Beruflich Dokumente
Kultur Dokumente
The entire track is cut into two sections, the following chart
Two track alignment, the connecter shift half to another section of the track, two track together, as
shown in the following picture:
Use six horn screw rod, tightening the connecter screws can be, as follows
The belt inside the track and must in circle,must keep the beltnot in distort
The product was assemblied by ourself, then separate into two pieces, so the belt will be proper length, you can not
cut the track or belt
The system has two carrier,, I have tried to open it for your reference, you can understand to see the carrier which
assemblied, you will see how to assembly
1. Make the belt in good position and move Arm main bodyconnector the two tracks,the connector can not make in
very tight, if too tight, the carrier will feel heavy.
2After all assemblied, move the one of carrier , if it can not move, that means the inside belt has been distort.
Motor driver head Motor driver end ceiling bracket
Power Line
Power connector
Learningkey
Yellow light
Green light
Changing key
Bottom of motor
1-6 channel
OPEN
Stop
CLOSE
Running hole
Top of motor
Lock botton
Put the bracket to the track and use the screw to install to the ceiling
The running hole of motor to match with the running pole,so the the motor can install to
motor driver head
The lock button will down automatically when the motor installed
Installation steps
The first step: install the track via the bracket
The second step: install the motor to Motor driver head via the above method.
The thrid step: connect with the power
The fourth step: set up the remote
Learning key
Push this key last for three seconds until the green light
on,then loose your hand, select the channel you want via
Choose channel key,push the Choose channel key on the
same time, then you will see the green light key is lighting
and off, that is mean you set up successfully.
Yellow light
Green light
Push this key last for three seconds until the yellow light on,then loose
your hand. The position of the carrier changed successfully from
middle or two ends
Remote has 7 channel 1 2 3 4 5 6, all lights up of remote memean one channel it is
Learning key the seventh (7) channel.
Green light Only the remote and motor set up, then the remote can work.
Close