Beruflich Dokumente
Kultur Dokumente
Self-study programme
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
http://scoda-ssp.ru/
As one of its high priority targets, the company koda Auto develops and manufactures products that
are environmentally friendly in all stages of their life cycle.
We place the main emphasis on the selection of recyclable materials. koda vehicles are produced
using progressive technologies in modern production facilities that meet the most rigorous criteria.
Only lead-free electrophoresis (KTL) and water-dilutable paints are used for the corrosion protection
of the painted parts of the vehicle.
The company's strategy is to focus on the reduction in fuel consumption and emissions, therefore
the engines offered by koda Auto comply with the applicable emission standards.
All products of koda Auto meet the laws and regulations on soil and water conservation. This
approach enables vehicles produced by koda to comply with the demands in terms of technology,
safety and quality, as well as fulll the environmental protection requirements.
Thus, koda Auto is committed to maintaining a clean environment, without sacricing the mobility
and customer satisfaction.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
SP76_01
The effort to reduce the environmental impact The Euro 5 standard sets limit values for the most
of vehicles as much as possible, is noticable common pollutants contained in exhaust gases
since the seventies of the last century, when (in grams per kilometer), in particular for diesel
the rst regulations for the reduction of pollutants engines.
contained in exhaust gases came into effect.
A signicant reduction in emissions was primarily
achieved in the last fteen years, due to the intro-
duction of new technologies and the development
in electronics and computer technology.
GB
2
http://scoda-ssp.ru/
CONTENTS
kodaFabia GreenLine II 8
kodaRoomster GreenLine II 13
kodaOctavia GreenLine II 14
kodaYeti GreenLine II 15
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
kodaSuperb GreenLine IIauthorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
unless
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
16
Recuperation 18
Start-stop system 20
GB 3
http://scoda-ssp.ru/
Generation of GreenLine models
kodaFabia GreenLine I
1.4 ltr. TDI PD DPF 59 kW
kodaFabia Combi GreenLine I
kodaOctavia GreenLine I
1.6 TDI CR DPF 77 kW
kodaOctavia Combi GreenLine I
kodaFabia GreenLine II
kodaFabia Combi GreenLine II 1.2 TDI CR DPF 55 kW
kodaRoomster GreenLine II
kodaOctavia GreenLine II
kodaOctavia Combi GreenLine II
kodaYeti GreenLine II 1.6 TDI CR DPF 77 kW
kodaSuperb GreenLine II
kodaSuperb Combi GreenLine II
The GreenLine II models differ from the rst generation by the engines used (see tables), in addition
they are equipped with new systems which play an important role in fuel economy:
Start-Stop
Brake Energy Regeneration
Maxi DOT function (gear recommendation display)
The new second-generation GreenLine ll models kodaRoomster GreenLine II, kodaYeti Green-
Line II and kodaSuperb Combi GreenLine II are being introduced on the market, which were not yet
available in the rst generation.
Due to the restriction specied for the equipment of the GreenLine models, certain items of equipment
cannot be ordered on request (current info available from your dealer).
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability SP76_02
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
GB
4
http://scoda-ssp.ru/
Engine equipment of the GreenLine II models
Technical highlights
4-valve technology
a balance shaft in the crankcase
electromagnetic valve-controlled injectors
injection pressure up to 180 MPa (1800 bar)
turbocharger with variable turbine geometry
exhaust gas recirculation module with integrated
valve of exhaust gas recirculation and exhaust
gas recirculation cooler SP76_17
particle lter with upstream oxidation catalytic
converter
n (min-1)
You will nd the detailed description SP76_18
of the 1.2 ltr./55 kW TDI CR engine
in the Self-Study Programme 80.
GB 5
http://scoda-ssp.ru/
Engine equipment of the GreenLine II models
Technical highlights
4-valve technology
electromagnetic valve-controlled injectors
injection pressure up to 180 MPa (1800 bar)
turbocharger with variable turbine geometry
exhaust gas recirculation module with integrated
valve of exhaust gas recirculation and exhaust
gas recirculation cooler SP76_20
particle lter with upstream oxidation catalytic
converter
50
P (kW)
You will nd the detailed description 0 1000 2000 3000 4000 5000 6000
of the 1.6 ltr./77 kW TDI CR engine
n (min-1)
in the Self-Study Programme 80. SP76_21
GB
6
http://scoda-ssp.ru/
Designation of the GreenLine II models
Designation GreenLine 2
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
SP76_26
All GreenLine ll models, manufactured since the 45th week 2010, will be marked in four points
of the body:
SP76_27
GB 7
http://scoda-ssp.ru/
kodaFabia/Fabia Combi GreenLine II
START-STOP system
GB
8
http://scoda-ssp.ru/
EU5 emission standard
Multifunction display
SP76_16
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
GB with respect to the correctness of information in this document. Copyright by KODA AUTO A. S. 9
http://scoda-ssp.ru/
kodaFabia/Fabia Combi GreenLine II
Aerodynamic improvements
Shorter antenna
Rear spoiler
SP76_25
On the Fabia GreenLine II model, changes were made to reduce the air resistance correction value.
- adaptation of the lower vehicle trim panel, to facilitate the air ow under the vehicle
- seal of the front wheel houses*
- rear spoiler*
- shorter antenna*
- engine hood seal*
- special cover of the radiator fan*
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
- radiator grille, three-quarters covered*
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
GB
10
http://scoda-ssp.ru/
SP76_29
The aerodynamic resistance is also reduced On the standard Fabia models, the radiator
through the face plate of the brake air ducts. The grill is only covered in the upper half, on the
face plates are tted to the plastic trim panels on kodaFabia GreenLine model, the radiator grille
the front wheel houses. is three-quarters covered.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
GB 11
http://scoda-ssp.ru/
kodaFabia/Fabia Combi GreenLine II
Another element that reduces the air resistance correction value on the models kodaFabia Green-
Line II in the Hatchback version is the engine hood seal tted to the front end.
In order to obtain low aerodynamic resistance values, the roof of the Fabia Combi model is not
equipped with frame side rails.
A weight limit is applied to the rst generation of the Fabia GreenLine model as well as to its
successor, which allows the vehicle to be equipped with only as many elements of special equipment
in order to maintain the maximum prescribed unladen weight of the vehicle or the favourable air
resistance correction value Cx. Equipment, which increases the vehicle weight too much, also
increases its fuel consumption and the CO2 emissions contained in the exhaust gases.
On the Fabia GreenLine II model, the value Cx 0.301 is achieved by implementing these measures.
The basic equipment of the Fabia GreenLine II model includes light alloy wheels ANTARES 6Jx15"
and 185/60 R15 tyres with lower rolling resistance.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
GB
12
http://scoda-ssp.ru/
kodaRoomster GreenLine II
SP76_19
Start-Stop system
Brake Energy Regeneration System
Gear recommendation display
Cruise control system
Tyre pressure monitor
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
Light alloy wheels ANTARES 6J xby 15"
unless authorised KODA andAUTO185/60
A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
R15 tyres with lower rolling resistance.
SP76_36
GB 13
http://scoda-ssp.ru/
kodaOctavia/Octavia Combi GreenLine II
SP76_31
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness ofLocation
information inof the
this Copyright by KODA AUTO A. S.
START-STOP
document.
Start-Stop system
Brake Energy Regeneration System
Gear recommendation display
The clear height of the kodaOctavia Green-
Line II model was reduced by 15 mm compared
to the standard models.
195/65 R15 tyres with lower rolling resistance.
SP76_35
GB
14
http://scoda-ssp.ru/
kodaYeti GreenLine II
SP76_30
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
Start-Stop system
Brake Energy Regeneration System
Gear recommendation display
The clear height of the kodaYeti GreenLine ll
model was reduced by 25 mm compared to the
standard models.
205/55 R16 tyres with lower rolling resistance.
SP76_33
* The kodaYeti GreenLine II models are equipped with a 4-x-2 system (front axle drive).
GB 15
http://scoda-ssp.ru/
kodaSuperb/Superb Combi GreenLine II
Start-Stop system
Brake Energy Regeneration System
gear recommendation display
205/55 R16 tyres with lower rolling resistance
additional gear stages
GB
16
http://scoda-ssp.ru/
Rear spoiler
SP76_34
* only on model kodaSuperb
GB 17
http://scoda-ssp.ru/
Recuperation
In order to reduce the fuel consumption and the CO2 emissions, the recuperation function is also
applied in the models Greenline ll. Depending on the driving mode, the electrical energy is supplied
to the vehicle either by the alternator or the power supply is fed by the battery.
The core of the system is the alternator, its output voltage being controlled by an electronic regulator.
The control of the regulator is performed via the engine control unit.
The recuperation system allows to convert the excess kinetic energy of the vehicle into re-usable
electrical energy. This energy is stored in the battery of the vehicle or it is returned to the power supply
system of the vehicle. For vehicles in which the recuperation system is not used, the excess kinetic
energy is converted into heat energy during braking.
ALTERNATOR ELECTRICAL
EL. REGULATOR CONSUMERS
LIN
12V BATTERY
LIN
GATEWAY BDM SP76_50
When braking the vehicle (gear engaged, accelerator pedal in basic position or brake pedal is
operated) the electronic regulator increases the output voltage at the alternator. The voltage
at the alternator is higher than the voltage of the battery, a maximum of 15 V. The alternator ensures
the power supply and at the same time the battery charge. If the voltage potential of the alternator
in the recuperation phase is higher, then the higher electric charge is stored in the battery.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
GB
18
http://scoda-ssp.ru/
Function of the system during acceleration and while maintaining
a constant speed
Current sharing for 12 V on-board voltage
During acceleration of the vehicle or when maintaining a constant speed, the output voltage
of the alternator is lowered by the regulator to a value below the battery voltage (approx. 12 V).
The magnetic eld of the rotor and stator winding of the alternator moves the force vector of the
resistance into the lower range of the load characteristic of the rotating machine. The alternator
will take less mechanical energy from the crankshaft of the combustion engine. The fuel dosage
is adapted to the reduced engine power.
If the BDM unit decides that the battery is sufciently charged, the alternator is completely relieved
by the regulator and the whole power supply system of the vehicle is powered only by the battery.
ALTERNATOR ELECTRICAL
EL. REGULATOR CONSUMERS
LIN
12V BATTERY
LIN
GATEWAY BDM SP76_51
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
The principle of the described recuperation is the change in voltage at the regulator of the alternator,
whereby the energy ow of the alternator/battery is divided depending on the current need
of the vehicle.
The charge status of the battery is monitored electronically (BDM battery data module). The new
battery technology makes it possible to achieve an extremely cyclic resistance and a higher level
of energy efciency. The information about the charge status of the battery is part of the control algo-
rithm of the recuperation function. The control is installed in the engine control unit.
The alternator is an electric, rotating three-phase machine, similar in its principle to the alternator
in a conventional vehicle. The main difference lies in the voltage range (12-15V) of the electronic regu-
lator which is connected to the engine control unit by a LIN communication interface (Local Intercon-
nect Network). On the conventional vehicle, the xed value at the regulator of the alternator is 14.4 V.
Through the use of recuperation, the exhaust emissions are lowered by 2-4 g CO2/km in the NEDC
(New European Driving Cycle).
GB 19
http://scoda-ssp.ru/
Start-stop system
START-STOP system
The START-STOP system is one of the most important technological elements that contributes to the
reduction of fuel consumption on GreenLine II models.
The philosophy of this system is to automatically shut off the engine when the vehicle is stopped,
whenever it is not necessary for the engine to run. The engine restarts automatically whenever the
driver wishes to continue the journey. The system is especially suitable for city trafc. In practice,
it is used when standing at trafc lights or driving in a queue of trafc.
The START-STOP system requires no special operation and works completely automatically. For the
traveler, it means no loss of comfort or the ability to accelerate immediately when the engine is started.
The function of the START-STOP system is performed via the engine control system. The function
is integrated in the software of the engine control unit.
SP76_23
It is possible to operate the START-STOP system with only a few new components.
Some of the existing components had to be adapted for the function of this system.
New components:
push-button switch of the start-stop operation
START-STOP F416
battery monitoring control unit J367
GB
20
http://scoda-ssp.ru/
Operation of the START-STOP system
The START-STOP mode is automatically activated when the engine is started and the vehicle has
reached a speed of at least 3 km/h for about four seconds.
active START-STOP
system
SP76_22
It is decisive for the START-STOP system or for the phase in which the engine is turned off, whether
the charge status of the starter battery allows a restart of the engine. This procedure is referred
to as start voltage prediction. It states if all the properties and values of the engine related to a restart
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
of the engine were evaluated. Therefore, the charge
unless authorised by KODAstatus
AUTO A. of the battery
S. KODA AUTO A. S. is
doesconstantly
not guarantee ormeasured.
accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
Based on the start voltage prediction, it is determined whether the START-STOP operation can be
carried out or specic electrical consumers are switched off in order to maintain the power consump-
tion. This concerns e.g. the seat heating system, the rear window heating and the mirror heating
systems. These systems are switched off before restarting the engine and are blocked for the duration
of the engine start.
GB 21
http://scoda-ssp.ru/
DPF
SP76_13
Function
The exhaust gases pass through a lter body, which consists of many ducts with a faceplate on one
side. The faceplates of the ducts alternate: once the gas enters the duct in the open direction, it must
then pass through its porous walls into an adjacent duct that is open in the direction of the engine.
When the exhaust gases ow through the lter, the soot particles are absorbed by the input ducts,
whereby the gaseous components of the exhaust gases can penetrate the porous walls of the duct.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
SP76_15
GB
22
http://scoda-ssp.ru/
Design
The particle lter consists of a ceramic honeycomb structure based on silicon carbide, which is
enclosed in a metal housing. The ceramic body is divided into several parallel microscopic ducts
with porous walls, whereby these ducts are alternately always closed on one side.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by KODA AUTO A. S. KODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
SP76_14
Silicon carbide is suitable for use in diesel particle lters because of the following properties:
- high mechanical strength
- very good thermal shock resistance
- temperature resistance and conductivity
- high wear resistance
You will nd a detailed description of the function of the diesel particle lter in the
Self-Study Programme 60.
GB 23
http://scoda-ssp.ru/
76
Overview of the previously edited self-study programmes
No. Designation No. Designation
1 Mono-Motronic 50 kodaSuperb; automatic gearbox 01V
2 Central locking 51 2.0 ltr./85 kW petrol engine with balancing shafts
3 Vehicle alarm and two-stage intake manifold
4 Working with wiring diagrams 52 kodaFabia; 1.4 ltr. TDI engine with unit injection
5 KODA FELICIA system
6 Safety of the KODA vehicles 53 kodaOctavia; Vehicle presentation
7 Principles of ABS - were not published 54 kodaOctavia; Electrical Components
8 ABS - FELICIA 55 FSI petrol engines; 2.0 ltr./110 kW and 1.6 ltr./85
9 System for safe start-up with transponder kW
10 Air conditioning in the vehicle 56 Automatic gearbox DSG-02E
11 Air conditioning FELICIA 57 Diesel engine; 2.0 ltr./103 kW TDI with pump-nozzle
12 1.6 engine - MPI 1AV units, 2.0 ltr./100 kW TDI with pump-nozzle units
13 Four-cylinder diesel engine 58 kodaOctavia, Chassis and electromechanical
14 Power-assisted steering power-assisted steering
15 KODA OCTAVIA 59 kodaOctavia RS, 2.0 ltr./147 kW FSI turbo engine
16 1.9 ltr. TDI diesel engine 60 2.0 ltr./103 kW 2V TDI diesel engine; particle lter
17 KODA OCTAVIA Convenience electronic system with additive
18 KODA OCTAVIA Manual gearbox 02K, 02J 61 Radio navigation systems in the koda
19 1.6 ltr. and 1.8 ltr. petrol engines 62 kodaRoomster; Vehicle presentation part l
20 Automatic gearbox - fundamentals 63 kodaRoomster; Vehicle presentation part ll
21 Automatic gearbox 01M 64 kodaFabia II; Vehicle presentation
22 1.9 ltr./50 kW SDI, 1.9 ltr./81 kW TDI diesel engines 65 kodaSuperb II; Vehicle presentation part l
23 1.8 ltr./110 kW and 1.8 ltr./92 kW petrol engines 66 kodaSuperb II; Vehicle presentation part ll
24 OCTAVIA, CAN BUS 67 Diesel engine; 2.0 ltr./125 kW TDI with Common
25 Protected
OCTAVIA - CLIMATRONIC
by copyright. Rail injection system
Copying for private or commercial purposes, in part or in whole, is not permitted
26 unless
OCTAVIA KODA AUTO
authorised-bysafety of the A. S. KODA AUTO A. S. does not guarantee or accept any liability
vehicle 68
with respect to the correctness of information in this document. Copyright by KODA AUTO A. S.
1.4 ltr./92 kW TSI petrol engine with turbocharger
27 OCTAVIA - 1.4 ltr./44 kW engine and gearbox 002 69 3.6 ltr./191 kW FSI petrol engine
28 OCTAVIA - ESP - fundamentals, design, function 70 All-wheel drive with Haldex coupling of the lV.
29 OCTAVIA 4 x 4 - all-wheel drive generation
30 2.0 ltr. 85 kW and 88 kW petrol engines 71 kodaYeti; Vehicle presentation part l
31 Radio navigation system - design and functions 72 kodaYeti; Vehicle presentation part ll
32 KODA FABIA - technical information 73 LPG system in koda vehicles
33 KODA FABIA - electrical systems 74 1.2 ltr./77 kW TSI petrol engine with turbocharger
34 KODA FABIA - electro-hydraulic power-assisted 75 7-speed dual-clutch automatic gearbox 0AM
steering 76 Green Line vehicles
35 1.4 ltr. - 16 V 55/74 kW petrol engines
36 KODA FABIA - 1.9 ltr. TDI Unit injection
37 Manual gearbox 02T and 002
38 kodaOctavia; model 2001
39 Euro-On-Board-Diagnosis
40 Automatic gearbox 001
41 6-Speed gearbox 02M
42 kodaFabia - ESP
43 Exhaust emissions
44 Extended service intervals
45 Three-cylinder petrol engines 1.2 ltr.
46 kodaSuperb; Vehicle presentation; part l
47 kodaSuperb; Vehicle presentation; part ll
48 kodaSuperb; 2.8 ltr./142 kW V6 petrol engine
49 kodaSuperb; 2.5 ltr./114 kW TDI V6 diesel engine
http://scoda-ssp.ru/