Beruflich Dokumente
Kultur Dokumente
When we build the 10 LEDs running light for hobby. Often use IC-4017 CMOS-IC.
This really neat chip contains a counter and a decoder circuit, that can show a
single output pin for each count from 0 to 9.
And also use to build all kinds of timer, LED sequencers and controllers circuits.
The power supply range of 3 volts to 16 volts and Maximum power supply voltage
at pin 1 must not much than 18 volts.
When 1 logic, the clock input is stop, and the counter does nothing even when
clock pulse arrive.
If they are noisy the counter may advance two or more times during each clock
pulse.
5.) Pins 1-7 and 9-11 are the decoded output pins.
The active count pin goes high and all others remain low.
6.) Pin 12 is Carry output, for the clock input of an additional counter or an
external circuit that the count is complete.
This the circuit light led flashing with show of 10 LED. By use integrated number
circuit CD4017 perform be Decade Counter/Divider with 10 Decoded Outputs.
Which it is integrated digital circuit CMOS then use the power supply about
9VDC. For a signal input continue the circuit can produce general frequency may
use IC NE555 all right.