Beruflich Dokumente
Kultur Dokumente
Gas Field
EEE - Assistant Manager Recruitment Examination (departmental)
March, 2017
Exam Venue- BUET
Question 1:Find the nodal voltage and current I?
Solution 1:
At supernode,
= 10 . (1) =0 , = 10 = 20
= 10 . (2) 10
= +
Combined, 5 10
10 10 20
+5+ + = 0 = = 2 2 = 4
10 5 10 5 10
+ 2 + = 40 . (3)
Career@Engineering facebook.com/groups/career.eng/
Cell: 01710-759868 Page1/5
Solution 2:
The circuit can be reduced to after Wye Delta =
conversion, Where = = 1 = 5 6
= 30
(30)
= =
6
= 150 ( )
5A
3
Question 3:Find IB, IC, VC, VB for the following voltage divider circuit?
Solution: 3
= || = 39 ||3.3 = 3.04 = ( + 1)
3.3 15 = 101 1.53 = 0.154
= = = 1.17 , = = 100 1.53 = 0.163
+ 39 + 3.3
= = = 0.154 3 = 0.462
+ ( + 1)
= = 0.153 5 = 0.765
Career@Engineering facebook.com/groups/career.eng/
Cell: 01710-759868 Page2/5
1.17 0.7
= = 1.53
3.04 + 101 3
Question 4:Design the Op-amp circuit using integrator and adder circuits, = , V= 5V
at t = 0.
Solution: 4
Since, V = 5V, so differentiating
a constant term would result
zero d(5)/dt = o
So, finally we need to implement
= ,
Question 5:Given Ia = 10<0o, Ib = 10<180o, Ic = 0A, Find positive and zero sequence current?
Solution: 5
1
1 1 = [10 < 0 + (1 < 120 10 < 180 )
= 1 3
3 + 0 ]
1 1 1
1 = 5.78 < 30
= [ + + ] 1
2 = [ + + ]=0
Where a = 1<120o and a2 = 1<240o 3
0.150 0.090
Question 6:Two Bus System, = , find sub transient current on bus 1. Also
0.090 0.114
find voltage of V2 and V3 on bus 1 and 2.
Career@Engineering facebook.com/groups/career.eng/
Cell: 01710-759868 Page3/5
Solution: 6
Here considering the matrix, we can write,
Here considering the matrix, we can write, The voltage at bus 2,
1.0 = 1.0
= = 6.67 . = 1.0 ( 6.67)( 0.09)) = 0.4 .
0.15
Question 7:A 3 phase 10MVA, 400V, 50Hz Y connected alternator supplies the rated load 0.8 pf
A 3 phase 10MVA, 400V, 50Hz Y connected alternator supplies the rated load 0.8 pf
lagging. It has synchronous reactance 0.635
lagging. It has synchronous reactance 0.635 . Find the torque angle?
Solution: 7
400 Now, cos = 0.8, = 36.8 = 0.6
= = 231 +
3 tan( + ) =
10 10 +
= = 14.43 10 + = 60.7 7
3 400
= 9163.05 = 60.7 23.9 (
36.8 = 23 )
Question 8:Describe the under excitation and over excitation of synchronous motor. Give name
Describe the under excitation and over excitation of synchronous motor. Give name
of two synchronous motor without rotor excitation.
of two synchronous motor without rotor excitation.
Reference: Art
t 6.2, Electrical Machineries - Seteven Chapman
Solution: 8
Consider the following figure
Notice that as the value of EA increases, the magnitude of the armature current I
increases, the magnitude of the armature current IA first decreases
first decreases
and then increases again. At low EA, armature current is lagging, and the motor is an inductive
load. It is acting like an inductor- resistor combination, consuming reactive power Q. As the field
resistor combination, consuming reactive power Q. As the field
current is increased the armature current eventually lines up with V, and the motor looks
purely resistive. As the field current is increased further, the armature current becomes leading,
ly resistive. As the field current is increased further, the armature current becomes leading,
Career@Engineering facebook.com/groups/career.eng/
facebook.com/groups/career.eng/
Cell: 01710-759868 Page4/5
and the motor becomes a capacitive load. It is now acting like a capacitor- resistor combination,
consuming negative reactive power Q or, alternatively, supplying reactive power Q to the
system.
Question 9:A message signal m(t)= 6sin 8000t. If the sensitivity level is 500 Hz/V. Then find
modulation index and bandwidth.
Solution: 9
Given,
( ) = 6 sin 8000 600
, = = = 0.15
=6 = 100 4000
, = 2[ + ]
8000
= = 4000 = 2[600 + 4000]
2 = 9.2 ( )
= = 6 100 = 600
Question 10:For 1011 sequence draw unipolar NRZ, Bipolar RZ and Bipolar NRZ.
Solution: 10
Solution Prepared by: