Beruflich Dokumente
Kultur Dokumente
D E P A R T M E N T O F T H E A R M Y T E C H N I C A L M A N U A L
REPORTING OF ERRORS
You can help improve this manual by calling attention to errors and by recommending im-
provements and stating your reasons for the recommendations. Your letter or DA Form 2028
(Recommended Changes to Publications and Blank Forms) should be mailed direct to Com-
mander, US Army Electronics Command, ATTN: DRSEL-MA-Q, Fort Monmouth, New Jersey
07703. A reply will be furnished direct to you.
Table of Contents
Illus
Page Figure
Section I. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
II. Repair parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Group 00 Test Set, Battery AN/PSM-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 1
01 Test Set, Battery TS-130VPSM-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 2
02 Adaptor, Connector U-240/PSM-13 (No parts authorized)
03 Adaptor, Connector U-241/PSM-13 (No parts authorized)
04 Adaptor, Connector U-242/PSM-13 (No parts authorized)
05 Adaptor, Connector U-297/PSM-13 (No parts authorized)
06 Adaptor, Connector U-314/PSM-13 (No parts authorized)
07 Adaptor, Connector U-315/PSM-13 (No parts authorized)
08 Adaptor, Connector U-347/PSM-13 (No parts authorized)
09 Bag, Cotton Duck CW-842/PSM-13 (No parts authorized)
Section III. Special tools list (Not applicable)
IV. National stock number and part number index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
* This manual supersedes so much of TM 11-662S-823-15, 26 February 1968, as perteins to repair parts and special tools lists.
i
TM 11-6625-823-24P
SECTION I
INTRODUCTION
1. Scope NOTE
This manual lists spares and repair parts; special tools; Cannibalization or salvage may be used as a
special test, measurement, and diagnostic equipment source of supply for any items source coded
(TMDE), and other special support equipment required above except those coded XA and aircraft
for performance of organizational, direct support, and support items as restricted by AR 700-42.
general support maintenance of the AN/PSM-13. It (2) Maintenance code. Maintenance codes are
authorizes the requisitioning and issue of spares and assigned to indicate the levels of maintenance
repair parts as indicated by the source and mainte- authorized to USE and REPAIR support items. The
nance codes. maintenance codes are entered in the third and fourth
2. General positions of the Uniform SMR Code format as follows:
This Repair Parts and Special Tools List is divided into (a) The maintenance code entered in the third
the following sections: position will indicate the lowest maintenance level
a. Section II. Repair Parts List. A list of spares and authorized to remove, replace, and use the support
repair parts authorized for use in the performance of item. The maintenance code entered in the third posi-
maintenance. The list also includes parts which must tion will indicate one of the following levels of mainte-
be removed for replacement of the authorized parts. nance:
Code Application/Explanation
Parts lists are composed of functional groups in
numeric sequence, with the parts in each group listed O –Support item is removed, replaced, used at the
in figure and item number sequence. organizational level.
b. Section III. Special Tools List. Not applicable. H –Support item is removed, replaced, used at the
c. Section IV. National Stock Number and Part general support level.
Number Index. A list, in National item identification (b) The maintenance code entered in the fourth
number (NIIN) sequence, of all National stock numbers position indicates whether the item is to be repaired
and identifies the lowest maintenance level with the
(NSN) appearing in the listings, followed by a list, in
alphameric sequence, of all part numbers appearing in capability to perform complete repair (i.e., all
the listings. National stock numbers and part numbers authorized maintenance functions). This position will
are cross-referenced to each illustration figure and contain one of the following maintenance codes:
Code Appliaation/Explanation
item number appearance.
H –The lowest maintenance level capable of com-
3. Explanation of Columns plete repair of the support item is the general
a. Illustration. This column is divided as follows: support level.
(1) Figure number. Indicates the figure number of Z –Nonreparable. No repair is authorized.
the illustration on which the item is shown. (3) Recoverability code. Recoverability codes are
(2) Item number. The number used to identify item assigned to support items to indicate the disposition ac-
called out in the illustration. tion on unserviceable items. The recoverability code is
b. Source, Maintenance, and Recoverability (SMR) entered in the fifth position of the Uniform SMR Code
Codes. format as follows:
(1) Source code. Source codes indicate the manner Recoverability
of acquiring support items for maintenance, repair, or codes Definition
overhaul of end items. Source codes are entered in the Z –Nonreparab)e item. When unserviceable, con-
first and second positions of the Uniform SMR Code demn and dispose at the level indicated in posi-
format as follows: tion 3.
Code Definition D –Reparable item. When beyond lower level repair
PA–Item procured and stocked for anticipated or acapability, return to depot.. Condemnation
known usage. and disposal not authorized below depot level.
PD–Support item, excluding support equipment, pro- c. National Stock Number. Indicates the National
cured for initial issue or outfitting and stocked stock number assigned to the item and will be used for
only for subsequent or additional initial issues requisitioning purposes.
or outfittings. Not subject to automatic d. Part Number. Indicates the primary number used
replenishment. by the manufacturer (individual, company, firm, cor-
XD–A support item that is not stocked. When re- poration, or Government activity), which controls the
quired, item will be procured through normal design and characteristics of the item by means of its
supply channels. engineering drawings, specifications, standards, and
1
TM 11-6625-823-24P
2
TM11-6625-823-24P
EL2YS00I
4
TM11-6625-823-24P
SECTION II
(1) (2) (3) (4) (5) (6) (7) (8)
ILLUSTRATION QTY
(A) (B) NATIONAL DESCRIPTION INC
FIG ITEM SMR STOCK PART IN
NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U/M UNIT
GROUP 00 TEST SET,BATTERY AN/PSM-13
1 1 PAOZZ 5935-00-832-4967 SM165137 80063 ADAPTER,CONNECTOR U-240/PSM-13 EA 1
1 2 PAOZZ 5935-00-832-4965 SMC165141 80063 ADAPTER,CONNECTOR U-297/PSM-13 EA 1
1 3 PAOZZ 5935-00-832-4970 SMC165144 80063 ADAPTER,CONNECTOR U-347/PSM-13 EA 1
5
TM11-6625-823-24P
TOP VIEW
EL2YS002
6
SECTION IV TM11-6625-823-24P
NATIONAL STOCK NUMBER AND PART NUMBER INDEX
FIGURE ITEM FIGURE ITEM
STOCK NUMBER NO. NO. STOCK NUMBER NO. NO.
5305-00-054-6653 2 5
5935-00-087-1148 1 4 5935-00-832-4967 1 1
5355-00-616-9659 2 4 5935-00-832-4969 1 8
5935-00-832-4949 1 5 5935-00-832-4970 1 3
5935-00-832-4965 1 2 6625-00-936-5488 2 1
5935-00-832-4966 1 6 6625-00-936-5489 1 9
6625-00-936-5490 1 10
PART FIG ITEM PART FIG ITEM
NUMBER FSCM NO NO NUMBER FSCM NO NO
CW842PSM13 80058 1 10 SMC165138 80063 1 4
MS51957-29 96906 2 5 SMC165141 80063 1 2
MS91525-1 80063 2 4 SMC165142 80063 1 8
SMB16139 80063 1 7 SMC165143 80063 1 5
SMB165140 80063 1 6 SMC165144 80063 1 3
SMB165147 80063 2 1 SMC165146 80063 1 9
SMB165148 80063 2 2 SMC165158 80063 2 3
SMC165137 80063 1 1
7
By Order of the Secretary of the Army:
BERNARD W. ROGERS
General United States Army
Official: Chief of Staff
PAUL T. SMITH
Major General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-51, Organizational maintenance requirements for
AN/PRC-25 and AN/PRR-9, AN/PRT-4.
THE METRIC SYSTEM AND EQUIVALENTS
P I N : 0 2 0 0 0 5-000