Beruflich Dokumente
Kultur Dokumente
MIC Guide
March 2013
Modular Interface Cards (MICs) install into two slots in the front of the ACX4000 router
and provide the physical connections to various network media types. The slots are
labeled 1/0 and 1/1. You can install MICs of different media types on the same router as
long as the router supports those MICs. For complete specifications, see MICs Supported
on ACX Series Routers on page 2
MICs receive incoming packets from the network and transmit outgoing packets to the
network. During this process, each MIC performs framing and high-speed signaling for
its media type. Before transmitting outgoing data packets through the MIC interfaces,
the Packet Forwarding Engine encapsulates the packets received.
The ACX4000 router has two slots on the front of the router that accept MICs. Table 1
on page 2 lists the MICs supported by the ACX4000 router.
ACX-MIC-4COC3-1COC12CE
g006682
0 1 2 3
SDH channelization:
4 STM1 channel
252 E1 channels
NOTE: To extend the life of the laser, when a MIC is not being actively used with any valid links,
take the MIC offline until you are ready to establish a link to another device. For information about
taking a MIC offline, see the request chassis pic offline command in the Junos OS System Basics
and Services Command Reference.
OffNot enabled
GreenOnline with no alarms or failures
YellowOnline with alarms for remote failures
RedActive with a local alarm; router has detected a failure
ACX-MIC-6GE-CU-SFP
g006533
Software release Junos OS Release 12.3x51-D10 and later
10/100/1000BASE-T
Copper interface specificationssee Ethernet 10BASE-T Copper Interface Specifications,
Fast Ethernet 100BASE-T Copper Interface Specifications, and Gigabit Ethernet 1000BASE-T
Copper Interface Specifications
NOTE: To extend the life of the laser, when a MIC is not being actively used with any valid links,
take the MIC offline until you are ready to establish a link to another device. For information about
taking a MIC offline, see the request chassis pic offline command in the Junos OS Operational
Mode Commands.
ActivityIf the LED is blinking green, the port is sending or receiving data; if there is no light,
the port is down or is not active.
LinkIf the LED is yellow, the port link is up; if there is no light, the port links is down.
ACX Series routers support a variety of fixed and pluggable transceivers and network
cables.
To determine which transceivers and network cables are supported in a particular device,
see the topic or guide for your router:
ACX1000 and ACX1100 routers: See Uplink Ports on ACX1000 and ACX1100 Routers
in the ACX1000 and ACX1100 Universal Access Routers Hardware Guide.
ACX2000 and ACX2100 routers: See Uplink Ports on ACX2000 and ACX2100 Routers
in the ACX2000 and ACX2100 Universal Access Routers Hardware Guide.
ACX4000 routers: See the Cables and connectors section for each MIC in the ACX4000
Universal Access Routers MIC Guide.
Fast Ethernet and Gigabit Ethernet Bidirectional SFP Optical Interface Specifications
If the information in the latest release notes differs from the information in the
documentation, follow the Junos OS Release Notes.
To obtain the most current version of all Juniper Networks technical documentation,
see the product documentation page on the Juniper Networks website at
http://www.juniper.net/techpubs/.
Technical product support is available through the Juniper Networks Technical Assistance
Center (JTAC). If you are a customer with an active J-Care or JNASC support contract,
or are covered under warranty, and need post-sales technical support, you can access
our tools and resources online or open a case with JTAC.
JTAC hours of operationThe JTAC centers have resources available 24 hours a day,
7 days a week, 365 days a year.
Find solutions and answer questions using our Knowledge Base: http://kb.juniper.net/
To verify service entitlement by product serial number, use our Serial Number Entitlement
(SNE) Tool: https://tools.juniper.net/SerialNumberEntitlementSearch/
Revision History
Juniper Networks, Junos, Steel-Belted Radius, NetScreen, and ScreenOS are registered trademarks of Juniper Networks, Inc. in the United
States and other countries. The Juniper Networks Logo, the Junos logo, and JunosE are trademarks of Juniper Networks, Inc. All other
trademarks, service marks, registered trademarks, or registered service marks are the property of their respective owners.
Juniper Networks assumes no responsibility for any inaccuracies in this document. Juniper Networks reserves the right to change, modify,
transfer, or otherwise revise this publication without notice.
Products made or sold by Juniper Networks or components thereof might be covered by one or more of the following patents that are
owned by or licensed to Juniper Networks: U.S. Patent Nos. 5,473,599, 5,905,725, 5,909,440, 6,192,051, 6,333,650, 6,359,479, 6,406,312,
6,429,706, 6,459,579, 6,493,347, 6,538,518, 6,538,899, 6,552,918, 6,567,902, 6,578,186, and 6,590,785.