Beruflich Dokumente
Kultur Dokumente
1 Wireless Power Transfer: This circuit mainly works on the principle of mutual
inductance. This circuit may be used as wireless power transfer circuit, wireless
mobile charger circuit, wireless battery charger circuit, etc.
2 Street Lights that Glow on Detecting Vehicle Movement: This article describes
about the circuit that switches the street lights on detecting vehicle movement and
remains off after fixed time. This system controls the street lights using light
dependent resistor and PIR sensor.
3 DTMF Based Home Automation System Circuit: This is a simple and very
useful circuit in our real life named DTMF controlled home appliances system. It
helps to control the home appliances using DTMF technology.
4 RFID based Attendance System: This simple RFID based attendance system is
designed using ATmega8 Microcontroller and is mainly used in educational
institutions, industries, etc. where authentication is needed.
This is a simple spy robot circuit which can be controlled by the remote. The
maximum controllable range is 125 meters. It is used to observe the behavior of
wild animals where human beings cannot reach.
9 Wireless Electronic Notice Board using GSM: This wireless electronic notice
board using GSM Technology and microcontroller circuit is used to display the data
on LCD whatever we sent from the mobile.
11 Metal Detector Robotic Vehicle: Land mines buried under the ground causes
threat to the lives and affect the economy of the nation. Detection and removing of
these mines manually is a dangerous task. So, we use a metal detection robot which
works on RF technology.
12 Car Parking Guard Circuit Using Infrared Sensor: This circuit helps the person
in the driving seat in such a way that it gives an alarm if there is any obstacle or a
wall while parking or while driving in reverse. It is very useful in our real life.
13 Wireless Switch Circuit using CD4027: This is a simple circuit which needs no
physical contact with the appliance. In this circuit, all you need is to pass your hand
above LDR to ON or OFF the switch.
14 Cell Phone Detector: This is a simple circuit which helps to detect the
presence of an activated cell phone by detecting the signals in the frequency range
of 0.9 to 3GHz. It helps in mobile phones tracking which are used for spying.
20 Interfacing GPS with 8051 Microcontroller: In this interfacing of GPS with 8051
circuit, GPS module calculates the position by reading the signals that are
transmitted by satellites.
21 IR Audio Link Circuit: This simple IR audio link circuit is used to transmit audio
signals wirelessly. This IR audio link is able transmit audio signals up to 4 meters.
22 GSM Interfacing with 8051: The main principle of this circuit is to interface a
GSM modem with the microcontroller. The microcontroller used is AT89C51
microcontroller.
23 Wireless AC/DC Device control for Appliances Using Remote Control:A simple,
small and cost effective equipment for device control is developed in this project. It
is a microcontroller based project, which can control both AC and DC appliances
with the help of a remote control. It is an RF based communication, so that there is
no need for line-of sight contact between the transmitter and the receiver.
28 Two-way Wireless Data Messaging System for Rural Areas using ZigBee
Technology:Using this project, data can be transmitted securely using ZigBee
technology for the application in rural areas. The communication can be two-way
communication and the security of the data is of no concern as the protocol of
ZigBee communication allows encryption and decryption of the data
33 Intelligent Wireless Controller for Oil Wells:The monitoring at oil pump units is
mainly manual. In this project, a wireless monitor and control system for oil
pumping unit in oil wells is designed. It is a microcontroller based system with
ZigBee transmitter and receiver. A network of sensors include, level sensor, voltage
sensor and current sensor will form a wireless sensor network that can be monitored
remotely.
40 Centralized Monitoring System for Taxies:Taxis are one of the common modes
of transportation in cities. For the safety of the passengers and accurate information
about distance and fare, a system is proposed for monitoring taxis. Using this
system, police can monitor all the taxis without any hassle. It is based on GPS
technology and also uses GSM for sending messages to the customer.
61 RF based tsunami detection and remote alert system with 60dB siren:The aim
of this project is to design a system which helps in tsunami detection and alerts a
remote area. A pressure sensor, which is anchored to the sea floor, is used to read
the pressure of the water. This data is transmitted to the control station over RF
communication link. The advantage of RF communication is there is less
interference from other signals.
69 ARM Hardware Platform for Vehicular Monitoring and Tracking:The aim of this
project is to monitor and track different parameters like location, speed etc. of a
vehicle using the GPS module. The tracked data can be sent to a control or monitor
station and also to a registered mobile via SMS using GSM technology. Such system
can be installed in heavy vehicles like cargo trucks to small cars and bikes for the
purpose of security, tracking and surveillance.
70 Air Pollution Monitoring System Using ZigBee and GPS Module:The degree of
automation in all sectors in increasing rapidly with the growth in technology. In the
proposed system, a wireless sensor network of gas sensors are used to monitor
different pollutants like Carbon dioxide, Carbon monoxide, Nitrogen dioxide and
Sulphur dioxide. A ZigBee based communication is used to transfer this data to a
control station along with the locations captured from GPS module.
72 Assistance for Dumb and Illiterates in Airline Based on Touch Screen and
ZigBee:A touch screen based assistance system for the dumb and illiterates
traveling in an airline is designed here. Services like coffee, tea, drinks, food etc.
can be requested using this system. The communication between the interface and
the control unit (located at the air hostess) is done through ZigBee protocol. Both
the transmitter and receiver sections require microcontrollers.