Beruflich Dokumente
Kultur Dokumente
20000 A
IOUT= 0 .. 20 mA
For the electronic measurement of currents: DC, AC, pulsed, mixed,
with galvanic isolation between the primary circuit (high power) and (T-RMS DC)
the secondary circuit (electronic circuit).
Electrical data
Primary nominal Primary current Type
current rms measuring range
Features
IPN (A) IPM (A)
Hall effect measuring principle
IC Current consumption 50 mA
IP Overload capability 30,000 A
RIS Isolation resistance @ 500 VDC > 1,000 MW Advantages
IOUT Output current @ IPN, TA = 25C 0 .. 20 mA
Easy mounting
ratings range
Accuracy - Dynamic performance data High immunity against external
Traction
Note: 1)
Linearity data exclude the electrical offset.
2)
To avoid excessive core heating
3)
Please consult characterisation report for more technical details and
application advice.
4)
Regarding compliance towards IEC 61000-4-3 ( EN 50121-3-2 (2006)):
Output is avove to 50% of Isn between 300 MHz and 500MHz with a field
intensity of 20 [V/m]. Page 1/3
111017/10 LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice. www.lem.com
Current Transducer HAZ 4000..20000-SRI
Isolation characteristics
Applications examples
Safety
When operating the transducer, certain parts of the module can carry hazardous
voltage (eg. primary busbar, power supply).
Ignoring this warning can lead to injury and/or cause serious damage.
This transducer is a build-in device, whose conducting parts must be inaccessible
after installation.
A protective housing or additional shield could be used.
Main supply must be able to be disconnected.
Page 2/3
111017/10 LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice. www.lem.com
Dimensions HAZ 4000..20000-SRI (in mm. 1 mm = 0.0394 inch)
FUJICON F2023A
6 1
6 5 4
T.P. GND OUTPUT
3
0V
2
-Vc
1
+Vc
Connection Circuit
50
48
HAZ 10000-SRI
HAZxxx-SRI
1 +Vc
250 +/-1.5
2 -Vc
235
3 0V
4-D6
4 OUTPUT
T.P.
6 (Internal test point used
during factory calibrations)
160 +/-1.5
42 +/-2
162 +/-2
125
Operation Principle
75
+Vc
M5
7.5
4...OUTPUT
5...GND
6...T.P.
Mechanical characteristics
General tolerance 0.5 mm
Aperture for primary conductor 162 mm x 42 mm
( 2 mm)
Transducer fastening 4 x M5
(not supplied)
Recommended fastening torque < 5 Nm
Connection of secondary Fujicon F2023A
(6 terminals)
Remarks
Temperature of the primary conductor should not exceed
120C.
Page 3/3
111017/10 LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice. www.lem.com