/userfiles/File/MI_otchet_za_net.pdf
http://www.industcards.com/st-coal-bulgaria.htm and http://www.tpp2.com/page/about-
us.html
http://sofiaecho.com/2005/04/10/645111_clash-on-maritsa-iztok-2
http://en.wikipedia.org/wiki/Maritsa_Iztok_Complex
http://www.cez.bg/bg/za-nas/kompaniite-v-balgariya/tets-varna.html
http://en.wikipedia.org/wiki/Varna_Power_Plant
http://www.industcards.com/st-coal-bulgaria.htm
http://www.cez.cz/en/investors/financial-reports/annual-reports.html
ID
6
6
10
Notes
Abstract
CET Bacau CHPP Romania is located at Chimiei nr. 6, 600286, Bacau, Romania. Location coordinates are: Latitude= 46.531, Longitude= 26.938. T
infrastructure is of TYPE Coal Power Plant with a design capacity of 74.25 MWe. It has 2 unit(s). The first unit was commissioned in 1998 and the last in 2
operated by SC CET SA Bacau.
CET Brasov CHPP Romania is located at Timis Triaj nr.6, 500240, Brasov, Romania. Location coordinates are: Latitude= 45.6623, Longitude= 25.646
infrastructure is of TYPE Coal Power Plant with a design capacity of 100 MWe. It has 2 unit(s). The first unit was commissioned in 1990 and the last in 19
operated by SC CENTRALA ELECTRICA DE TERMOFICARE BRASOV SA.
CET Govora Coal CHPP Romania is located at INDUSTRIILOR, NR.1, 240050, RAMNICU VALCEA, Romania. Location coordinates are: Latitude= 45
Longitude= 24.29. This infrastructure is of TYPE Coal Power Plant with a design capacity of 200 MWe. It has 4 unit(s). The first unit was commissioned
and the last in 1987. It is operated by CET GOVORA SA.
Craiova II Coal Power Station Romania is located at Craiova, Dolj, Romania. Location coordinates are: Latitude= 44.345, Longitude= 23.8156. This infras
is of TYPE Coal Power Plant with a design capacity of 300 MWe. It has 2 unit(s). The first unit was commissioned in 1987 and the last in 1988. It is oper
SC Craiova Energetic Complex SA.
Isalnita Coal Power Plant Romania is located at Isalnita, Dolj County, Romania. Location coordinates are: Latitude= 44.3886, Longitude= 23.718. T
infrastructure is of TYPE Coal Power Plant with a design capacity of 630 MWe. and the last in 1988. It is operated by SC Complexul Energetic (CE) Crai
Mintia-Deva Power Station Romania is located at 7 km from Deva, Hunedoara, Romania. Location coordinates are: Latitude= 45.9134, Longitude= 22.82
infrastructure is of TYPE Coal Power Plant with a design capacity of 1285 MWe. It has 6 unit(s). The first unit was commissioned in 1970 and the last in 1
operated by Electrocentrale Deva SA.
Mintia-Deva Power Station Romania is located at 7 km from Deva, Hunedoara, Romania. Location coordinates are: Latitude= 45.9134, Longitude= 22.82
infrastructure is of TYPE Coal Power Plant with a design capacity of 1285 MWe. It has 6 unit(s). The first unit was commissioned in 1970 and the last in 1
operated by Electrocentrale Deva SA.
Paroseni CHPP Coal Power Station Romania is located at Nr. 20, 336200, Jiu Paroseni, Hunedoara, Romania. Location coordinates are: Latitude= 45.
Longitude= 23.261. This infrastructure is of TYPE Coal Power Plant with a design capacity of 300 MWe. It has 4 unit(s). The first unit was commissioned
and the last in 1964. It is operated by SC TERMOELECTRICA SA BUCURESTI.
Romag-Termo CHPP Romania is located at Calea Tg.Jiului, km5, 227297, Drobeta Turnu Severin, Romania. Location coordinates are: Latitude= 44.6
Longitude= 22.6883. This infrastructure is of TYPE Coal Power Plant with a design capacity of 225 MWe. It has 5 unit(s). The first unit was commissioned
and the last in 1988. It is operated by RAAN - Regia Autonoma Pentru Activitati Nucleare.
Rovinari Coal Power Station Romania is located at Rovinari, Near Targu Jiu, Gorj, Romania. Location coordinates are: Latitude= 44.9068, Longitude= 2
This infrastructure is of TYPE Coal Power Plant with a design capacity of 1320 MWe. It has 6 unit(s). The first unit was commissioned in 1972 and the last
It is operated by Complexul Energy Rovinari S.A..
Turceni Coal Power Station Romania is located at Turceni, half way between the cities of Craiova and Targu Jiu, Gorj, Romania. Location coordinates
Latitude= 44.6698, Longitude= 23.4077. This infrastructure is of TYPE Coal Power Plant with a design capacity of 2310 MWe. It has 7 unit(s). The first u
commissioned in 1978 and the last in 1987. It is operated by Complexul Energy Turceni S.A..
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pounds, MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
CET Bacau
Operating fully 41141 New Leu
CHPP Romania
CET Brasov
Operating fully 41142 New Leu
CHPP Romania
CET Govora
Coal CHPP Operating fully 41143 New Leu
Romania
Craiova II Coal
Power Station Operating fully 40971 New Leu
Romania
Isalnita Coal
Power Plant Operating fully 40970 New Leu
Romania
Mintia-Deva
Power Station Operating fully 40969 New Leu
Romania
Mintia-Deva
Power Station Operating fully 40969 New Leu
Romania
Paroseni CHPP
Coal Power Operating fully 40988 New Leu
Station Romania
Romag-Termo
Operating fully 41144 New Leu
CHPP Romania
Rovinari Coal
Power Station Operating fully 40968 New Leu
Romania
Turceni Coal
Power Station Operating fully 40967 New Leu
Romania
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
46,531 26,938 Exact 74.25
Thermal
Sub-critical
45,662 25,646 Exact 100
Thermal
Sub-critical
45.04 24.29 Exact 200
Thermal
Sub-critical
44,345 23,816 Exact 300
Thermal
Sub-critical
44,389 23,718 Exact 630
Thermal
Sub-critical
45,913 22,825 Exact 1285
Thermal
Sub-critical
45,913 22,825 Exact 1285
Thermal
Sub-critical
45,365 23,261 Exact 300
Thermal
Sub-critical
44,675 22,688 Exact 225
Thermal
Sub-critical
44,907 23,138 Exact 1320
Thermal
Sub-critical
44,670 23,408 Exact 2310 1605
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Chimiei nr. 6,
Lignite Natural Gas 600286, Bacau,
Romania
INDUSTRIILOR,
five boilers of
NR.1, 240050,
420 t/h and four
Lignite Natural Gas RAMNICU
turbines of 50
VALCEA,
Mwe
Romania
Craiova, Dolj,
Lignite Natural Gas
Romania
Isalnita, Dolj
Lignite Natural Gas
County, Romania
7 km from Deva,
Sub-bituminous Natural Gas Hunedoara,
Romania
7 km from Deva,
Sub-bituminous Natural Gas Hunedoara,
Romania
Calea Tg.Jiului,
km5, 227297,
Lignite Fuel Oil
Drobeta Turnu
Severin, Romania
Rovinari, Near
Lignite Natural Gas Targu Jiu, Gorj,
Romania
Water
Electric Power Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
Grid Connected SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
To Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Municipal grid
National Grid
Prigoria open-pit
National Grid mining and
SNLO
Valea Jiului
basins with
National Grid Minita
15392 kJ/kg by
Railways
Valea Jiului
basins with
National Grid Minita
15392 kJ/kg by
Railways
110 kV CET
National Grid
Drobeta
Adjacent Coal
Mines
Associated Jilt
four 400kV lines Openpit coal
connecting to mine and
Tantareni Tehomir
Substation underground
mine
Description
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
Olt River
River Jiu
River Mures
River Mures
River Jiu
River Jiu
River Jiu
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Particulates(PM
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify: ) Control Device
Device Device Type Device Type
Type
Unit Informat
Date Decommission
Boiler
If other, specify: Unit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
1 60 1998 Vulcan
2 14.25 2008
1 50 1990 ICAL
2 50 1995 ICPET
1 50
2 50
3 50
4 55
5 100
6 100
1 50 1955
2 50 1957
3 50 1959
4 150 1964
1 50 1986 ICPET
2 50 1986 ICPET
3 50 1986 ICPET
4 50 1986 ICPET
5 25 1988 ICPET
ICPET-Generatoare Abur
3 330 1976
S.A.
ICPET-Generatoare Abur
4 330 1977
S.A.
ICPET-Generatoare Abur
5 330 1977
S.A.
ICPET-Generatoare Abur
6 330 1979
S.A.
TURBOMACH-
GT-1 T 130 LEROY SOMER
SWITZERLAND
IMBG IMBG
IMBG IMBG
Rateau Alstom
Rateau Alstom
K-200-130 TVV-200-2
K-200-131 TVV-200-2
K-200-132 TVV-200-2
K-200-133 TVV-200-2
K-200-134 TVV-200-2
K-200-135 TVV-200-2
IMBG SC 25 IMBG
Skoda
Skoda
Rateau-Schneider Alstom
Rateau-Schneider Alstom
Rateau-Schneider Alstom
Rateau-Schneider Alstom
Rateau-Schneider Alstom
Rateau-Schneider Alstom
Rateau-Schneider Alstom
Environmental Issues Past and Future Major Upgrades
Government SC CET SA
City of Bacau
Municipal Bacau
SC CENTRALA
Government ELECTRICA DE
City of Brasov Alsando
Municipal TERMOFICARE
BRASOV SA
CET GOVORA
S.C. CET GOVORA S.A. IPP
SA
SC Craiova
Thermoelectrica S.A. Government Energetic
Complex SA
Government
SC Complexul
(Ministry of
Thermoelectrica S.A. Energetic (CE)
Economy and
Craiova SA
Commerce)
Electrocentrale
Thermoelectrica S.A. Government
Deva SA
Electrocentrale
Thermoelectrica S.A. Government
Deva SA
Government SC
(Ministry of TERMOELECTR
Thermoelectrica S.A.
Economy and ICA SA
Commerce) BUCURESTI
RAAN - Regia
RAAN - Regia Autonoma Autonoma
Government
Pentru Activitati Nucleare Pentru Activitati
Nucleare
Complexul
SC Termoelectrica S.A. Government Energy Rovinari
S.A.
Complexul
SC Termoelectrica S.A. Government Energy Turceni
S.A.
mation
Regulatory Project
Authority Financed By
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
AGENTIA
NATIONALA
PENTRU
PROTECTIA
MEDIULUI
Comments
Comment 1
Direct access to railroad and storing abilities for 500000 tonnes coal
Units 1-6 have been decommisioned. Plans for adding a 500 MW supercritical unit
A consortium of Alstom, Sumitomo and IHI Corporation is commissioned to upgrade the 315 MW group to 345 MW each at a total cost of US$ 315 m
This plant equilibrates power balance in central and western areas of the country and is an important interconnection point with West European power
UCTE
This plant equilibrates power balance in central and western areas of the country and is an important interconnection point with West European power
UCTE
Unit 4 approved to get a FGD unit in Nov 2009. All 4 units have russian BTG
Plans to add a new 500 MW supercritical unit at a total cost of US$ 600 million. This unit will replace the decommisioned units 1 and 2
fitting of several sulphur filters at the existing power units at a total cost of US$ 250 million
Collaboration with ABB-Babcock to modernize units 4 and 5 and add FGD units
References
http://www.cetbacau.ro/prezentare/date-tehnice/producerea-energiei-electrice.html
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.industcards.com/st-coal-romania.htm
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.industcards.com/st-coal-romania.htm
http://www.cetbv.ro/date-tehnice/capacitati-de-productie-cet-brasov.htm
http://www.cetbv.ro/date-tehnice/statistici-cet-brasov.htm
http://www.cet-govora.ro/cet_engleza/index.php
http://www.cet-govora.ro/cet_engleza/index.php?pid=7
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.industcards.com/st-coal-romania.htm
http://en.wikipedia.org/wiki/Craiova_II_Power_Station
http://www.industcards.com/st-coal-romania.htm
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://en.wikipedia.org/wiki/List_of_power_stations_in_Romaniahttp://www.9am.ro/stiri-revista-presei/2005-06-23/mec-vrea-14-milioane-de-euro-in-plus-pe
http://www.termodeva.ro/index.php/about-us/http://www.termodeva.ro/index.php/welcome/http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.termodeva.ro/index.php/about-us/http://www.termodeva.ro/index.php/welcome/http://prtr.ec.europa.eu/FacilityLevels.aspx
http://en.wikipedia.org/wiki/List_of_power_stations_in_Romania
http://www.eib.org/projects/pipeline/2009/20090514.htm
http://www.minind.ro/International/printable/ER1/ER1.318.06.pdf
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.raan.ro/en/index.html
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.industcards.com/st-coal-romania.htm
http://www.cerovinari.ro/
http://en.wikipedia.org/wiki/List_of_power_stations_in_Romania
http://en.wikipedia.org/wiki/Rovinari_Power_Station
http://www.industcards.com/st-coal-romania.htm
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.eturceni.ro/date_gen.htm#
http://en.wikipedia.org/wiki/List_of_power_stations_in_Romania
http://en.wikipedia.org/wiki/Turceni_Power_Station
http://www.industcards.com/st-coal-romania.htm
http://pdf.usaid.gov/pdf_docs/PNADG294.pdf
http://prtr.ec.europa.eu/FacilityLevels.aspx
ID
3
Notes
Abstract
CET Bucharest-Progresu CHPP Power Plant Romania is located at Pogoanele, nr. 1A, 75449, Bucharest, Romania. Location coordinates are: Latitude= 44.3
Longitude= 26.1073. This infrastructure is of TYPE Gas Power Plant with a design capacity of 200 MWe. It has 4 unit(s). The first unit was commissioned in 19
and the last in 1994. It is operated by SC ELECTROCENTRALE BUCURESTI SA.
Iernut-Ludus (Mures) Power Station Romania is located at Lernut, Mures County, Romania. Location coordinates are: Latitude= 46.4677, Longitude= 24.183
This infrastructure is of TYPE Gas Power Plant with a design capacity of 800 MWe. It has 6 unit(s). The first unit was commissioned in 1963 and the last in 19
It is operated by S.C. Electrocentrale Bucuresti S.A..
Petrom Brazi CCGT Power Plant Romania is located at Petrobrazi Refinery, Ploiesti, Prahova, Romania. Location coordinates are: Latitude= 44.8802, Longitu
25.9988. This infrastructure is of TYPE Gas Power Plant with a design capacity of 860 MWe. It has 3 unit(s). The first unit was commissioned in 2011 and the
in 2011. It is operated by Petrom Power.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Gas
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
CET Bucharest-
Progresu CHPP
Operating Fully 41136 New Leu
Power Plant
Romania
Iernut-Ludus
(Mures) Power Operating Fully 40973 New Leu
Station Romania
Petrom Brazi
CCGT Power Operating Fully 42206 New Leu
Plant Romania
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
44,372 26,107 Exact 200
Thermal
Sub-critical
46,468 24,183 Exact 800
Thermal
Combined Cycle
44,880 25,999 Exact 860
Gas Turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Pogoanele, nr.
1A, 75449,
Natural Gas Fuel Oil
Bucharest,
Romania
Lernut, Mures
Natural Gas
County, Romania
Petrobrazi
expect 6.7 TWh Refinery, Ploiesti,
Natural Gas Base Load
per year Prahova,
Romania
Description
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Fule Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
pipeline from
from an
underground
Brazi Vest
National Grid storage facility at
substation
Butimanu in
Dambovita
County
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 50 1987
2 50 1988
3 50 1989
4 50 1994
1 100 1963
2 100 1964
3 100 1964
4 100 1966
5 200 1966
6 200 1967
1 310 2011
2 310 2011
3 305 2011
Unit Information
Decommission
Turbine Turbine Generator Generator Boiler/HRSG Boiler/HRSG
Date (yyyy-mm-
Manufacturer Model/Type Manufacturer Model/Type Manufacturer Model/Type
dd)
TMZ
Electrosila
(Turbomotornyj Taganrog
Russia
Zavod)
TMZ
Electrosila
(Turbomotornyj Taganrog
Russia
Zavod)
TMZ
Electrosila
(Turbomotornyj Taganrog
Russia
Zavod)
TMZ
Electrosila
(Turbomotornyj Taganrog
Russia
Zavod)
GE GT-1 7FB GE
GE GT-1 7FB GE
GE GT-1 7FB GE
Environmental Issues Past and Future Major U
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
SC
ELECTROCENT
RALE
BUCURESTI SA
S.C.
Electrocentrale
Bucuresti S.A. Public joint-stock
(subsidiary of company
Termoelectrica
S.A.)
Metka Greece,
GR Energy,
Petrom CPP and IPP
Empresarios
Agrupados
perator Information Comments
AGENTIA
SC
NATIONALA
ELECTROCENT
PENTRU
RALE
PROTECTIA
BUCURESTI SA
MEDIULUI
Supply power to Petrobrazi Refinery and rest sell on the market. Basic
Petrom Power
and Detail Engineering by Empresarios Agrupados
References
http://www.elcen.ro/
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.elcen.ro/http://prtr.ec.europa.eu/FacilityLevels.aspxhttp://en.wikipedia.org/wiki/Ludus-Iernut_Power_Stationhttp://www.industcards.com/st-other-rom
http://www.wall-street.ro/articol/Companii/43553/GE-Energy-construieste-termocentrala-de-
860-MW-pentru-Petrom.html
http://en.wikipedia.org/wiki/Petrom_Brazi_Power_Station
http://www.petrom.com/portal/01/petromcom/!
ut/p/c5/04_SB8K8xLLM9MSSzPy8xBz9CP0os3hfA0sPN89Qo1BHE08vAze3oDAvAwgAyk
diyrtbesDk8ev288jPTdUPTs3TL8iNKAcA3Xu5bQ!!/dl3/d3/L0lJSklrQSEhL3dMTUFCa0FFa
k5BIS80Qm40UklBd1FBISEvNl9NMDlIRklVMlVBNElKMEZGRDRKMDAwMDAwMC83X00
wOUhGSVUyVUE0SUowRkZVTUgxMDAwMDAwL0hvbWU!/
http://www.petrom.com/SecurityServlet/secure?
cid=1234540819219&lang=en&swa_site=wps.vp.petromcom&swa_nav=Business+Units||
Gas%2C+Power+%26+Chemicals||BD+Power||EBRD+documents||&swa_pid=
%5BObjectIDImpl+%276_M09HFIU2UA4IJ0FFP7S0000000%27%2C+CONTENT_NODE
%2C+VP%3A+6491%2C+%5BDomain%3A+rel%5D%2C+DB%3A+5B19-
16A4F8A4175E1139C17BF97000000000%5D&swa_lang=en
http://www.empresariosagrupados.es/projects/brazi-romania/
ID
6
6
Notes
Abstract
Brazi (Dalkia Termo Prahova) Thermal CHPP Power Plant Romania is located at Trandafirilor nr.71, 107084, Brazi, Romania. Location coordinates are: Latitud
44.8833, Longitude= 26.00888. This infrastructure is of TYPE Oil Power Plant with a design capacity of 610 MWe. It has 10 unit(s). The first unit was
commissioned in 1961 and the last in 1986. It is operated by SC DALKIA TERMO PRAHOVA SRL.
Bucharest Grozavesti CHPP Power Station Romania is located at Splaiul Independentei nr. 229, 77208, Bucharest, Romania. Location coordinates are: Latitu
44.4404, Longitude= 26.06333. This infrastructure is of TYPE Oil Power Plant with a design capacity of 100 MWe. It has 2 unit(s). The first unit was commissio
in 1964 and the last in 1964. It is operated by SC Electrocentrale Bucuresti SA.
Bucharest South CHPP Power Station Romania is located at Releului , nr. 2B, 74569, Bucharest, Romania. Location coordinates are: Latitude= 44.4046,
Longitude= 26.1523. This infrastructure is of TYPE Oil Power Plant with a design capacity of 550 MWe. It has 6 unit(s). The first unit was commissioned in 19
and the last in 1975. It is operated by S.C. Electrocentrale Bucuresti S.A..
CET Bucuresti West CHPP Romania is located at Bd. Timisoara nr. 106, 77208, Bucharest, Romania. Location coordinates are: Latitude= 44.4233, Longitud
25.979. This infrastructure is of TYPE Oil Power Plant with a design capacity of 250 MWe. It has 2 unit(s). The first unit was commissioned in 1975 and the las
1975. It is operated by SC ELECTROCENTRALE BUCURESTI SA.
CET Constanta CHPP Power Plant Romania is located at Bulevardul Aurel Vlaicu nr. 123, 900075, Constanta, Romania. Location coordinates are: Latitude
44.1585, Longitude= 28.607. This infrastructure is of TYPE Oil Power Plant with a design capacity of 100 MWe. It has 2 unit(s). The first unit was commissione
1970 and the last in 1971. It is operated by SC ELECTROCENTRALE BUCURESTI SUC. CONSTANTA.
Galati Thermal Power Station Romania is located at Soseaua Smardan nr. 3, 800700, Galati, Romania. Location coordinates are: Latitude= 45.436, Longitud
27.9814. This infrastructure is of TYPE Oil Power Plant with a design capacity of 535 MWe. and the last in . It is operated by SC Electrocentrale Galati SA.
Galati Thermal Power Station Romania is located at Soseaua Smardan nr. 3, 800700, Galati, Romania. Location coordinates are: Latitude= 45.436, Longitud
27.9814. This infrastructure is of TYPE Oil Power Plant with a design capacity of 535 MWe. and the last in . It is operated by SC Electrocentrale Galati SA.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pound
MM=million
Identifiers for Oil
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Brazi (Dalkia
Termo Prahova)
Operating
Thermal CHPP 41145 New Leu
partially
Power Plant
Romania
Bucharest
Grozavesti CHPP
Operating fully 41135 New Leu
Power Station
Romania
Bucharest South
CHPP Power Operating fully 40972 New Leu
Station Romania
CET Bucuresti
West CHPP Operating fully 41134 Kwacha
Romania
CET Constanta
CHPP Power Operating fully 41137 New Leu
Plant Romania
Galati Thermal
Power Station Operating fully 40974 New Leu
Romania
Galati Thermal
Power Station Operating fully 40974 New Leu
Romania
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
44,883 26,009 610 576
steam turbine
Sub-critical
44,440 26,063 Exact 100
steam turbine
Cogeneration
44,405 26,152 Exact 550 Power and Heat
Steam Turbine
Sub-critical
44,423 25,979 Exact 250
steam turbine
Sub-critical
44,159 28,607 Exact 100
steam turbine
Sub-critical
45,436 27,981 Exact 535
steam turbine
Sub-critical
45,436 27,981 Exact 535
steam turbine
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Trandafirilor
Fuel Oil Natural Gas nr.71, 107084,
Brazi, Romania
Splaiul
Independentei
Oil Natural Gas nr. 229, 77208,
Bucharest,
Romania
Bulevardul Aurel
Vlaicu nr. 123,
Fuel Oil Natural Gas 900075,
Constanta,
Romania
Soseaua
Smardan nr. 3,
Heavy Oil Natural Gas
800700, Galati,
Romania
Soseaua
Smardan nr. 3,
Heavy Oil Natural Gas
800700, Galati,
Romania
Description
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Oil Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
Industry,
National Grid Commercial and
Residential
National Grid
River Danube
River Danube
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: Unit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 50 1961
2 50 1961
3 50 1961
4 50 1961
5 50 1961
6 50 1961
7 105
8 105
9 200 1986
10 200 1986
1 50 1964
2 50 1964
1 50 1965
2 50 1966
3 100 1967
4 100 1967
5 125 1975
6 125 1975
1 125 1975
2 125 1975
1 50 1970
2 50 1971
1 60
2 60
3 100
4 105
5 105
6 105
Unit Information
Turbomotornyj
Taganrog Zavod Electrosila
Yekaterinburg
Type of Construction/E
Cost Year Owner 1 % Share
Ownership PC Contractor
SC DALKIA
TERMO
PRAHOVA SRL
SC
Electrocentrale
Bucuresti SA
S.C.
Public joint-stock
Electrocentrale
company
Bucuresti S.A.
SC
ELECTROCENT
RALE
BUCURESTI SA
SC
AGENTIA
ELECTROCENT
NATIONALA
RALE Public joint-stock
PENTRU
BUCURESTI company
PROTECTIA
SUC.
MEDIULUI
CONSTANTA
Thermoelectrica
100
S.A.
Thermoelectrica
100
S.A.
perator Information Comments
AGENTIA
SC DALKIA NATIONALA
TERMO PENTRU Heat Output = 475 MW thermal
PRAHOVA SRL PROTECTIA
MEDIULUI
AGENTIA
SC NATIONALA
Electrocentrale PENTRU
Bucuresti SA PROTECTIA
MEDIULUI
AGENTIA
S.C. NATIONALA Modernization of Units 3 and 4 of 100 MW each. Targets: 8% reduction
Electrocentrale PENTRU of electricity generation costs (3 USD/MWh); Emissions reduction by
Bucuresti S.A. PROTECTIA installing low NOx burners.
MEDIULUI
AGENTIA
SC
NATIONALA
ELECTROCENT
PENTRU
RALE
PROTECTIA
BUCURESTI SA
MEDIULUI
SC
ELECTROCENT
RALE
BUCURESTI
SUC.
CONSTANTA
AGENTIA
SC NATIONALA
Electrocentrale PENTRU
Galati SA PROTECTIA
MEDIULUI
AGENTIA
SC NATIONALA
Electrocentrale PENTRU
Galati SA PROTECTIA
MEDIULUI
References
http://www.dalkia.ro/ro/despre-dalkia/filiale.html
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.energie-gratis.ro/termocentrale.php
http://www.elcen.ro/
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.industcards.com/st-other-romania.htm
http://en.wikipedia.org/wiki/List_of_power_stations_in_Romania
http://www.elcen.ro/
http://www.industcards.com/st-other-romania.htm
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.elcen.ro/
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://www.elcen.ro/
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://en.wikipedia.org/wiki/Gala%C5%A3i_Power_Station
http://www.cez.cz/en/investors/inside-information/1167.html
http://prtr.ec.europa.eu/FacilityLevels.aspx
http://en.wikipedia.org/wiki/Gala%C5%A3i_Power_Station
http://www.cez.cz/en/investors/inside-information/1167.html
http://prtr.ec.europa.eu/FacilityLevels.aspx
ID
Notes
Abstract
Matra Coal Power Plant Hungary is located at Visonta, East of Gyongyos, Heves, Hungary. Location coordinates are: Latitude= 47.79027, Longitude= 20
This infrastructure is of TYPE Coal Power Plant with a design capacity of 950 MWe. It has 7 unit(s). The first unit was commissioned in 1978 and the last
operated by Matra Ermu Rt.
Oroszlany CHP Coal Power Plant Hungary is located at Oroszlany, Komarom-Esztergom, Hungary. Location coordinates are: Latitude= 47.5017, Longi
18.2701. This infrastructure is of TYPE Coal Power Plant with a design capacity of 240 MWe. It has 4 unit(s). The first unit was commissioned in 1961 and
in 1963. It is operated by Vertesi Eromu ZRt (formed in 1992 and owned by MVM Ztr).
Pannonpower (Pecs) Thermal Power Plant Hungary is located at Pecs, Pecs, Hungary. Location coordinates are: Latitude= 46.0641, Longitude= 18.263
infrastructure is of TYPE Coal Power Plant with a design capacity of 182.4 MWe. It has 4 unit(s). The first unit was commissioned in 1961 and the last in 1
operated by Pannon Thermal PP Ltd and Pannon Green.
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pounds, MM=million
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 pounds, MM=million
Identifiers for Coal
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
Matra Coal
Power Plant Operating Fully 42668 Forint
Hungary
Oroszlany CHP
Coal Power Operating Fully 42672 Forint
Plant Hungary
Pannonpower
(Pecs) Thermal
Operating Fully 42683 Forint
Power Plant
Hungary
Location
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
47,790 20,064 Exact 950
Thermal
Cogeneration
47,502 18,270 Exact 240 84 Power and Heat
Steam Turbine
Sub-critical
46,064 18,263 Exact 182.4
Thermal
Configuration
Short Power Plant of
Type of Fuel Primary Secondary Location
Description Used For Boiler/Turbine/
Gen
Visonta, East of
Coal Lignite Base Load Gyongyos, Heves,
Hungary
Oroszlany,
Coal lignite and Komarom-
Base Load
Brown Coal Esztergom,
Hungary
Mixed Fuel -
Pecs, Pecs,
Gas, Coal and Natural Gas Biomass
Hungary
Biomass
D
Water
Electric Power Name of Onsite Storage Withdrawal Onsite Storage
Name/operator
Grid Connected SubStation Source of Coal Capacity Rate at Full Capacity
PPA(years)
To Connected To (Tonnes) Power (Tonnes)
(cum/hour)
Company owned
Lignite mines 3
National Grid 180000
km South and
East
Mines in the
Oroszlany and
National Grid Tatabanya
regions including
Markushegy
Pecs substation
National Grid
at 120kV
Description
Kilometers to
Name of Major Type of Cooling Source of Source of
Coal Mines Rate (cum/day) Rate (cum/day)
Mines System Cooling Water Makeup Water
(Average)
3
Water
Withdrawal Cogen Mode:
Environmental Capital Cost of and/or In US
Rate at Full Steam Supplied (Tonnes/hour) Description
Issues Plant Dollars
Power To
(cum/hour)
Particulates(PM
Mercury Control SOx Control NOx Control
In Year (YYYY) If other, specify: If other, specify: ) Control Device
Device Device Type Device Type
Type
Date Decommission
Boiler
If other, specify: Unit # Capacity (MWe) Commissioned Date (yyyy-mm- Boiler Manufacturer
Model/Type
(yyyy-mm-dd) dd)
1 100 1978
2 100 1978
3 220 1980
4 232 1980
5 232 1980
6 33
7 33
3 60 1965 Coal
ST-1
ST-2
ST-3
ST-4
ST-5
Vertesi Eromu
1. 1990-1990
ZRt (formed in
MVM Ztr.
1992 and owned
2. 2002-2004
by MVM Ztr)
Regulatory Project
Authority Financed By
Comments
Comment 1
Units 1, 2 4 & 5 have Heller-type dry cooling systems while Unit-3 uses conventional natural draft towers
Two wet lime FGD units are integrated into the interior of the two dry-cooling towers and fed by a common duct collecting flue gases from the 3x232
Sales of power benefit from having regional electricity distributors Elmu and Emasz, both controlled by RWE-EnBW
This thermal plant started out as 2x35 (1961) and 2x60 (1965) coal fired.
The 2x35 MW units were converted to Gas fired in 2005 and Unit 4 of 60 MW units to Biomass in 2004 with capacity 49.9 MW
References
http://english.mvm.hu/engine.aspx?page=statistical_data
http://www.industcards.com/st-coal-hungary.htm
http://www.rwe.com/web/cms/mediablob/en/217484/data/217340/1/rwe-power-
international/downloads/www-rwepi-com-downloads/RWE-extended-the-life-of-
Hungarys-Matra-power-station.pdf
http://www.vert.hu/oroszlany.aspx
http://www.industcards.com/st-coal-hungary.htm
http://www.pannonpower.hu/tagvallalatok/pannonpower-holding-zrt/tevekenysegunk
http://www.industcards.com/biomass-europe.htm
6
7
10
11
12
13
14
Notes
Abstract
AES Tisza II Thermal Power Plant Hungary is located at Tiszaujvaros, Borsod-Abauj-Zemplen, Hungary. Location coordinates are: Latitude= 48.9174, Lon
21.077. This infrastructure is of TYPE Gas Power Plant with a design capacity of 900 MWe. It has 4 unit(s). The first unit was commissioned in 1977 and t
1978. It is operated by AES TISZA ERM KFT..
BC (Borsodchem) CHP Power Plant Hungary is located at Kazincbarcika, BorsodChem Zrt, Borsod-Abauj-Zemplen, Hungary. Location coordinates are: L
48.2453, Longitude= 20.6476. This infrastructure is of TYPE Gas Power Plant with a design capacity of 47 MWe. It has 2 unit(s). The first unit was comm
in 2001 and the last in 2001. It is operated by Sinergy Ltd (for BC-Erm Kft).
Csepel CCGT Power Plant Hungary is located at On river Danube, Budapest, Hungary. Location coordinates are: Latitude= 47.428, Longitude= 19.052
infrastructure is of TYPE Gas Power Plant with a design capacity of 403 MWe. It has 3 unit(s). The first unit was commissioned in 2000 and the last in 20
operated by Atel Csepeli Vllalatcsoport.
Dunamenti II Thermal Power Plant Hungary is located at Szazhalombatta, Pest, Hungary. Location coordinates are: Latitude= 47.3283, Longitude= 18.91
infrastructure is of TYPE Gas Power Plant with a design capacity of 1290 MWe. It has 6 unit(s). The first unit was commissioned in 1974 and the last in 1
operated by Dunamenti Ltd.
E.ON Debrecen OCGT CHP Power Plant Hungary is located at Debrecen, Hajdu-Bihar, Hungary. Location coordinates are: Latitude= 47.5185, Longit
21.6329. This infrastructure is of TYPE Gas Power Plant with a design capacity of 95 MWe. It has 1 unit(s). The first unit was commissioned in 2001. It is
by Debreceni Kombinlt Ciklus Erm Kft. (DKCE).
E.ON Gonyu CCGT Power Plant Hungary is located at West of Gonyu, Gyor-Moson-Sopron, Hungary. Location coordinates are: Latitude= 47.7384, Lon
17.8033. This infrastructure is of TYPE Gas Power Plant with a design capacity of 433 MWe. It has 2 unit(s). The first unit was commissioned in 2011 and
in 2011. It is operated by E.ON Ermvek Kft.
E.ON Nyiregyhaza OCGT CHP Power Plant Hungary is located at Nyiregyhaza, Szabolcs-Szatmar-Bereg, Hungary. Location coordinates are: Latitude= 4
Longitude= 21.6988. This infrastructure is of TYPE Gas Power Plant with a design capacity of 49 MWe. It has 1 unit(s). The first unit was commissioned in
is operated by Nyregyhzi Kombinlt Ciklus Erm Kft.
Kelenfold CCGT CHP Power Plant Hungary is located at Hengermalom t 60, Budapest XI, Hungary. Location coordinates are: Latitude= 47.4624, Long
19.0563. This infrastructure is of TYPE Gas Power Plant with a design capacity of 196 MWe. It has 4 unit(s). The first unit was commissioned in 1995 and
in 2010. It is operated by Budapesti Eromu Rt (BERT) (Budapest Power Plant).
Kispest CCGT CHP Power Plant Hungary is located at Budapest XVIII., Nefelejcs u. 2., Hungary. Location coordinates are: Latitude= 47.4568, Longitu
19.1673. This infrastructure is of TYPE Gas Power Plant with a design capacity of 114 MWe. It has 2 unit(s). The first unit was commissioned in 2004 and
in 2004. It is operated by Budapesti Eromu Rt (BERT) (Budapest Power Plant).
Liter OCGT Power Plant Hungary is located at Liter, Veszprem, Hungary. Location coordinates are: Latitude= 47.1075, Longitude= 18.0143. This infrastru
of TYPE Gas Power Plant with a design capacity of 120 MWe. It has 1 unit(s). The first unit was commissioned in 1998. It is operated by MVM GTER
Lorenci OCGT Power Plant Hungary is located at 3021 Lrinci, Pf.: 10, Erm telep, Heves, Hungary. Location coordinates are: Latitude= 47.71644, Lon
19.67779. This infrastructure is of TYPE Gas Power Plant with a design capacity of 170 MWe. It has 1 unit(s). The first unit was commissioned in 2000
operated by MVM GTER Ztr..
Sajoszoged OCGT Power Plant Hungary is located at Borsod-Abauj-Zemplen, Hungary. Location coordinates are: Latitude= 47.9393, Longitude= 20.97
infrastructure is of TYPE Gas Power Plant with a design capacity of 120 MWe. It has 1 unit(s). The first unit was commissioned in 1998. It is operated b
GTER Ztr..
TVK CCGT CHP Power Plant Hungary is located at Tiszajvros, TVK Nyrt, Borsod-Abauj-Zemplen, Hungary. Location coordinates are: Latitude= 47.9
Longitude= 21.0236. This infrastructure is of TYPE Gas Power Plant with a design capacity of 33.4 MWe. It has 2 unit(s). The first unit was commissioned
and the last in 2004. It is operated by Sinergy Ltd (for TVK-Erm Kft.).
Ujpest CCGT CHP Power Plant Hungary is located at T u. 7., Budapest IV, Hungary. Location coordinates are: Latitude= 47.554, Longitude= 19.1023
infrastructure is of TYPE Gas Power Plant with a design capacity of 110 MWe. It has 2 unit(s). The first unit was commissioned in 2002 and the last in 20
operated by Budapesti Eromu Rt (BERT) (Budapest Power Plant).
* cum = cubic meters; MWe = Megawatts electric; 1 KWhr = 3412.3 Btu = 859.85 kilocalories; 1 Tonne = 2205 po
MM=million
Identifiers for Gas
Country
GEO Assigned Select Currency
Plant Efficiency Plant Overall Assigned
Name Status of Plant Identification for data in this
and Impact Rating Identification
Number page
Number
AES Tisza II
Thermal Power Operating Fully 42673 Forint
Plant Hungary
BC
(Borsodchem)
Operating Fully 42682 Forint
CHP Power
Plant Hungary
Csepel CCGT
Power Plant Operating Fully 42667 Forint
Hungary
Dunamenti II
Thermal Power Operating Fully 42674 Forint
Plant Hungary
E.ON Debrecen
OCGT CHP
Operating Fully 42669 Forint
Power Plant
Hungary
E.ON Gonyu
CCGT Power Operating Fully 42670 Forint
Plant Hungary
E.ON
Nyiregyhaza
OCGT CHP Operating Fully 42671 Forint
Power Plant
Hungary
Kelenfold CCGT
CHP Power Operating Fully 42678 Forint
Plant Hungary
Kispest CCGT
CHP Power Operating Fully 42680 Forint
Plant Hungary
Liter OCGT
Power Plant Operating Fully 42666 Forint
Hungary
Lorenci OCGT
Power Plant Operating Fully 42664 Forint
Hungary
Sajoszoged
OCGT Power Operating Fully 42665 Forint
Plant Hungary
Heat Supply
Design Firm Capacity
Latitude: Longitude: This location is: Capacity Type of Plant
Capacity (MWe) (MWe) nbr
(MWth)
Sub-critical
48,917 21,077 Exact 900
Thermal
Combined Cycle
47,428 19,053 Exact 403
Gas Turbine
Sub-critical
47,328 18,917 Exact 1290 1000
Thermal
Combined Cycle
47,738 17,803 Exact 433
Gas Turbine
Combined Cycle
47,957 21,699 Exact 49
Gas Turbine
Tiszaujvaros,
8x boilers of 670
Borsod-Abauj-
Natural Gas Fuel Oil Base Load t/h, 540 C, 168
Zemplen,
bar steam
Hungary
supplies the Kazincbarcika, It has 2 HRSG
adjacent BorsodChem Zrt, with
BorsodChem Natural Gas Fuel Oil Cogeneration Borsod-Abauj- supplemental
works with steam Zemplen, firing and two
and electricity Hungary reserve boiler
On river Danube,
One 2+2+1
Natural Gas Fuel Oil Budapest,
Block
Hungary
These are
labeled units F8- Szazhalombatta,
Natural Gas Fuel Oil Base Load
13 by the Pest, Hungary
company
Debrecen,
Intermediate/Pea One 1+1+1
Natural Gas Hajdu-Bihar,
k Load CCGT block
Hungary
West of Gonyu,
One 1+1+1
Natural Gas Gyor-Moson-
CCGT block
Sopron, Hungary
Nyiregyhaza,
Szabolcs-
Natural Gas Base Load
Szatmar-Bereg,
Hungary
Hengermalom t
Natural Gas Fuel Oil Cogeneration 60, Budapest XI,
Hungary
Liter, Veszprem,
Natural Gas Fuel Oil Peaking load one OCGT
Hungary
Borsod-Abauj-
Natural Gas Peaking load Zemplen, One OCGT
Hungary
Tiszajvros,
TVK Nyrt,
One 1+1+1
Natural Gas Cogeneration Borsod-Abauj-
CCGT block
Zemplen,
Hungary
T u. 7., 2 steam boilers,
Natural Gas Cogeneration Budapest IV, 1 HRSG, 2 hot
Hungary water boilers
Description
Water
Electric Power Name of Withdrawal Cogen Mode:
Name/operator
Grid Connected SubStation Source of Fuel Source of Water Rate at Full Steam Supplied
PPA(years)
To Connected To Power To
(cum/hour)
220kV substation
for Units 1-2 and 180 cum/h
National Grid a 400kV capacity water
substation for treatment plan
Units 3-4
Industry;
National Grid Danube River Szazhalombatta
Oil Refinery
E.ON Tiszntli
Regional Grid 120 kV
ramhlzati Zrt.
Adjacent Gonyu
National Grid Danube River
substation
Industry,
Commercial and
Regional Grid
Residential: City
of Nyiregyhaza
Residential
Complex: District
heating areas of
gas and oil by Ormezo,
National Grid Danube River
pipeline Gazdagret,
Lagymanyos
high pressure housing estate
natural gas and areas of
Buda Castle
Kbnya City
National Grid which arrives
Centre, Jzsef
through a
Attila housing
pipeline
Adjacent
400/132/35/20
National Grid
kV substation
Liter
Sajoszoged
National Grid 400/220/132 kV
substation
Chemical
company Tiszai
Vegyi Kombint
Residential:
Nyrt and MOL
district heating
National Grid Industrial Water areas of
Kposztsmegye
r, jpest City
(Tonnes/hour) Environmental Capital Cost of and/or In US SOx Control
In Year (YYYY) If other, specify:
Description Issues Plant Dollars Device Type
62000000 2001
17000000000 2000
573000000
11000000000
75000000 2004
Particulates(PM Date
NOx Control
If other, specify: ) Control Device If other, specify: nit # Capacity (MWe) Commissioned
Device Type
Type (yyyy-mm-dd)
1 225 1977
2 225 1977
3 225 1978
4 225 1978
1 23.5 2001
Low Nox Burner
2 23.5 2001
1 142.5 2000
2 142.5 2000
3 118 2000
1 215 1974
2 215 1974
3 215 1975
4 215 1975
5 215 1976
6 215 1976
1 95 2001
1 290 2011
Low Nox Burner
2 143 2011
Low Nox Burner 1 49 2007
1 136 1995
2 50 2006
3 5 2009
4 5 2010
1 70.1 2004
Low Nox Burner
2 44 2004
1 120 1998
1 23.6 2004
Low Nox Burner
2 9.8 2004
1 74 2002
2 36 2002
Unit Information
Decommission
Turbine Turbine Generator Generator Boiler/HRSG Boiler/HRSG
Date (yyyy-mm-
Manufacturer Model/Type Manufacturer Model/Type Manufacturer Model/Type
dd)
164 MVA at
AE
GE GT-1 MS99171E Elin 15.75 kV output
Energietechnik
voltage
164 MVA at
AE
GE GT-2 MS99171E Elin 15.75 kV output
Energietechnik
voltage
164 MVA at
GE ST-1 MS9001E Elin 15.75 kV output
voltage
Brown Boveri
ST-1
and Cie (BBC)
Brown Boveri
ST-2
and Cie (BBC)
Brown Boveri
ST-3
and Cie (BBC)
Brown Boveri
ST-4
and Cie (BBC)
Brown Boveri
ST-5
and Cie (BBC)
Brown Boveri
ST-6
and Cie (BBC)
GT-1 SGT5-
Siemens Siemens SGEN 5-3000W STF
4000F
GE GT-1 6FA
ST-1
European Gas
GT-1 PG 9171E GEC-Alstom
Turbines EGT
GE GT-1 6FA
Alstom ST-1
Environmental Issues Past and Future Majo
250
Refurbishment of plant for life
250
extension and meeting
250 European standards
250
200
200
200
200
200
200
59
59
Past and Future Major Upgrades Owner and Operator Infor
Type of
Cost Year Owner 1 % Share
Ownership
AES Hungary
1. EMASZ Rt (RWE)
3. BorsodChem Zrt
1. Electrabel SA
1. 50,3%
2. GDF SUEZ Energy Holding,
2. 24,5%
Hungary Ltd.
3. 25%
3. Hungarian Power Companies
4. 0,2%
4. Other
EDF Group
EDF Group
MVM Ztr.
MVM Ztr.
MVM Ztr.
EMASZ Rt (RWE)
CPP
Tiszai Vegyi Kombinat Rt (TVR)
EDF Group
nd Operator Information
AES TISZA
ERM KFT.
Atel Csepeli
VA Tech
Vllalatcsoport
Dunamenti Ltd
Debreceni
Kombinlt
Ciklus Erm
Kft. (DKCE)
E.ON Ermvek
Siemens
Kft
E.ON Energy Nyregyhzi
Projects, Kombinlt
Babcock-Hitachi Ciklus Erm
Europe Kft
Budapesti Eromu
Rt (BERT)
(Budapest Power
Plant)
Budapesti Eromu
Rt (BERT)
(Budapest Power
Plant)
Comment 1
Fuel oil delivered to the plant through pipeline from the Tisza Refinery
of MOL Rt. Four storage tanks of 20000 cum each
In addition to the main plant items, the site also has a Water Treatment
Plant, four hot water boilers and one auxiliary steam boiler to supply
district heat
The distillate fuel oil is stored in two 8000 cum tanks and unloaded at
the adjacent jetty
The GWh are for both the thermal and CCGT power plant
Along with electricity, the plant supplies about 910 TJ/yr of heat for the
city and process steam to a nearby Michelin tire plant
Onsite storage of fuel oil is 5000 cum. The plant has additional hot
water boilers available to operate in peak periods as needed
The 2x5 MW gas turbines are part of the TORNADO project for
summer cogeneration
In winter heating season the main equipment of PP is run typically at
high load and with optimum utilisation. Outside the heating season,
production is optimised over current contractual obligations and energy
market opportunities
The Matravidek site (old 4x32 coal-fired plant retired in 1982-1986) was
bought by MVM from the Matra Power Plant Co in 1995
http://www.industcards.com/st-other-hungary.htm
http://www.sinergy.hu/english/pages/bc_power_plant_kazincbarcika/http://www.industcards.com/cc-hungary.htm
http://csepel.alpiq.hu/en/what-we-offer/electricity-generation/electricity-generation.jsp
http://www.industcards.com/cc-hungary.htm
http://www.alpiq.com/what-we-offer/our-assets/thermal-power-plants/gas-fired-combined-
cycle-power-plants/csepel-thermal-power-station.jsp
http://www.gdfsuez-energia.hu/tarsasagunkrol/gdf-suez-magyarorszagon/dunamenti-eromu
http://www.industcards.com/st-other-hungary.htm
http://www.turbinetec.com/Download_GE_Layer.html
http://www.gdfsuez-energia.hu/sajtoszoba/sajtoszoba-063
http://www.eon-
hungaria.com/en/corporate/eongroup/debrecenikombinaltciklusueromu/history
http://www.industcards.com/cc-hungary.htm
http://www.eon-hungaria.com/en/corporate/e-on-eromuvek-kft http://www.eon-
hungaria.com/en/press/releases/2011/kozl110627
http://www.powermag.com/e-on-commissions-433-mw-hungary-ccgt/
http://www.industcards.com/cc-hungary.htm
http://www.eon-
hungaria.com/en/corporate/eongroup/nyiregyhazikombinaltciklusueromu/history and
http://www.eon-hungaria.com/en/corporate/eon/history
http://www.industcards.com/cc-hungary.htm
option=com_content&view=article&id=10&Itemid=13&lang=en
http://www.industcards.com/cc-hungary.htm
http://www.budapestieromu.hu/index.php?
option=com_content&view=article&id=18&Itemid=22&lang=en
option=com_content&view=article&id=12&Itemid=15&lang=en
http://www.budapestieromu.hu/index.php?
http://www.budapestieromu.hu/index.php?
option=com_content&view=article&id=14&Itemid=17&lang=en (BERT Annual Reports
http://www.mvm-gter.hu/gazturbinas-eromuvek
http://www.gter.hu/gazturbinas-eromuvekhttp://www.industcards.com/cc-hungary.htm
http://www.mvm-gter.hu/gazturbinas-eromuvek
http://www.industcards.com/cc-hungary.htm
http://www.sinergy.hu/english/pages/tvk_power_plant_tiszaujvaros/
http://www.industcards.com/cc-hungary.htm
option=com_content&view=article&id=11&Itemid=14&lang=en
http://www.budapestieromu.hu/index.php?
option=com_content&view=article&id=14&Itemid=17&lang=en (Bert Annual Reports 2005-